2019 Mercedes-Benz SPRINTER 4500: complaints, problems and recalls

TRAVELING DOWN THE HIGHWAY AT 65 MPH, THE WHEELS STARTED SHAKING VIOLENTLY, AND WITHIN 5 SECONDS, THE POWER STEERING ASSIST COMPLETELY FAILED. IT TOOK EXCESSIVE STRENGTH TO STEER THE VEHICLE TO SAFETY. MERCEDES-BENZ IS REFUSING TO COVER THE REPAIR ON THE 15-MONTH OLD VAN THAT HAS 43000 MILES ON IT. THE ISSUE HAS BEEN IDENTIFIED AS A FAILED ELECTRIC ACTUATOR.

Owner-reported narrative. 43,000 miles reported. Look up ODI 11390987 at NHTSA ↗

ROLLAWAY FROM PARK. VEHICLE ROLLED FORWARD AND COLLISION AT RIGHT FRONT.

Owner-reported narrative. 24,262 miles reported. Look up ODI 11404894 at NHTSA ↗

The Lane Assist and Crosswind Assist do not work properly. When a gust of wind hits you or when you're passing a semi, the van immediately forces your vehicle off the road or into the other lane where there is another vehicle or a concrete barrier. It's very difficult to hold onto the steering wheel and try to maneuver the vehicle to stay in your lane. The only way to turn off these features are to turn off them off every time you start your vehicle. Mercedes Benz has told me there is no way to turn it off completely and they have had numero…

Owner-reported narrative. Look up ODI 11421986 at NHTSA ↗

The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _…

Owner-reported narrative. Look up ODI 11432261 at NHTSA ↗

Awning operation and lights are controlled by switchs in vehicle and/or app. Intermittently switchs will not work. Awing sometimes stutters when deployed. So far we have been able to fully retract. We have not taken to dealer since the symptoms are very sporadic.

Owner-reported narrative. Look up ODI 11486867 at NHTSA ↗

Cruse control will sometimes disengage and display these error messages: "Active Distance Assist Inoperative" "Active Brake Assist Functions Limited See Operator's Manual" Cruse control kicks out and the power cuts off abruptly. After some variable time the cruise control function will work again. This is an intermittent problem that occurs without warning. When cruise control set to 65-70 mph, the deceleration is very pronounced, as if brakes are applied. This can be very starling to the driver, passengers, and any vehicles tailing behin…

Owner-reported narrative. Look up ODI 11530169 at NHTSA ↗

The active distance assist inoperative appears when using the cruise control. This comes on when no traffic in front of the vehicle for 1 hour or less. Also Active Brake Assist functions limited - see operators Manual To reset: follow another vehicle for 5 minutes. This is Very Very Very frustrating and UNSAFE. This function should not automatically shut off. I paid a lot of money to try and figure out the problem. This is VERY UNSAFE for this feature of instantly shut off for no reason and is dangerous. Please fix this with a softwar…

Owner-reported narrative. Look up ODI 11624407 at NHTSA ↗

At high altitudes (it's happened over 5000ft and not under that) while in 4x4 mode, the car occasionally just simply does not respond to throttle input while in drive. This is usually from a start while shifting from park or reverse into drive, but there is zero power which has now been dangerous a few times for us while on inclines or near traffic. It eventually goes away after shifting back and forth to park/reverse/neutral and trying to rev the engine. But it's inconsitent, infrequent and not particularly easy to reproduce.

Owner-reported narrative. Look up ODI 11634134 at NHTSA ↗

Reported: 2019-07-02 (July 2, 2019)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500 and 4500 vehicles. The rear side windows may be single-pane safety glass instead of laminated safety glass.

Consequence: In the event of a side impact crash or vehicle rollover, the fitted side windows may not adequately protect the rear occupants from being ejected, increasing their risk of injury.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner dealers will replace the single-pane safety glass with laminated safety glass., free of charge. DVUSA issued owners an interim notification on August 16, 2019. The recall began January 21, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VERGLAS.

Reported: 2019-08-12 (August 12, 2019)

Daimler Vans USA, LLC. (MBUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter 1500, 2500, 3500, and 4500 vehicles. If the manual turn-switch that activates the vehicle lights is turned quickly from one lighting position to another, the brightness of the taillights can be significantly reduced or could switch off completely.

Consequence: Reduced taillight visibility increases the risk of a crash.

Remedy: MBUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will update the body control unit software, free of charge. The recall began September 30, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is VS3HELI.

Reported: 2019-09-18 (September 18, 2019)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter vehicles. The screw connection on the upper hood catch may have been improperly tightened. As a result, factors such as the vehicle's speed, wind resistance and road conditions may cause the hood to open while the vehicle is being driven.

Consequence: A hood that opens while driving can reduce the driver's visibility, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will inspect the screw connection, tightening it as necessary, free of charge. The recall began November 1, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3HAUBOSS.

Reported: 2019-10-02 (October 2, 2019)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Sprinter and Metris vehicles. The vehicles left the reassembly plant without the final quality inspection of safety-relevant parts or bolt connections, resulting in possible unknown safety risks.

Consequence: Failure to identify loose safety related parts can increase the risk of crash and injury.

Remedy: DVUSA will notify owners, and vehicles will be returned to the reassembly plant for comprehensive inspection and, if necessary, corrective action, free of charge. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSX566ZP25.

Reported: 2019-10-02 (October 2, 2019)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz and Freightliner Sprinter vehicles. The airbag systems may not have been activated after vehicle production. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Consequence: An inactive airbag system can increase the risk of injury in the event of a crash.

Remedy: DVUSA will notify owners, and dealers will inspect the vehicles to determine if the airbag systems have been activated, correcting them as necessary, free of charge. DVUSA issued owners an interim notification on November 22, 2019. The recall began February 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AIRIGEL.

Reported: 2019-10-08 (October 8, 2019)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter vehicles. In the affected vehicles, the abutting wedge, a component attached to the door jamb to make opening the door easier after a severe frontal impact, may have been installed incorrectly.

Consequence: If a vehicle that has an incorrectly installed abutting wedge is involved in a severe frontal accident, a greater force may be necessary to open the doors, increasing the risk of injury.

Remedy: DVUSA will notify owners, and dealers will inspect the installation of the abutting wedge on the driver and front passenger side, correcting it, as necessary, free of charge. DVUSA issued owners an interim notification on November 22, 2019. The recall began February 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KEIL.

Reported: 2019-11-07 (November 7, 2019)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz and Freightliner Sprinter vehicles equipped with diesel fuel systems. The bayonet lock between the fuel pump and the fuel tank may not have been closed and locked during manufacturing. As a result, a leak between the fuel pump and the fuel tank could occur. In addition, a gas station fuel pump may not automatically stop once the tank fill level is reached, potentially causing the fuel to overflow.

Consequence: A diesel fuel leak can create slippery road conditions, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will inspect the bayonet lock on the fuel pump, locking it as necessary, free of charge. The recall began January 3, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KRAFMOD.

Reported: 2019-11-06 (November 6, 2019)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner vehicles. A seam on the height adjuster for the front seats may have been insufficiently welded.

Consequence: In the event of a crash, the weld seam may break and cause the seat cushion to shift forward, increasing the risk of injury.

Remedy: DVUSA will notify owners, and dealers will replace the tilt adjuster for the front seats, free of charge. DVUSA issued owners an interim notification on December 19, 2019. The recall began March 9, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SITZVER.

Reported: 2019-12-19 (December 19, 2019)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The lashing rails on the side walls may not have been properly installed, possibly resulting in the lashing rails detaching.

Consequence: If the lashing rails disconnect, the cargo could become unsecured, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will correctly affix the lashing rails to the side walls, free of charge. DVUSA issued owners an interim notification on February 7, 2020. The recall began April 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ZUSCHI.

Reported: 2020-02-12 (February 12, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The connecting screws on the exhaust gas recirculation (EGR) pipe may not have been correctly tightened.

Consequence: If the connecting screws are not properly tightened, hot exhaust gases may leak from the EGR pipe, increasing the risk of a fire.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will renew the screw connection and the flange seals on the exhaust gas recirculation pipe, free of charge. DVUSA issued owners an interim notification on April 6, 2020. The recall began May 4, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3AGROHR.

Reported: 2020-02-12 (February 12, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The flange connection between the exhaust gas turbocharger and the exit to the diesel particulate filter may not be attached properly, potentially causing an exhaust gas leak.

Consequence: An exhaust gas leak in the engine compartment increases the risk of a fire.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace the flange seals and properly tighten the connection, free of charge. The recall began April 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FLABIND.

Reported: 2020-02-25 (February 25, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The screws that secure the intermediate bearing of the steering spindle may not have been properly tightened, potentially causing the screws to loosen and detach.

Consequence: If the screws detach, the driver may have difficulty steering the vehicle, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will replace and properly tighten the steering spindle intermediate bearing screws, free of charge. The recall began April 13, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHLENK.

Reported: 2020-02-25 (February 25, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The steering column casing cover may have not been installed, allowing the steering column area to be exposed.

Consequence: If small vehicle components, such as nuts and screws, enter the steering column area, the steering operation can be affected, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace the steering column with one that has a cover, free of charge. The recall is expected to begin April 10, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3VERKLE.

Reported: 2020-03-18 (March 18, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The spare tire label may indicate the maximum speed at 55 kilometers per hour (kph) rather than as 34 miles per hour (mph).

Consequence: With only the metric speed listed on the spare tire label, the driver could misinterpret the kph as mph and operate the vehicle with the spare tire installed at higher speeds than the tire can withstand, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will replace it with the label with the correct maximum speed information indicated in miles per hour, free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEGRESS.

Reported: 2020-03-18 (March 18, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2018-2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The spare tire label indicating the maximum speed may have not been affixed to the spare tire.

Consequence: Without the label, an operator may be unaware of the maximum speed limit of the spare tire and operate the vehicle at a excessive speed, increasing the risk of tire failure and a crash.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will attach the speed limitation label on the spare wheel, free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEGREPP.

Reported: 2020-03-18 (March 18, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with winter tires. The tires may not have been correctly installed, possibly resulting in reduced traction in wet or snowy conditions.

Consequence: A reduction in traction may result in a loss of vehicle control, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect the running direction of the tires, correcting them as necessary. If the thread wear is uneven, the tires will be replaced. All services will be performed free of charge. The recall began May 15, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LAUFRI.

Reported: 2020-03-26 (March 26, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The Operator's Manual may not contain the correct information about how the automatic parking function ("Auto-P") operates.

Consequence: If the driver relies on the Auto-P function as described in the Operator's Manual, vehicle rollaway or movement may occur, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will provide the correct description of the Auto-P function for the Operator's Manual, free of charge. The recall began May 18, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BAUTOP.

Reported: 2020-03-25 (March 25, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rear part of the fender liner on the front axle may contact and chafe the brake hose, possibly resulting in a loss of brake fluid.

Consequence: Loss of brake fluid can extend the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and Mercedes-Benz or Freightliner Sprinter dealers will inspect and replace the brake hoses, as necessary. Additionally, the fender liners will be modified. All services will be performed free of charge. The recall began May 8, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BRADVER.

Reported: 2020-09-29 (September 29, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling 2019-2020 Mercedes Benz and Freightliner Sprinters. The fuel line clamps may loosen and result in a fuel leak.

Consequence: A fuel leak can increase the risk of a fire.

Remedy: DVUSA will notify owners, and dealers will check the fuel hose clamp connections and tighten or replace the components as needed, free of charge. DVUSA issued owners an interim notification on November 9, 2020. The recall began January 19, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHELLE.

Reported: 2020-10-28 (October 28, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.

Consequence: The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.

Reported: 2020-12-08 (December 8, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019 Mercedes Benz Sprinter vehicles. These vehicles may have been delivered with a version of the printed and digital operator's manual that may be inaccurate and/or incomplete.

Consequence: If the operator relies on the provided owner's manual, the information about vehicle functions and other safety relevant information may be inaccurate and/or incomplete, which could lead to improper operation of the vehicle and potentially increase the risk of a crash or injury.

Remedy: DVUSA will notify owners, and dealers will replace the printed version of the operator's manual with the latest version and update the software of the digital version, free of charge. DVUSA distributed owners an interim notification on January 22, 2021. The recall began March 17, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PRIDIBA.

Reported: 2020-12-21 (December 21, 2020)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with electric parking brakes. The rear brake calipers may leak brake fluid into the housing of the electric parking brake connected to the rear axle service brake system, allowing air to enter the hydraulic brake system.

Consequence: Air in the brake system can result in extended brake pedal travel, increasing the risk of a crash.

Remedy: DVUSA will replace the rear brake calipers, free of charge. Owners notification letters were mailed on January 4, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREPB.

Reported: 2021-02-05 (February 5, 2021)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.

Consequence: Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.

Remedy: DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSXHERMPOS.

Reported: 2021-02-17 (February 17, 2021)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with the multimedia system "Connect 5" and a rearview camera. The rearview image may not display within 2 seconds from the start of the backing event. In addition, the rearview image may be obscured or covered by the visual display of the Emergency Call (eCall) pop-up window if the eCall system is activated while the reverse gear is engaged. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence: A delayed or obstructed rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will perform a software update on the vehicles, free of charge. The recall began March 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3RUECON.

Reported: 2021-03-10 (March 10, 2021)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The retaining washer and bolt that connect the brake pedal to the bearing block, may come loose and detach. This could cause the brake lights to stay illuminated, even when the brake pedal is not pressed.

Consequence: Malfunctioning brake lights can fail to alert other motorists of the driver's intention, increasing the risk of a crash.

Remedy: DVUSA will notify owners and dealers will secure a bearing bracket to brake pedal by retrofitting an additional retaining ring (with PNR A 907 994 01 00) at the bearing bracket of brake pedal, free of charge. DVUSA issued owners an interim notification on May 3, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREBOL.

Reported: 2021-03-10 (March 10, 2021)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter vehicles equipped with an optional electric sliding door. The auxiliary lock on the sliding door may be the incorrect type for an electric sliding door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."

Consequence: In the event of a crash, the sliding door could dislocate more than intended, and increase the risk of injury to vehicle occupants.

Remedy: DVUSA will notify owners, and dealers will convert the sliding door from electric to manual function, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHIEBT.

Reported: 2021-04-05 (April 5, 2021)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The multifunctional display in the instrument cluster may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."

Consequence: A display that is too bright can hinder the driver's vision, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DISPKI.

Reported: 2021-04-06 (April 6, 2021)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach and cause hydraulic fluid to leak.

Consequence: A hydraulic fluid leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Remedy: DVUSA will notify owners, and dealers will install a screw-type clamp, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NV3LETULPX.

Reported: 2021-06-02 (June 2, 2021)

Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.

Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.

Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.

Reported: 2021-06-02 (June 2, 2021)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.

Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.

Reported: 2021-12-15 (December 15, 2021)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. A software error in the park lock system may allow the vehicle to move after the gear selector has been placed in the Park 'P' position without the parking brake applied.

Consequence: Unintentional vehicle movement can increase the risk of a crash.

Remedy: Dealers will update the electronic stability program control unit software, free of charge. Owner notification letters were mailed February 11, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PA27 ERI/ERO.

Reported: 2022-04-27 (April 27, 2022)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rearview camera may not display the rearview image due to a software error. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence: An inoperable rearview camera display reduces the driver's rear view, increasing the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed July 20, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMRUE.

Reported: 2022-05-20 (May 20, 2022)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.

Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.

Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.

Reported: 2022-10-21 (October 21, 2022)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with a manual parking brake and 7-speed automatic transmission. The guide bushing on the parking pawl may fatigue, which can cause the parking pawl not to engage and result in vehicle rollaway.

Consequence: Vehicle rollaway increases the risk of a crash.

Remedy: Dealers will update the software of the electronic stability, transmission control, direct select module, and electronic ignition switch control units, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's numbers for this recall are 22V2790611, 22V2790612, and 22V2790613.

Reported: 2023-03-24 (March 24, 2023)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The instrument cluster may fail to display any information when the vehicle is started.

Consequence: A blank instrument panel will not show critical information, such as vehicle speed, fuel gauge, warning messages, and warning lights, increasing the risk of a crash.

Remedy: Dealers will update the instrument cluster software on the affected vehicles, free of charge. Owner notification letters were mailed May 5, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMBAUS.

Reported: 2023-12-21 (December 21, 2023)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The longitudinal frame members may be missing reinforcement fasteners, reducing vehicle stability and decreasing the structural integrity of the third-row seats.

Consequence: Reduced stability increases the risk of a crash. Additionally, the third-row seat mountings can fail, increasing the risk of injury during a crash.

Remedy: Dealers will inspect and repair the frame members as necessary, free of charge. Owner notification letters were mailed March 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ROHRAH.

Reported: 2023-12-21 (December 21, 2023)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.

Consequence: A detached partition wall can increase the risk of injury.

Remedy: Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TREWAN.

Reported: 2024-12-13 (December 13, 2024)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter vehicles. The instrument cluster illumination may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."

Consequence: A display that is too bright can make it difficult for the driver to see critical safety information, increasing the risk of a crash.

Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed January 31, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BELKOM.