1997 Subaru OUTBACK: complaints, problems and recalls

2.5 LITER ENGINE BLOCK CRACKED, CAUSING REPEATED INSTANCES OF OVERHEATING REQUIRING STOPPING IN DANGEROUS TRAFFIC SITUATIONS AND EVENTUAL REPLACEMENT OF BLOCK AT OWNER EXPENSE. TS

Owner-reported narrative. 68,526 miles reported. Look up ODI 10000526 at NHTSA ↗

WHEN THE BRAKE WAS APPLIED, THE VEHICLE EXPERIENCED EXTENDED STOPPING DISTANCE.*JB

Owner-reported narrative. Look up ODI 10007512 at NHTSA ↗

WHILE DRIVING DOWN ROUTE. 495 AT 65 MPH DURING THE 6:30-6:45 A.M. RUSH HOUR, (PRIMARILY LARGE TRUCKS BARRELING DOWN THE HIGHWAY), THE HOOD OF MY CAR POPPED OPEN, SHATTERING MY WINDSHIELD, DENTING AND CAUSING THE HOOD TO HAVE TO BE REPLACED, DENTING THE ROOF, AND CAUSING THE REAR VIEW MIRROR TO FALL OFF. WITH THE GRACE OF GOD, I WAS ABLE TO SAFELY MANEUVER THE VEHICLE OFF THE HIGHWAY. THE MINOR INJURIES I SUSTAINED WERE TO MY UPPER BACK AND LEFT SIDE OF MY NECK. THESE INJURIES ARE NOT DISABLING, BUT PAINFUL AND ANNOYING. I DID NOT SEEK MED…

Owner-reported narrative. Look up ODI 10014435 at NHTSA ↗

CONSUMER STATES THAT LATCHES, LOCKS AND HINGES ARE RUSTED. DEALER STATED NOTHING WE COULD DO. VEHICLE'S WARRANTY EXPIRED. *AK

Owner-reported narrative. Look up ODI 10032122 at NHTSA ↗

VEHICLE FUEL FILL TUBE ROTTED RESULTING IN A FUEL LEAK. *MR THERE WAS A PUDDLE OF GAS IN THE GARAGE. THE CONSUMER WAS TOLD THAT IF THE TANK WAS KEPT ON 1/2 TO 3/4 FULL, THE LEAK WOULD CEASE. THE MECHANIC HAD JUST FIXED THE SAME PROBLEM ON A SUBARU, A WEEK PRIOR AND HAD SINCE REPEATED THAT TASK AT LEAST 4 TIMES. THE CONSUMER REQUESTED THAT SUBARU COVER THE COSTS INCURRED. *SCC ALSO THE WIPER BLADES WERE REPLACED. *JB

Owner-reported narrative. Look up ODI 10037833 at NHTSA ↗

A THICK FILM COVERED THE HEADLIGHTS CAUSING THE HEADLIGHTS TO BECOME DIM. *AK

Owner-reported narrative. Look up ODI 10041901 at NHTSA ↗

POWER BRAKES FAIL TO FUNCTION IMMEDIATELY AND SHORTLY AFTER (WITHIN ABOUT 5 MINUTES) AFTER COLD START IN TEMPERATURES BELOW 10 DEGREES F. BRAKE PEDAL REMAINS HIGH AND STIFF WITH LITTLE TO NO TRAVEL DISTANCE INDICATING NO POWER TO POWER BRAKE SYSTEM BUT BRAKE PEDAL APPARENTLY TRAVELS ENOUGH DISTANCE TO ALLOW SHIFTING OUT OF PARK. USER REMEDY IS TO ALLOW MORE THAN 5 MINUTES TO WARM AND VERIFY BRAKE PEDAL TRAVELS NORMAL DISTANCE INDICATING POWER BRAKE SYSTEM IS FUNCTIONING BEFORE SHIFTING OUT OF PARK. OTHER REMEDY IS TO SHARPLY DEPRESS BRAKE PE…

Owner-reported narrative. 60,000 miles reported. Look up ODI 10054620 at NHTSA ↗

THE ENGINE SEALS OF THE MAIN CAM SHAFT FAILED AND CAUSED THE ENGINE TO LEAK OIL. THE DEALER REPLACED THE SEALS AND THE TIMING BELT. PLEASE PROVIDE FURTHER DETAILS. *NM

Owner-reported narrative. 60,000 miles reported. Look up ODI 10057602 at NHTSA ↗

Reported: 2001-06-25 (June 25, 2001)

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH FRONT COIL SPRINGS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW YORK, NEW JERSEY, NEW HAMPSHIRE, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS WERE PRODUCED WITH POOR PAINT QUALITY WHICH, AFTER CONTINUED EXPOSURE TO CORROSIVE SALT, CAN RESULT IN BREAKAGE OF THE SPRING.

Consequence: DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE. SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Remedy: DEALERS WILL NOTIFIY CUSTOMERS TO BRING THEIR VEHICLE TO AN AUTHORIZE DEALERSHIP TO HAVE A SPRING GUARD INSTALLED ON BOTH FRONT STRUTS TO PREVENT TIRE PUNCTURE AND REPLACE ANY BROKEN SPRINGS FREE OF CHARGE. OWNER NOTIFICATION BEGAN SEPTEMBER 18, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUBARU AT 1-800-782-2783.

Reported: 1998-02-20 (February 20, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE THROTTLE SHAFT BALL BEARING ON THE SENSOR SIDE OF THE THROTTLE BODY ASSEMBLY WAS NOT INSTALLED IN CERTAIN THROTTLE BODIES.

Consequence: OPERATION OF A VEHICLE WITH A MISSING THROTTLE SHAFT BEARING CAN EVENTUALLLY LEAD TO AN INCOMPLETE RETURN OF THE THROTTLE VALVE RESULTING IN A HIGH IDLING CONDITION.

Remedy: DEALERS WILL INSPECT THE THROTTLE BODY AND REPLACE THE THROTTLE ASSEMBLY IF THE BEARING IS MISSING.

Reported: 1998-02-20 (February 20, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. DUE TO POOR WELDS, IGNITION KEYS CAN STICK, SHIFT LEVERS/LINKAGES CAN BREAK AND SHIFT LEVERS CAN MOVE.

Consequence: THIS CONDITION CAN CAUSE UNEXPECTED MOVEMENT OF THE VEHICLE INCREASING THE RISK OF A CRASH OR PROPERTY DAMAGE.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION SHIFT LEVER ASSEMBLIES (EXCEPT THE HANDLE GRIP).

Reported: 1998-05-04 (May 4, 1998)

VEHICLE DESCRIPTION: PASSENGER STATION WAGON, SEDAN AND SPORT UTILITY VEHICLES. DUE TO IMPROPER WELDING, FRACTURES CAN OCCUR ON THE SUPPORT BRACKET OF THE FRONT TRANSVERSE LINK.

Consequence: SUCH FRACTURES CAN RESULT IN PARTIAL OR COMPLETE SEPARATION OF THE BRACKET CAUSING A FAILURE OF THE LOWER SUSPENSION MOUNTING, LEADING TO A LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL INSPECT AND REPLACE IF NECESSARY THE FRONT SUSPENSION SUPPORT BRACKETS.