2010 Mercedes-Benz SPRINTER 2500: complaints, problems and recalls

OUR 2010 MERCEDES-BENZ (MB) 2500 SPRINTER VAN AT 57,000 HAD A CHECK ENGINE LIGHT TURN ON. WE TOOK IT TO THE DEALER AND THEY REST THE COMPUTER AND TOOK IT FOR A TEST DRIVE. UPON RETURNING FROM THE TEST DRIVE THEY TOLD US EVERYTHING WAS FINE. TWO DAYS LATER THE LIGHT TURNED ON AGAIN AND THE MOTOR RUNS ROUGH. I TOOK IT BACK INTO THE DEALER AND THE NEXT DAY THEY SAID MY PROBLEM WAS A SENSOR IN THE ADBLUE TANK. TO FIX THE PROBLEM THE TANK, SENSOR AND WIRING HARNESS MUST BE REPLACED AT A COST OF $2200.00. ADBLUE IS THE NAME FOR THE MB DIESEL EXHAUST …

Owner-reported narrative. 57,000 miles reported. Look up ODI 10452279 at NHTSA ↗

DURING AND AFTER RAIN VEHICLE LEAKS WATER (LIKE A WATER FALL ) THRU THE CEILING VENTS IN THE REAR OF THE CAR, DRENCHING ANY ONE WHO IS SEATED IN THE 1ST OR 2ND ROWS, SOME TIME THE DRIVER SEAT AND PASSENGER ALSO GET SOAKED WHILE DRIVING IF YOU BRAKE OR MAKE A TURN. *TR

Owner-reported narrative. 3,000 miles reported. Look up ODI 10554063 at NHTSA ↗

MY EMERGENCY EXIT WINDOW IS FALLING OUT... THE GLUE THAT HOLDS THE WINDOW IN THE HINGE HAS COME LOOSE.. I LOOKED UP HERE @ THE RECALL.GOV SITE TO SEE IF THIS WAS A COMMON PROBLEM, AND IT WAS... I TOOK MY SPRINTER VAN INTO THE DEALERSHIP TO HAVE IT REPAIRED, AND THEY SAID THERE IS NO RECALL ON MY WINDOW AND THAT I WOULD HAVE TO PAY $950 TO HAVE IT FULLY REPLACED WITH THE SAME DEFECTED WINDOW WITH NO WARRANTY... I NOW HAVE THE WINDOW DUCT TAPED DOWN TO HOLD IT IN PLACE. *TR

Owner-reported narrative. 99,482 miles reported. Look up ODI 10588927 at NHTSA ↗

I OWN A 2010 MERCEDES BENZ SPRINTER PASSENGER VAN (2500). I PURCHASED IT USED IN AUGUST 2014. THE DEALER I PURCHASED IT FROM INFORMED ME THAT THEY WERE FIXING A LEAK IN THE REAR AIR CONDITIONER. IN JANUARY, 2015 AFTER A SIGNIFICANT SNOWSTORM AND A FREEZE MY AIR CONDITIONING UNIT STARTED LEAKING. IT ONLY LEAKS DURING A RAIN STORM, BUT IT IS DUE TO THE SEAL THAT IS BETWEEN THE AIR-CONDITIONER AND ROOF OF THE VAN WHICH HAS BEEN TORN. I UNDERSTAND THAT THIS IS A PROBLEM IN NEARLY ALL SPRINTER MODELS. THIS POSES A SAFETY CONCERN FOR MY PASS…

Owner-reported narrative. 40,000 miles reported. Look up ODI 10713944 at NHTSA ↗

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 MERCEDES BENZ SPRINTER 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V077000 (AIR BAGS), 16V379000 (AIR BAGS) AND STATED THAT THE PARTS WERE NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE RECALL REPAIR. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

Owner-reported narrative. Look up ODI 10926670 at NHTSA ↗

TAKATA RECALL, THIS RECALL HAS BEEN GOING ON FOR 3 + YEARS WITH NO FIX FOR THE PROBLEM

Owner-reported narrative. Look up ODI 11039573 at NHTSA ↗

TL* TAKATA RECALL. THE CONTACT OWNS A 2010 MERCEDES-BENZ SPRINTER 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 16V379000 AND 16V077000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER MERCEDES-BENZ OF ANAHEIM (5395 E LA PALMA AVE, ANAHEIM, CA 92807) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS CONTACTED AT [phone removed], BUT COULD NOT…

Owner-reported narrative. Look up ODI 11064625 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 MERCEDES-BENZ SPRINTER 2500. THE CONTACT STATED THAT THE VEHICLE ABRUPTLY DECELERATED WHILE THE ACCELERATOR PEDAL WAS DEPRESSED. THE FAILURE OCCURRED NUMEROUS TIMES WHILE DRIVING VARIOUS SPEEDS. WHEN THE FAILURE OCCURRED, THE VEHICLE WOULD NOT ACCELERATE PAST 30 MPH. THE CONTACT ALSO STATED THAT THE CHECK ENGINE INDICATOR REMAINED ILLUMINATED AND THERE WAS A WARNING THAT THE DIESEL PUMP PREHEATING SYSTEM WAS MALFUNCTIONING. THE CONTACT PLACED THE GEAR INTO NEUTRAL, AND TURNED OFF AND RESTARTED THE VEHICLE TO BRING TH…

Owner-reported narrative. 180,000 miles reported. Look up ODI 11191783 at NHTSA ↗

Reported: 2010-06-29 (June 29, 2010)

SPRINTER IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 VEHICLES MANUFACTURED FROM NOVEMBER 2009 THROUGH MARCH 2010 AND SOLD UNDER THE MERCEDES-BENZ, FREIGHTLINER, AND DODGE BRAND NAME. THE SPRING PLATE WHICH ATTACHES THE OIL FILLER NECK TO THE CYLINDER-HEAD COVER MAY CRACK.

Consequence: A CRACK IN THE SPRING PLATE MAY RESULT IN ENGINE OIL LEAKING INTO THE ENGINE COMPARTMENT FROM THE OIL FILLER NECK, POSSIBLY LEADING TO THE ACCUMULATION OF DIRT IN THE ENGINE COMPARTMENT WITH SUBSEQUENT SOILING OF THE ROAD SURFACE WHICH COULD LEAD TO A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE OIL FILLER NECK FREE OF CHARGE. MERCEDES-BENZ USA IS HANDLING THE MERCEDES-BENZ AND FREIGHTLINER SPRINTER OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN, AND CHRYSLER IS HANDLING THE DODGE SPRINTER OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. THE SAFETY RECALL BEGAN ON OCTOBER 4, 2010. MERCEDES-BENZ AND FREIGHTLINER SPRINTER OWNERS MAY CONTACT MBUSA, LLC AT 1-877-762-8276, AND DODGE SPRINTER OWNERS MAY CONTACT CHRYSLER AT 1-800-992-1997.

Reported: 2010-12-21 (December 21, 2010)

SPRINTER IS RECALLING CERTAIN MODEL YEAR 2010-2011 FREIGHTLINER 2500 SPRINTER AND MERCEDES-BENZ SPRINTER VEHICLES EQUIPPED WITH AN EMERGENCY EXIT WINDOW. THE ADHESIVE BOND BETWEEN THE GLASS AND THE HINGE ON THE TOP OF THE WINDOW MAY LOOSEN.

Consequence: THE EMERGENCY EXIT WINDOW MAY SEPARATE FROM THE BODY AND COULD FALL INCREASING THE RISK OF INJURIES TO THE PASSENGER OR DRIVER.

Remedy: DEALERS WILL REPLACE THE EMERGENCY EXIT WINDOW IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 11, 2011. OWNERS MAY CONTACT SPRINTER AT 1-201-573-0600.

Reported: 2010-12-29 (December 29, 2010)

MERCEDES BENZ IS RECALLING CERTAIN MODEL YEAR 2007 AND 2010 2500 AND 3500 SPRINTER VEHICLES. THE CORRECT INTERIOR TRIM COVERING THE A-PILLARS MAY NOT HAVE BEEN INSTALLED. IF INCORRECT TRIM WAS INSTALLED ON A VEHICLE, THE VEHICLE WOULD FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE VEHICLES MAY NOT PROVIDE THE PROTECTION REQUIRED BY THE STANDARD IF AN OCCUPANT STRIKES THE A-PILLAR TRIM.

Remedy: MERCEDES-BENZ WILL CHECK TO SEE IF THE CORRECT TRIM COVER WAS INSTALLED AND, IF NOT, REPLACE THAT TRIM COVER WITH THE CORRECT ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2011. OWNERS MAY CONTACT MERCEDES-BENZ AT 843-695-5000.

Reported: 2011-03-30 (March 30, 2011)

MERCEDES-BENZ IS RECALLING CERTAIN MODEL YEAR 2008-2011 2500 AND 3500 SPRINTER VEHICLES EQUIPPED WITH AN OPTIONAL THREE-SEAT BENCH IN THE PASSENGER COMPARTMENT. THE SEAT BENCHES IN THE SECOND SEATING ROW MAY HAVE BEEN EQUIPPED WITH SAFETY BELTS THAT DO NOT MEET THE MINIMUM REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, "OCCUPANT PROTECTION IN INTERIOR IMPACT," AND MOTOR VEHICLE SAFETY STANDARD 209, "SEAT BELT ASSEMBLIES." FIRST, THOSE SAFETY BELTS MAY NOT LOCK AS REQUIRED. SECOND, THE ASSEMBLY LOOP MAY NOT PERFORM TO MINIMUM FORCE REQUIREMENTS.

Consequence: IN THE EVENT OF A CRASH, THE SAFETY BELTS IN THESE VEHICLES MAY NOT PERFORM AS REQUIRED SUCH THAT A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY OR DEATH IN THE EVENT OF A CRASH.

Remedy: MERCEDES-BENZ WILL INSPECT AND REPLACE ANY SEAT BELT ASSEMBLIES THAT DO NOT MEET THE REQUIREMENTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 15, 2011. OWNERS MAY CONTACT MERCEDES-BENZ AT 843-695-5000.

Reported: 2016-02-10 (February 10, 2016)

Daimler Vans USA, LLC (Daimler Vans) is recalling certain model year 2007-2009 Dodge Sprinter 2500 and 3500 vehicles manufactured July 1, 2006, to July 31, 2008, 2007-2014 Freightliner Sprinter 2500 and 3500 vehicles manufactured July 1, 2006, to July 1, 2014, and 2010-2014 Mercedes Benz Sprinter 2500 and 3500 vehicles manufactured July 1, 2010, to July 1, 2014. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Daimler Vans will notify the Mercedes-Benz and Freightliner owners and Fiat Chrysler will notify the Dodge owners. The respective dealers will replace the driver frontal air bag inflator, free of charge. The recall began March 31, 2017. Mercedes-Benz and Freightliner owners may contact Daimler Van's customer service at 1-877-762-8267. Dodge owners may contact Fiat Chrysler customer service at 1-800-853-1403.

Reported: 2017-07-28 (July 28, 2017)

Daimler Vans USA, LLC (DVUSA) is recalling certain 2010-2011 Freightliner and Mercedes Benz Sprinter 2500 and 3500 vehicles. These vehicles are equipped with certain air bag inflators assembled into the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: DVUSA will notify owners, and dealers will replace the front passenger side air bag, free of charge. The began on January 12, 2018. Owners may contact DVUSA customer service at 1-877-762-8267. Note: This recall partially supersedes recall 16V-379.