1991 Plymouth VOYAGER: complaints, problems and recalls

WHILE IN MOTION, AND APPLYING THE BRAKES THE SEAT BELTS WON'T LOCK. *JG

Owner-reported narrative. 157,000 miles reported. Look up ODI 10001505 at NHTSA ↗

THIS TRANSMISSION HAS NOW FAILED TWICE, ONCE AT 46000 AND NEW AT 67000. I HAVE READ THAT THERE ARE A LOT OF PROBLEMS WITH THIS ON ALL THEIR VANS, THEY SHOULD BE MADE TO MAKE SOME KIND OF RECALL OR SOMEONE SHOULD START A CLASS ACTION SUIT AGAINST THEM FOR FAULTY PROBLEMS. DIMS 11 IVOQ ENTRY POSTED AFTER 12/12/2002 CUT-OVER-TO ARTEMIS........7707660. *AK *JB

Owner-reported narrative. 46,000 miles reported. Look up ODI 10006528 at NHTSA ↗

WHEN THE BRAKES WERE APPLIED BRAKE PEDAL WENT TO THE FLOOR, AND VEHICLE CAME TO A STOP. TOOK VEHICLE TO DEALER, AND DEALER INDICATED THAT ACCUMULATOR PRESSURE SWITCH NEEDED TO BE REPLACED. *AK

Owner-reported narrative. 108,000 miles reported. Look up ODI 10042774 at NHTSA ↗

WHEN COMING TO A STOP CONSUMER APPLIED A LOT OF PRESSURE TO THE BRAKE PEDAL TO STOP THE VEHICLE. CONSUMER BELIEVED THIS WAS DUE TO MANUFACTURER'S RECALL 702 CONCERNING ABS BRAKING SYSTEM. *AK

Owner-reported narrative. Look up ODI 10050249 at NHTSA ↗

VEHICLE HAS BEEN A SOURCE OF NUMEROUS NEVER SEEN BEFORE AND UNRESOLVED PROBLEMS ESPECIALLY DUE TO THE FACT THAT IT IS PRESENTLY LOCATED IN PROVENCE (FRANCE) WHERE PARTS AND LABOR ARE VERY HARD TO COME BY.....

Owner-reported narrative. 80,000 miles reported. Look up ODI 10068919 at NHTSA ↗

BRAKES FAILED TO STOP AND LIGHT COMES ON W/ANTI LOCK LIGHT CHRYSLER REPLACED WITH ANOTHER EXACT PART FROM JUNKYARD AND CHARGED ME FOR NEW PARTS $937.59. 1.5 YRS. LATER SAME PROBLEM OCCURS, THIS IS HOW I LEARNED WHAT THEY HAD DONE.

Owner-reported narrative. 138,406 miles reported. Look up ODI 10070732 at NHTSA ↗

CONSUMER COMPLAINED ABOUT A BROKEN AXLE. AXLE WAS REPLACED 4 TIMES ALREADY. *AK

Owner-reported narrative. 142,000 miles reported. Look up ODI 10072096 at NHTSA ↗

CLOCK SPRING ON STEERING COLUMN FAILED INTERNALLY, CAUSING STEERING WHEEL TO LOCK UP. THIS WAS DURING LEFT TURN. AFTER ROCKING STEERING WHEEL BACK AND FORTH, IT WOULD TURN AGAIN WITH NORMAL INPUT FORCES, HOWEVER THE HORN, CRUISE, AND AIRBAG ARE NOT OPERATIONAL AFTER THIS INCIDENT. *AK

Owner-reported narrative. Look up ODI 10078358 at NHTSA ↗

Reported: 1991-11-01 (November 1, 1991)

THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE HOSE MAY LEAK OR DETACH AT ITS CRIMPED END FITTING RESULTING IN THE DISCHARGE OF HYDRAULIC FLUID.

Consequence: FLUID DISCHARGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.

Remedy: REPLACE THE ABS HIGH PRESSURE HOSE WITH A HOSE OF DIFFERENT DESIGN AND CONSTRUCTION.

Reported: 1992-03-10 (March 10, 1992)

THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE PUMP MAY BE POROUS WHICH WILL RESULT IN BRAKE FLUID LEAKAGE.

Consequence: FLUID LEAKAGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.

Remedy: REPLACE THE ABS HIGH PRESSURE PUMP AND HIGH PRESSURE HOSE IF THE LAST SIX DIGITS OF THE BAR CODE LABEL ON THE PUMP ARE BETWEEN 052300 AND 059262.

Reported: 1996-06-13 (June 13, 1996)

THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.

Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.

Reported: 1996-11-18 (November 18, 1996)

THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.

Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.

Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS IN THE CENTER HUB ATTACHMENT AREA. ANY STEERING WHEELS SHOWING CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.

Reported: 1997-09-09 (September 9, 1997)

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.

Reported: 1997-09-09 (September 9, 1997)

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.

Reported: 1999-07-16 (July 16, 1999)

VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.

Consequence: THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.

Reported: 1999-09-02 (September 2, 1999)

VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.

Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.

Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.