2011 Mercury MILAN: complaints, problems and recalls

TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT WAS DRIVING 10 MPH WHEN THE VEHICLE ACCELERATED ABNORMALLY AS HE DEPRESSED THE BRAKES AND SHIFTED INTO NEUTRAL. THE VEHICLE WAS TAKEN TO THE DEALER WHO RAN A DIAGNOSTIC TEST BUT COULD NOT DUPLICATE THE FAILURE. THE DEALER KEPT THE VEHICLE FOR TWO WEEKS WITH A FLIGHT RECORDER HOOKED TO THE ENGINE, BUT THEY COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO STATED HE HAS TO TAKE THE VEHICLE TO THE DEALER FOR THEM TO INSPECT THE FAILURE. THEY OFFERED NO OTHER ASSISTANCE. THE FA…

Owner-reported narrative. 7,000 miles reported. Look up ODI 10462584 at NHTSA ↗

I WAS DRIVING ON A HIGHSPEED ROAD WHEN SUDDENLY THERE WAS NOTHING HAPPENING WHEN I PRESSED THE GAS. A SMALL WRENCH CAME ON THE DASH. THE OWNER'S MANUAL SAID THROTTLE/TRANSMISSION PROBLEM. HAD WE BEEN IN THE PASSING LANE WE PROBABLY WOULD HAVE BEEN REAR-ENDED AND KILLED! AS IT WAS, I WAS ABLE TO COAST OVER TO THE SHOULDER OF THE ROAD AND EVENTUALLY PULL INTO A PARKING LOT. I TURNED OFF THE CAR, WAITED A FEW MINUTES AND TURNED IT BACK ON. I WAS ABLE TO DRIVE ABOUT 5 MILES BEFORE THE SAME THING HAPPENED AGAIN. I LEFT THE CAR IN A PARKING LOT. I HA…

Owner-reported narrative. 35,500 miles reported. Look up ODI 10465733 at NHTSA ↗

I WAS DRIVING AT ABOUT 70 MPH ON I-70, WHEN THE CAR LOST ALL ENGINE POWER, LIKE IT DIED, I WAS FORTUNATELY GETTING READY TO EXIT, AND WAS IN THE RIGHT LANE,SO COASTED THE CAR OFF TO THE SIDE. A WRENCH LIGHT CAME ON, HAD IT TOWED TO DEALER, WHO SO FAR CANNOT DUPLICATE IT OR GET A CODE FOR IT TO SHOW. HE WANTS TO KEEP IT AWHILE TO FIGURE IT OUT. I AM ADVANCE COMPLAINING SINCE I HAVE SEEN THIS PROBLEM ON HERE FOR ANOTHER MILAN, AND HAVE FOUND THE SAME COMPLAINT ON THIS SITE 21 TIMES FOR THE SISTER CAR TO THIS, THE FORD FUSION. IT HAS BEEN THE "TH…

Owner-reported narrative. 44,000 miles reported. Look up ODI 10479712 at NHTSA ↗

WAS STOPPED AT A TRAFFIC LIGHT. AFTER THE LIGHT TURNED GREEN I APPLIED THE GAS PEDAL AND THE CAR SLOWLY PRECEDED I WAS UNSURE I WOULD MAKE IT THROUGH THE INTERSECTION I PULLED TO THE SIDE. I WAS ABLE TO RESTART CAR AND IT ACCELERATED NORMALLY. LUCKILY NO ONE REARENDED ME. *TR

Owner-reported narrative. 41,000 miles reported. Look up ODI 10491593 at NHTSA ↗

I HAVE EXPERIENCED THIS PROBLEM TWICE. THE CAR LOSES POWER, TRAVELING AT 65MPH ON HIGHWAY AND CAR LOST ALL POWER. THE WRENCH LIGHT CAME ON. PULLED OVER, TURNED CAR OFF AND RESTARTED. LIGHT WENT OFF AND CAR WAS DRIVABLE. THE SECOND TIME OCCURRED WHILE CAR WAS STOPPED AND WHEN I PROCEEDED TO ACCELERATE, THE CAR HAD NO POWER. I TOOK IT TO THE FORD DEALER AND THEY SAID THE THROTTLE BODY NEEDED TO BE REPLACED AS IT HAD A SHORT. THIS WAS NOT INCLUDED IN MY POWERTRAIN WARRANTY. I HAVE READ INFO ON THIS AND IT APPEARS THAT IT IS BECOMING MORE CO…

Owner-reported narrative. 36,506 miles reported. Look up ODI 10496010 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 MERCURY MILAN. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WENT INTO LIMP MODE WITHOUT ANY WARNINGS. THE CONTACT MENTIONED THAT HE HAD TO TURN OFF AND RESTART THE VEHICLE IN ORDER TO TEMPORARILY REMEDY THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 51,000.

Owner-reported narrative. 45,000 miles reported. Look up ODI 10500024 at NHTSA ↗

TRANSMISSION ISSUES: PROBLEM MAINLY OCCURS WHEN SHIFTING FROM 2ND TO 3RD GEAR WHILE IN "DRIVE" OR AUTOMATIC MODE. UNDER SLOW TO MODERATE ACCELERATION, THE ENGINE RPMS GO UP TO APPROXIMATELY 3,500 PROCEEDING TO SHIFT ABRUPTLY INTO 3RD GEAR. THIS ISSUE CAN BE REPLICATED WHETHER THE VEHICLE IS AT NORMAL OPERATING TEMP OR BELOW. THIS HAS CAUSED WHEEL SPIN WITH WET AND SNOW COVERED ROADS RESULTING LOSS OF CONTROL/ SKIDDING WHILE TURNING UNDER THE ABOVE CIRCUMSTANCES. THE HARD SHIFTING WAS NOTICED THE DAY I BOUGHT THE VEHICLE AND MORE SO DURING THE …

Owner-reported narrative. 13,000 miles reported. Look up ODI 10503872 at NHTSA ↗

2011 MERCURY MILAN. CONSUMER WRITES IN REGARDS TO PARTIAL ENGINE FAILURE IN VEHICLE AND SEEKS REIMBURSEMENT. *SMD THE CONSUMER STATED AT APPROXIMATELY 48,415, THE ENGINE STARTED GOING TIN A VERY ROUGH LOW RPM MODE. THE CONSUMER STATED THE WRENCH LIGHT AND ENGINE LIGHT ILLUMINATED AND THE VEHICLE RAN FINE UNDER 40 MPH. THE DEALER REPLACED THE THROTTLE BODY AND CABIN AIR FILTER.

Owner-reported narrative. 48,415 miles reported. Look up ODI 10504033 at NHTSA ↗

Reported: 2011-12-07 (December 7, 2011)

FORD IS RECALLING CERTAIN MODEL YEAR 2010-2011 FORD FUSION AND MERCURY MILAN VEHICLES EQUIPPED WITH 17 INCH STEEL WHEELS AND BUILT FROM APRIL 1, 2009, THROUGH APRIL 30, 2009, AND FROM DECEMBER 1, 2009, THROUGH NOVEMBER 13, 2010. THE WHEEL STUDS MAY FRACTURE, POTENTIALLY CAUSING A WHEEL TO SEPARATE.

Consequence: WHILE DRIVING, MULTIPLE STUD FRACTURES COULD OCCUR AT THE WHEEL LOCATION, AND THE OPERATOR MAY EXPERIENCE VEHICLE VIBRATION AND/OR WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE REAR BRAKE DISC SURFACE FOR FLATNESS AND REPLACE THE DISCS AS NECESSARY. ADDITIONALLY, THE WHEEL LUG NUTS WILL BE REPLACED ON ALL FOUR WHEELS. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JANUARY 24, 2012. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Reported: 2015-06-02 (June 2, 2015)

Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.

Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.

Remedy: Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.

Reported: 2015-11-24 (November 24, 2015)

Ford Motor Company (Ford) is recalling certain model year 2010-2011 Ford Fusion vehicles manufactured July 21, 2008, to March 4, 2011, and 2010-2011 Mercury Milan vehicles manufactured July 23, 2008, to December 10, 2010. The affected vehicles have fuel vapor canisters whose purge valves may not operate properly resulting in abnormal pressure changes in the fuel tank.

Consequence: The pressure changes may cause the tank to crack and leak fuel. A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Ford will notify owners, and dealers will update the vehicle powertrain control modules and inspect the vehicle for any diagnostic trouble codes (DTCs) for this issue and perform a leak test on the Canister Purge Valve (CPV). The fuel tank will be inspected for cracks. The CPV and fuel tank will be replaced as necessary. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S34.

Reported: 2016-05-31 (May 31, 2016)

Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.

Reported: 2019-01-07 (January 7, 2019)

Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2011 Ford Ranger and Mercury Milan vehicles, 2011-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles and 2011-2014 Ford Mustang vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2010 Ford Edge and Lincoln MKX vehicles, 2010-2011 Ford Ranger and Mercury Milan vehicles, 2010-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles, and 2010-2014 Ford Mustang vehicles sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with air bag inflators assembled as part of the passenger frontal air bag modules, used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 13, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall 19S01.

Reported: 2021-02-16 (February 16, 2021)

Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.

Reported: 2021-03-10 (March 10, 2021)

Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.