2003 Porsche BOXSTER: complaints, problems and recalls

POWER STEERING FAILURE, FLUID LEAK. *JB

Owner-reported narrative. 8,000 miles reported. Look up ODI 10039287 at NHTSA ↗

SECOND GEAR IN THE TRANSMISSION BROKE. *AK

Owner-reported narrative. 12,000 miles reported. Look up ODI 10118005 at NHTSA ↗

DT*: THE CONTACT STATED WHILE DRIVING 20-25 MPH, THE VEHICLE ACCELERATED ON ITS OWN CAUSING THE CONTACT TO LOSE CONTROL WHICH RESULTED AN ACCIDENT. THERE WERE NO PROBLEMS WITH THE VEHICLE PRIOR TO THIS INCIDENT. THERE WERE NO LIGHTS ILLUMINATED ON THE DASH. THE VEHICLE FINALLY HIT A CURB CAUSING EXTENSIVE DAMAGE TO THE VEHICLE. THE DRIVER WAS INJURED, BUT HASN'T GONE TO THE HOSPITAL. THERE WAS A POLICE REPORT FILED. THE AIR BAGS ALSO DID NOT DEPLOY.

Owner-reported narrative. 18,000 miles reported. Look up ODI 10161053 at NHTSA ↗

1. I PURCHASED THIS CAR NEW. IT IS MY DAILY DRIVER. ONLY SERVICED MY PORSCHE MECHANICS. IT HAD 32,500 MILES AT TIME OF FAILURE. AFTER LEAVING A DOCTOR'S APPOINTMENT, I NOTICED AN UNUSUAL SOUND COMING FROM THE ENGINE COMPARTMENT. NOT VERY LOAD. I THOUGHT IT HAD CAUGHT A PIECE OF DEBRIS IN THE BELT SYSTEM. DROVE IT SLOWLY HOME, AND THE SOUND GOT PROGRESSIVELY LOUDER. THE NEXT MORNING THERE WAS A PUDDLE OF OIL UNDER THE CAR. I CALLED THE PORSCHE DEALER IN MOBILE, AL FOR A TOW TRUCK. 2. I WAS TOLD BY THE PORSCHE SERVICE MANAGER THAT THE…

Owner-reported narrative. 32,500 miles reported. Look up ODI 10358136 at NHTSA ↗

A STRANGE THING HAPPENED AS MY WIFE AND I WERE DRIVING HOME AT NIGHT IN OUR '03 BOXSTER. THE SEATBACK ON THE PASSENGER SIDE MYSTERIOUSLY BEGAN ROTATING FORWARD, ALL EFFORTS TO STOP IT USING BODY FORCE FAILED. MY WIFE WAS CRUSHED INTO THE GLOVE BOX BY THE TIME I WAS ABLE TO PULL OVER AND STOP. SHE COULD NOT REACH THE DOOR HANDLE AND WAS BARELY ABLE TO EXTRICATE HERSELF AFTER I OPENED THE DOOR FROM THE OUTSIDE. THE SEAT MOTOR HAD ROTATED THE SEATBACK FORWARD TO A POSITION OF APPROXIMATELY 45 PAST VERTICAL BY THE TIME IT STOPPED. WE LATER DISCOVE…

Owner-reported narrative. 77,312 miles reported. Look up ODI 10458148 at NHTSA ↗

TL* THE CONTACT OWNS 2003 PORSCHE BOXTER. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, AN ABNORMAL NOISE WAS HEARD FROM THE VEHICLE. AFTER PARKING, THE CONTACT NOTICED OIL LEAKING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHERE AND DIAGNOSED AS HAVING AN INTERMEDIATE SHAFT BEARING FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 11,000. THE VIN WAS NOT AVAILABLE.

Owner-reported narrative. 11,000 miles reported. Look up ODI 10552976 at NHTSA ↗

REAR BRAKES (BOTH SIDES) BEGAN APPLYING THEMSELVES WITH NO DRIVER INPUT, LOCKING UP WITHIN ABOUT 5 SECONDS. *TR

Owner-reported narrative. 95,166 miles reported. Look up ODI 10625772 at NHTSA ↗

TOOK MY PORSCHE BOXSTER TO THE LOCAL PORSCHE DEALER FOR AN OIL CHANGE. THEY CALLED ME BACK AND SAID MY CAR HAD A GASOLINE FUEL LEAK AND NEEDED A REPLACEMENT FUEL LEVEL SENSOR IT WAS CRACKED AND LEAKING FUEL.. THE SERVICE ORDER AT PICKUP SAID MECHANIC NOTED FUEL DRIPPING FROM GAS TANK...NOTED LEAKING FROM CRACKS IN THE SENDING UNIT WHERE THE PRESSURIZED FUEL OUTLET IS, REPLACED SENDING UNIT AND SEAL, ALSO NOTED ELECTRICAL CONNECTOR SEAL SWOLLEN FROM FUEL CONTAMINATION. I ASKED THE SERVICE MANAGER IF THIS HAD BEEN REPORTED TO THE NHTSA AND HE SAI…

Owner-reported narrative. 119,774 miles reported. Look up ODI 10926541 at NHTSA ↗

Reported: 2003-01-23 (January 23, 2003)

CERTAIN 2-DOOR CONVERTIBLE PASSENGER VEHICLES EQUIPPED WITH THE TIPTRONIC (AUTOMATIC) TRANSMISSION MAY HAVE BEEN PRODUCED WITH AN INCORRECTLY ADJUSTED KEY-LOCK-CABLE DOWN TO THE SHIFT SELECTOR. IF THE KEY-LOCK-CABLE IS NOT ADJUSTED CORRECTLY, IT IS POSSIBLE THAT THE IGNITION KEY WILL SNAG UPON BEING REMOVED FRO THE IGNITION LOCK OR THE SLECTOR LEVER CAN BE SHIFTED FROM POSITION "P" WITH THE IGNITION KEY REMOVED AND THE LOCKING BUTTON OPERATED.

Consequence: IF THE SELECTOR LEVER IS THEN SHIFTED FROM POSITION "P" TO POSITION "R, N OR D" WITH THE VEHICLE PARKED, AND IF THE PARKING BRAKE IS NOT ON, THE VHEICLE WILL NOT BE SECURED FROM INADVERTENLY ROLLING AWAY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE CABLE ADJUSTMENT AND, REGARDLESS OF THE RESULTS OF THIS INSPECTION, THE KEY-LOCK-CABLE MUST ALSO BE ADJUSTED. OWNER NOTIFICATION BEGAN JULY 15, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PORSCHE AT 1-800-545-8039.

Reported: 2022-08-30 (August 30, 2022)

Porsche Cars North America, Inc. (Porsche) is recalling certain 2003-2020 Porsche Macan, Cayenne, Panamera, and Cayman S, 2001-2004 Boxster, Boxster S, 2004 Boxster 50 JAHRE SPYDER 550 vehicles. Please see the recall report for a complete list of all affected models and model years. The caps that cover the low-beam headlight horizontal adjustment screws are missing, which can allow the headlights to be improperly adjusted. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: Improperly adjusted headlights may not illuminate the road properly, or cause a glare to oncoming drivers, which can increase the risk of a crash.

Remedy: Dealers will inspect the headlights for sealing caps and install missing caps as necessary, free of charge. Owner notification letters were mailed October 28, 2022. Owners may contact Porsche's customer service at 1-800-767-7243. Porsche's number for this recall is ANB4.