2011 Mitsubishi OUTLANDER SPORT: complaints, problems and recalls

WHILE PASSING A SLOWER VEHICLE DURING INCREASED RPM'S THE MOTOR STALL AND STOPPED ASC SERVICE LIGHTS AND AIRBAG SERVICE LIGHT CAME ON ALMOST RESULTING IN A CRASH WITH PASSING VEHICLE BECAUSE OF NO STEERING AND PROPER BRAKING DUE TO LOSS OF POWER DEALERSHIP DIAGNOSTIC TECH NOTED INTERNAL FAILURE WITH ELECTRONIC CONTROL MODULE (ECM). *TR

Owner-reported narrative. 85,603 miles reported. Look up ODI 10651526 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 MITSUBISHI OUTLANDER SPORT. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V562000 (ENGINE). THE CONTACT STATED THAT THE PART NEEDED TO REMEDY THE VEHICLE WAS UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCE A FAILURE.

Owner-reported narrative. Look up ODI 10652322 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 MITSUBISHI OUTLANDER SPORT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V562000 (ENGINE AND ENGINE COOLING). THE CONTACT STATED THAT THE PART NEEDED TO REMEDY THE VEHICLE WAS UNAVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Owner-reported narrative. Look up ODI 10654726 at NHTSA ↗

I WENT ON VACATION FOR SEVEN DAYS AND WHEN I RETURNED I STARTED THE VEHICLE TO MAKE SURE IT WOULD AND IT STARTED JUST FINE. THE NEXT MORNING AS I WAS GETTING READY TO LEAVE FOR WORK, THE VEHICLE STALLED. I CONTACTED ROADSIDE ASSISTANCE AND IT WAS NOT THE BATTERY. I THEN TOWED THE VEHICLE TO A MECHANIC TO HAVE IT LOOKED AT. THEY STATED THE ENGINE MAY BE DONE FOR BECAUSE THE COMPRESSION LEVELS WERE READING VERY LOW AND THE HIGHEST READING WAS A 41 OF THE FOUR CYLINDERS. THEY SUGGESTED ITS EITHER THE TIMING BELT OR THE ENGINE AND THAT THE TIMING B…

Owner-reported narrative. 60,489 miles reported. Look up ODI 10662941 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 MITSUBISHI OUTLANDER SPORT. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V562000 (ENGINE AND ENGINE COOLING) EXCEEDED A REASONABLE AMOUNT OF TIME FOR REPAIR. THE DEALER STATED THAT THE PARTS WERE NOT AVAILABLE FOR REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE DELAY. THE VEHICLE WAS NOT REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

Owner-reported narrative. Look up ODI 10672705 at NHTSA ↗

CONTINUED FAILURE TO PROVIDE PARTS FOR NATIONAL RECALL; DRIVE BELT. NOW MORE THAN THREE (3) MONTHS SINCE PLACED ON LIST FOR REPLACEMENT. *TR

Owner-reported narrative. Look up ODI 10683038 at NHTSA ↗

PROBLEM EXISTED IN ELECTRIC POWER STEERING SYSTEM. UNDER LOW SPEED, 5 TO 10 MPH OR LESS, ELECTRIC POWER STEERING SYSTEM STOPPED WORKING OCCASIONALLY (USUALLY AFTER A FULL TURNING OF STEERING WHEEL TO THE LIMIT). WHEN THE PROBLEM OCCURS, NO POWER ASSIST FUNCTIONALITY FUNCTIONING, SIGNIFICANTLY INCREASES STEERING EFFORTS, THUS INCREASES VEHICLE CRASHING POSSIBILITIES SIGNIFICANTLY. MY VEHICLE HAS BEEN ONLY DRIVEN FOR LESS THAN 4 YEARS. A SELF CHECK ON THE STEERING SYSTEM SHOWED WITH NO LEAKING STEERING FLUID AND COMPLETELY CLEAN STEERING FLUID WH…

Owner-reported narrative. 72,900 miles reported. Look up ODI 10705644 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 MITSUBISHI OUTLANDER SPORT. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD PULL TO THE RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A WHEEL ALIGNMENT WAS PERFORMED, BUT THE FAILURE CONTINUED. WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE SUDDENLY PULLED TO THE RIGHT. THE DRIVER LOST CONTROL AND CRASHED INTO A BRICK BOULDER. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. ALSO, WHILE DESCENDING DOWN A HILL AT APPROXIMATELY 5 MPH, THE MESSAGE "VEHICLE IMMO…

Owner-reported narrative. 39,266 miles reported. Look up ODI 10723353 at NHTSA ↗

Reported: 2013-06-20 (June 20, 2013)

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2011 Outlander Sport vehicles manufactured August 26, 2010, through March 29, 2011. The panoramic glass roof may have been installed without primer being applied before the adhesive.

Consequence: Without primer being used, the panoramic glass roof may have reduced adhesion, possibly allowing the glass roof to detach from the vehicle, resulting in a road hazard to other vehicles.

Remedy: MMNA will notify owners and dealers will inspect the panoramic glass to see if primer was installed. If primer is not present, the glass will be reinstalled. The recall began on July 8, 2013. MMNA's recall number is SR-13-007. Customers may contact MMNA at 1-888-648-7820.

Reported: 2014-09-12 (September 12, 2014)

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2011 Outlander Sport vehicles manufactured on September 3, 2010. In the affected vehicles, the switch sleeve in the brake booster may crack and prevent the brake pedal from returning properly.

Consequence: If the pedal is unable to move back to the proper position, the vehicle may not move as expected, increasing the risk of a crash.

Remedy: Mitsubishi will notify owners, and dealers will inspect the brake booster, replacing it as necessary, free of charge. The recall began in October 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-008.

Reported: 2014-09-12 (September 12, 2014)

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2008-2011 Lancer, Lancer Evolution, and Outlander; 2009-2011 Lancer Sportback, Lancer Rilliart, and Lancer Sportback Ralliart; and 2011 Outlander Sport vehicles. The affected vehicles, manufactured with 4B1 engines, have an engine pulley and belt arrangement for turning the alternator, the cooling fan and the power steering pump (if equipped). These pulleys may experience unusual wear and allow for belt detachment.

Consequence: If the drive belt detaches, the battery may discharge, resulting in an engine stall, increasing the risk of a crash.

Remedy: Mitsubishi will notify owners, and dealers will replace the drive belt with a rubber belt. Drive pulleys that are excessively worn will be replaced. These repairs will be performed free of charge. The recall began on October 15, 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-009.

Reported: 2015-04-20 (April 20, 2015)

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2009-2011 Lancer vehicles manufactured March 16, 2009, to March 30, 2011, 2010-2011 Lancer Sportback vehicles manufactured June 17, 2009, to December 1, 2010, 2010-2011 Lancer Evolution vehicles manufactured July 14, 2009, to January 7, 2011, 2009-2011 Outlander vehicles manufactured February 10, 2009, to June 22, 2011, and 2011 Outlander Sport vehicles manufactured August 26, 2010, to November 19, 2010. In the affected vehicles, the blower motor may fail.

Consequence: Failure of the blower motor may reduce the performance of the windshield defroster, diminishing the driver's visibility and increasing the risk of a crash.

Remedy: Mitsubishi will notify owners, and dealers will replace a suspect blower motor, free of charge. The recall began on June 15, 2015. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-15-003.

Reported: 2015-09-21 (September 21, 2015)

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2011 Outlander Sport vehicles manufactured on December 3, 2010. The affected vehicles are equipped with incorrect certification labels that were installed during manufacturing. The incorrect labels do not have the correct vehicle identification numbers (VIN) printed on the label. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."

Consequence: A vehicle must comply with all regulatory requirements to ensure that it is safe.

Remedy: Mitsubishi will notify owners, and dealers will install corrected certification labels, free of charge. The recall began on October 8, 2015. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-15-010.

Reported: 2016-10-31 (October 31, 2016)

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2011-2015 Outlander Sport vehicles manufactured August 26, 2010, to January 5, 2015. In the affected vehicles, water may drop between the hood and the windshield and leak into the wiper motor breathing hole. The water may cause internal corrosion of the windshield wiper motor and the possible failure of the motor.

Consequence: Failure of the wiper motor can cause a loss of visibility, increasing the risk of a crash.

Remedy: MMNA will notify owners, and dealers will replace the wiper motor, free of charge. The manufacturer has begun the recall, but parts are not yet available; a second notice will be sent when parts are available. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-010.

Reported: 2016-12-02 (December 2, 2016)

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain model year 2011-2012 Outlander Sport vehicles manufactured August 26, 2010, to June 1, 2012, and 2016 Outlander Sport vehicles manufactured January 11, 2016, to July 8, 2016. The lift gate support outer tube on the affected vehicles may have insufficient anti-corrosion treatment that can allow the outer tube to corrode due to salt and water penetration.

Consequence: If the outer tube corrodes, there may be a rapid loss of the gas used to provide lift assistance, causing the lift gate to fall suddenly, increasing the risk of injury.

Remedy: MMNA will notify owners, and dealers will replace the lift gate supports, free of charge. The recall began on January 20, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-16-011.

Reported: 2018-01-26 (January 26, 2018)

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2009-2012 Lancer, 2008-2012 Outlander, 2010-2012 Lancer Sportback, and 2011-2012 Outlander Sport vehicles equipped with either a 4B11 or 4B12 engine. The drive belt automatic tensioner flange may crack, allowing the accessory drive belt to detach.

Consequence: If the drive belt detaches, the battery will discharge and the engine will stall, increasing the risk of a crash.

Remedy: MMNA will notify owners, and dealers will replace the belt tensioner with one that has an improved shape, free of charge. The recall is expected to begin March 27, 2018. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-18-001.

Reported: 2018-02-09 (February 9, 2018)

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2011-2016 Outlander Sport vehicles. Water may enter between the hood and windshield and cause the front wiper link ball joint to corrode, possibly resulting in the wiper link separating and the wipers becoming inoperative.

Consequence: Loss of wiper function can reduce visibility and increase the risk of a crash.

Remedy: MMNA will notify owners, and dealers will replace the rod of the wiper link and the wiper motor crank arm, free of charge. The recall is expected to begin April 10, 2018. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-18-004.

Reported: 2020-05-18 (May 18, 2020)

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2008-2010 Lancer, 2009-2010 Lancer Sportback, 2008-2013 Outlander, and 2011-2016 Outlander Sport vehicles originally sold in, or ever registered in, Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. The front lower control arms may detach due to the front cross member corroding from salt water exposure such as from road salt use.

Consequence: A detached front control arm can result in a loss of vehicle control, increasing the risk of a crash.

Remedy: MMNA will notify owners, and dealers will inspect the front cross members. Depending on the level of existing corrosion, either a sealing/anti-corrosion agent will be applied or the front cross member will be replaced with a new one. These repairs will be performed free of charge. The recall began August 7, 2020. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-20-003.