2015 Ram 3500: complaints, problems and recalls

TL*THE CONTACT OWNS A 2015 DODGE RAM 3500. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THERE WAS AN STRONG ODOR OF DIESEL FUEL PRESENT INSIDE THE CABIN OF THE VEHICLE. THE CONTACT MENTIONED THAT THE OCCUPANTS IN THE VEHICLE WOULD BECOME ILL DUE TO THE STRONG ODOR. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE CONTACT THEN HAD AN AIR QUALITY TESTING FIRM EXAMINE THE VEHICLE AND IT WAS DETERMINED THAT THE CARBON MONOXIDE LEVELS WERE MORE THEN 9 PARTS PER MILLION INSIDE THE CABIN …

Owner-reported narrative. 590 miles reported. Look up ODI 10704471 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 DODGE RAM 3500. THE CONTACT STATED THAT THE RADIO FAILED IN THE VEHICLE. THE PART WAS UNAVAILABLE TO REPAIR THE VEHICLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO HAVE THE PART AVAILABLE FOR THE REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 11,000.

Owner-reported narrative. 11,000 miles reported. Look up ODI 10734315 at NHTSA ↗

THIS IS A PARTICULARLY DANGEROUS SITUATION BECAUSE THERE IS NO METHOD TO KNOW, IN ADVANCE, THE FACTORY INTEGRATED TRAILER BRAKE MODULE (ITBM) WILL FAIL TO PROVIDE FULL VOLTAGE TO THE ELECTRIC TRAILER BRAKES I ATTACHED MY 13,000 POUND FIFTH WHEEL TRAILER TO MY TRUCK AND FOLLOWING THE ITBM SETUP STEPS IN THE OWNERS' MANUAL, THE RESULTS WERE AS EXPECTED. THERE WERE NO WARNINGS OR INDICATORS SIGNALING AN ISSUE WITH THE ITBM'S ABILITY TO APPLY THE TRAILER'S ELECTRIC BRAKES. ON TYPICAL CITY/URBAN DRIVING THE BRAKING EFFORT FROM THE TRAILER WAS AS…

Owner-reported narrative. 2,234 miles reported. Look up ODI 10746286 at NHTSA ↗

THE INTEGRATED TRAILER BRAKE CONTROL IN THE 2015 RAM TRUCKS DOES NOT PROVIDE ADEQUATE BRAKE CONTROL TO THE TRAILER BRAKES. I TRADED IN A 2013 RAM 3500 AND THE INTEGRATED CONTROLLER ALLOWED ME TO SET UP THE BRAKES SO I COULD LOCK THE TIRES UP, THEN I WOULD BACK THE VOLTAGE DOWN SLIGHTLY FROM THERE TO GET MAXIMUM BRAKING PERFORMANCE FROM THE TRAILER. WITH THE NEW TRUCK, THERE WASN'T THE ABILITY TO GET MUCH BRAKING AT ALL. DEALERS ARE TELLING THOSE WITH THE SAME TRUCKS, THAT IT IS WORKING AS DESIGNED AND THERE ISN'T A PROBLEM. MONDAY, AUGUST 1…

Owner-reported narrative. 405 miles reported. Look up ODI 10749880 at NHTSA ↗

MOTOR GONE AND DON'T HAVE KNOW REPLACEMENT.

Owner-reported narrative. Look up ODI 10760347 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 DODGE RAM 3500. WHILE DRIVING 55 MPH AND HAULING A TRAILER, THE STEERING WHEEL BEGAN TO TURN INDEPENDENTLY COUNTER CLOCKWISE AND BLOCKED THE INSTRUMENT PANEL. THE CONTACT PULLED THE VEHICLE OVER, LOOKED UNDERNEATH, AND NOTICED SOME BOLTS WERE LOOSE FROM THE STEERING CABLE. THE CONTACT STATED THAT THE BOLTS WERE TIGHTENED MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT DUPLICATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 22,779....UPDATED 12/29/15 *BF THE CONS…

Owner-reported narrative. 22,779 miles reported. Look up ODI 10762090 at NHTSA ↗

I HAVE THE INTEGRAL TRAILER BRAKE CONTROLLER ON MY TRUCK AND I HOOKED UP TO MY CAMPER FOR THE FIRST TIME WITH THE NEW TRUCK, [THE TRAILER BRAKES WORKED FINE WITH THE TRUCK THAT I REPLACED] I HAD VERY LIMITED BRAKING POWER ON TRAILER BRAKES, I DID SOME TESTS ON THE TRAILER BRAKES FIRST AND FOUND THAT THEY ARE WORKING PROPERLY, THEN I DID A TEST ON THE BRAKE CONTROLLER AND FOUND OUT THE TRAILER BRAKE CONTROLLER IS ONLY PUTTING OUT AROUND 9 VOLTS WHEN SET TO MAXIMUM GAIN AND FULLY APPLIED, IT SHOULD BE 12 VOLTS OR HIGHER, I TOOK IT TO THE DEALER …

Owner-reported narrative. 206 miles reported. Look up ODI 10763019 at NHTSA ↗

WHEN TOWING MY 13000 POUND TRAILER, I NOTICED THAT THE ELECTRONIC TRAILER BRAKE CONTROLLER IN MY TRUCK WILL PROVIDE SUFFICIENT BRAKING POWER TO STOP AT SLOWER SPEEDS. HOWEVER, WHEN A HARDER/FASTER STOP, SUCH AS WHEN I WAS TRAVELING AT 45-50 MPH IS REQUIRED THERE IS NOT SUFFICIENT BRAKING TO THE TRAILER. I WAS NOT ABLE TO STOP AS QUICKLY AS I SHOULD HAVE. I TESTED THE VOLTAGE ON THE CONTROLLER WITH THE SETTINGS TO MAXIMUM (GAIN AT 10 AND MANUAL SLIDER TO 100%) AND WAS ONLY GETTING 7.5 VOLTS. THE READING SHOULD BE CLOSER TO 12 VOLTS. THE BRAKES …

Owner-reported narrative. 4,050 miles reported. Look up ODI 10766411 at NHTSA ↗

Reported: 2015-07-22 (July 22, 2015)

Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, and 3500 trucks manufactured June 20, 2012, to January 26, 2015. In the affected vehicles, the side impact sensor calibrations may be overly sensitive, and as a result, the side air bag inflatable curtains and seat air bags may unexpectedly deploy and the seat belt pre-tensioners may activate.

Consequence: Air bags that unexpectedly deploy increase the risk of a crash or injury.

Remedy: Chrysler will notify owners, and dealers will update the Occupant Restraint Control module calibration, free of charge. The recall began on September 8, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R23.

Reported: 2015-07-23 (July 23, 2015)

Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.

Consequence: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.

Remedy: Chrysler will notify and mail affected owners a USB drive that includes a software update that eliminates the vulnerability, free of charge. Optionally, owners may download the update to their own USB drive from http://www.driveuconnect.com/software-update/ or take their vehicle to a Chrysler dealer for immediate installation. In an effort to mitigate the effects of this security vulnerability, Chrysler has had the wireless service provider close the open cellular connection to the vehicle that provided unauthorized access to the vehicle network. This measure may not have been implemented on all vehicles and does not address access by other means that will be remedied by the software update. The recall began on August 25, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R40.

Reported: 2016-07-26 (July 26, 2016)

Chrysler (FCA US LLC) is recalling certain model year 2015 RAM 2500 trucks, and RAM 3500 trucks and cab chassis. The affected vehicles may have inadequate welds securing the front track bar frame brackets, possibly resulting in the bracket components separating from the frame.

Consequence: If the bracket components separate from the frame, the vehicle may have a reduced response to steering input, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will weld on a new track bar frame bracket or replace the frame of the vehicle, free of charge. The recall began on September 14, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S58.

Reported: 2017-05-09 (May 9, 2017)

Chrysler (FCA US LLC) is recalling certain model year 2013-2016 Ram 1500, Ram 2500, and 2014-2016 Ram 3500 vehicles. Certain driving conditions, such as driving off-road or debris striking the vehicle may cause the roll rate sensor to trigger a fault within the Occupant Restraint Controller (ORC). If this fault occurs, the rollover side curtain air bag and the seat belt pretensioner will be disabled from deploying.

Consequence: If the rollover side curtain air bags and seat belt pretensioners are disabled, there is an increased risk of injury to the vehicle occupants in the event of a crash that necessitates activation of these safety systems.

Remedy: Chrysler will notify owners, and dealers will update the ORC software, free of charge. The recall began June 26, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T25.

Reported: 2017-08-10 (August 10, 2017)

Streetcar ORV LLC, dba American Expedition Vehicles (AEV) is recalling certain 2013-2017 RAM 2500 and 3500 heavy duty trucks, modified by AEV to be equipped with cast aluminum Katla 8.5" road wheels. The outer surface of the wheel may fracture, resulting in rapid air loss.

Consequence: If the wheel fractures, a loss of vehicle control can occur, increasing the risk of a crash.

Remedy: AEV will notify owners, and dealers will replace the wheels with wheels of similar value, free of charge. The recall began on August 30, 2017. Owners may contact AEV customer service at 1-248-926-0256 extension 500.

Reported: 2017-09-12 (September 12, 2017)

Chrysler (FCA US LLC) is recalling certain 2013-2017 RAM 2500, 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles, equipped with Cummins 6.7L Turbo Diesel engines that have Concentric-brand water pumps without a vent hole. These water pumps may leak coolant.

Consequence: The leaking water pump can increase the risk of an engine compartment fire.

Remedy: Chrysler will notify owners, and dealers will replace the water pumps, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T51.

Reported: 2017-12-20 (December 20, 2017)

Chrysler (FCA US LLC) is recalling certain 2016-2017 Ram 3500 Cab Chassis with a Gross Vehicle Weight Rating (GVWR) of less than 10,000 lbs, 2011-2017 Ram 3500, 4500 and 5500 Cab Chassis vehicles, 2009-2017 Ram 1500 and 2010-2017 Ram 2500 and 3500 pickup trucks, all equipped with a column shifter. Pushing the brake pedal for prolonged periods when the vehicle is running and in PARK may cause the Brake Transmission Shift Interlock (BTSI) pin to stick in the open position. With the pin in the open position, the transmission can be shifted out of PARK into any gear without pushing the brake pedal or having the key in the ignition.

Consequence: Being able to shift the transmission without pushing the brake pedal and/or without a key in the ignition can increase the risk of an unintended vehicle rollaway that may result in personal injury or a crash.

Remedy: Chrysler will notify owners, and dealers will update the vehicle software, inspect the BTSI, and, as necessary, replace it, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T79.

Reported: 2017-12-21 (December 21, 2017)

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.

Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.

Reported: 2018-05-17 (May 17, 2018)

Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.

Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.

Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.

Reported: 2018-07-27 (July 27, 2018)

Chrysler (FCA US LLC) is recalling certain 2015-2017 RAM 1500, 2500, and 3500 pickup trucks equipped with a power locking tailgate and either a 5 foot, 7 inch or 6 foot, 4 inch bed. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.

Consequence: If the tailgate latch releases and the tailgate opens while driving, cargo may fall out, creating a road hazard and increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will repair the vehicle, free of charge. The recall began September 17, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U74.

Reported: 2019-01-25 (January 25, 2019)

Chrysler (FCA US LLC) is recalling certain 2013-2018 Ram 3500 and 2014-2018 Ram 3500 Chassis Cab and Ram 2500 vehicles. The outboard steering linkage jam nut may loosen, allowing one end of the drag link to separate.

Consequence: A drag link separation can cause a loss of steering control, increasing the risk of crash.

Remedy: Chrysler will notify owners, and dealers will check the steering linkage jam nut tightness, replacing the drag link assembly or welding the nut to the adjuster sleeve, free of charge. The recall began March 22, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is V06.

Reported: 2019-05-09 (May 9, 2019)

Chrysler (FCA US LLC) is recalling certain 2015-2017 Ram 1500, 2500 and 3500 pickup trucks equipped with an 8 foot bed and a power locking tailgate. Chrysler is also recalling all 2013-2014 and 2018 Ram 1500, 2500 and 3500 pickup trucks built before April 1, 2018 with a 6 or 8 foot bed and a power locking tailgate. On August 29, 2019 Chrysler expanded the recall to include an additional 693,128 model year 2013-2014 Ram 1500, 2500 and 3500 pickup trucks. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.

Consequence: If the tailgate opens while the vehicle is being driven, cargo may fall out the vehicle and create a road hazard, increasing the risk of crash.

Remedy: Chrysler will notify owners, and dealers will repair the tailgate latch, free of charge. The recall began May 23, 2019. Chrysler is expected to notify owners of the expanded population on October 18, 2019. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's number for this recall is V44. Note: 2015-2017 MY Ram 1500 pickup trucks with truck beds other than 8 foot, are currently covered under NHTSA recall 18V-486 for this issue.

Reported: 2021-05-27 (May 27, 2021)

Chrysler (FCA US, LLC) is recalling certain 2012-2021 RAM 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles. Incorrect information in the Service and Owner's Manuals may cause the flanged lug nuts to be over-tightened, which could result in a broken wheel stud and possible wheel separation.

Consequence: Wheel separation can cause a vehicle crash.

Remedy: Dealers will update the torque specification in the owner's manual and other published service documents. Dealers will also inspect the vehicle's wheel studs, replacing them if necessary, free of charge. Owner notification letters were mailed on November 30, 2021. Campaign Y36 owner notification letters were mailed on November 30, 2021. Campaign Y26 owner notification letters were mailed on December 1, 2021. Owners may contact FCA US customer service at 1-800-853-1403. FCA US's numbers for this recall are Y26 and Y36.

Reported: 2021-08-12 (August 12, 2021)

Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

Consequence: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

Remedy: Dealers will inspect and replace as necessary, the SABIC assemblies, free of charge. Interim owner notification letters were mailed on October 4, 2021. Owner notification letters were mailed on May 26, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y55.