Mercedes-Benz SPRINTER 4500 problems and owner complaints

Cruse control will sometimes disengage and display these error messages: "Active Distance Assist Inoperative" "Active Brake Assist Functions Limited See Operator's Manual" Cruse control kicks out and the power cuts off abruptly. After some variable time the cruise control function will work again. This is an intermittent problem that occurs without warning. When cruise control set to 65-70 mph, the deceleration is very pronounced, as if brakes are applied. This can be very starling to the driver, passengers, and any vehicles tailing behin…

Owner-reported narrative. Look up ODI 11530169 at NHTSA ↗

The active distance assist inoperative appears when using the cruise control. This comes on when no traffic in front of the vehicle for 1 hour or less. Also Active Brake Assist functions limited - see operators Manual To reset: follow another vehicle for 5 minutes. This is Very Very Very frustrating and UNSAFE. This function should not automatically shut off. I paid a lot of money to try and figure out the problem. This is VERY UNSAFE for this feature of instantly shut off for no reason and is dangerous. Please fix this with a softwar…

Owner-reported narrative. Look up ODI 11624407 at NHTSA ↗

TRAVELING DOWN THE HIGHWAY AT 65 MPH, THE WHEELS STARTED SHAKING VIOLENTLY, AND WITHIN 5 SECONDS, THE POWER STEERING ASSIST COMPLETELY FAILED. IT TOOK EXCESSIVE STRENGTH TO STEER THE VEHICLE TO SAFETY. MERCEDES-BENZ IS REFUSING TO COVER THE REPAIR ON THE 15-MONTH OLD VAN THAT HAS 43000 MILES ON IT. THE ISSUE HAS BEEN IDENTIFIED AS A FAILED ELECTRIC ACTUATOR.

Owner-reported narrative. 43,000 miles reported. Look up ODI 11390987 at NHTSA ↗

The Lane Assist and Crosswind Assist do not work properly. When a gust of wind hits you or when you're passing a semi, the van immediately forces your vehicle off the road or into the other lane where there is another vehicle or a concrete barrier. It's very difficult to hold onto the steering wheel and try to maneuver the vehicle to stay in your lane. The only way to turn off these features are to turn off them off every time you start your vehicle. Mercedes Benz has told me there is no way to turn it off completely and they have had numero…

Owner-reported narrative. Look up ODI 11421986 at NHTSA ↗

At high altitudes (it's happened over 5000ft and not under that) while in 4x4 mode, the car occasionally just simply does not respond to throttle input while in drive. This is usually from a start while shifting from park or reverse into drive, but there is zero power which has now been dangerous a few times for us while on inclines or near traffic. It eventually goes away after shifting back and forth to park/reverse/neutral and trying to rev the engine. But it's inconsitent, infrequent and not particularly easy to reproduce.

Owner-reported narrative. Look up ODI 11634134 at NHTSA ↗

The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _…

Owner-reported narrative. Look up ODI 11432261 at NHTSA ↗