2004 Mazda MPV: complaints, problems and recalls

2004 MAZDA MPV WITH ONLY 400 MILES ON IT IS STARTING TO DEVELOP A SULFUR SMELL COMING FROM TAIL PIPE AREA. THIS HAS BEEN A ISSUE IN THE PAST WITH THE MPV. IS THERE A FIX. I HAVE NOT CONTACTED DEALER AS OF YET. *JB

Owner-reported narrative. Look up ODI 10062686 at NHTSA ↗

2004 MAZDA MPV PURCHASED ON FEB. 28, 2004. ON MAR. 27, 2004, ENGINE FAILED WITHOUT WARNING LIGHTS. FORTUNATELY, CAR WAS IDLE WHEN ENGINE FAILED. ONLY HAD 1,100 MILES ON VEHICLE. MANUFACTURER HAS NOT BEEN COOPERATIVE IN DIAGNOSING THE PROBLEM. INITIAL ASSESSMENT BY THE DEALER TECH AT STAR MAZDA IN GLENDALE, CA WAS THAT CONNECTING ROD FAILED AND ENGINE SEIZED. DEALER STATED THAT MAZDA'S OWN TECH PEOPLE WOULD HAVE TO TAKE A LOOK AT THE ENGINE TO DIAGNOSE PROBLEM. IT HAS ALREADY BEEN A WEEK. REQUESTED VEHICLE TO BE TOWED TO 1000 OAKS MAZDA, WHERE I…

Owner-reported narrative. 1,100 miles reported. Look up ODI 10064575 at NHTSA ↗

DURING INSPECTION DEALERSHIP INFORMED THE CONSUMER THAT ALL FOUR TIRES HAD TREAD SEPARATION. THE PROBLEM WAS NOT RESOLVED. DUNLOP SP4000, 215/60R16. *AK *NM

Owner-reported narrative. 5,599 miles reported. Look up ODI 10076173 at NHTSA ↗

WHILE DRIVING CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. A LOUD KNOCKING NOISE WAS HEARD FROM THE FRONT. CONSUMER WAS ABLE TO SLOW DOWN, AND PULLED OVER. CONSUMER HAD VEHICLE TOWED TO THE DEALER, AND MECHANIC DETERMINED THAT TRANSMISSION BLEW OUT DUE TO A WORN SHAFT SOLENOID. *AK

Owner-reported narrative. Look up ODI 10087390 at NHTSA ↗

(1) DRIVING ALONG IN TOWN, APROX 5 MPH 2) TIRE WENT FLAT, SEEMS AS IF SOMEONE STUCK A KNIFE THROUGH IT, BUT IT WAS FINE UPON LEAVING MY HOME (ONLY HAS 1,866 MILES)/ (3) NOT COVERED BY WARRENTY, HAVE TO PURCHASE NEW TIRE. *AK

Owner-reported narrative. Look up ODI 10088437 at NHTSA ↗

NHTSA RECALL 04V073000 SUBJECT: FMVSS 208 AIR BAGS. NO PARTS WERE AVAILABLE . *AK

Owner-reported narrative. Look up ODI 10094874 at NHTSA ↗

SIDEWALL OF THE RIGHT FRONT TIRE SPLIT IN TWO PLACES AFTER THE CONSUMER RAN OVER A CURB AT 5 MPH, WHICH CAUSED AN IMMEDIATE BLOWOUT. *BF ONE MONTH LATER THE CONSUMER RUBBED THE LEFT FRONT TIRE AGAINST A CURB WHILE PULLING THROUGH A NARROW DRIVEWAY AND THE LEFT FRONT TIRE SIDEWALL CAME APART IN THE SAME WAY AS THE FIRST TIRE DID. THE CONSUMER TOOK THE VEHICLE BACK TO THE DEALER, HOWEVER THE DEALER STATED IT WAS A ROAD HAZARD AND IT WAS NOT COVERED UNDER WARRANTY, BUT AS A COURTESY THEY REPLACED THE TIRE. THE CONSUMER REQUESTED THAT THE 17 IN…

Owner-reported narrative. Look up ODI 10099040 at NHTSA ↗

I HAD A SINGLE CAR ACCIDENT IN MY 2004 MAZDA MPV VAN WITH FRONT END SUSTAINING DAMAGE WITH NO DEPLOYMENT OF FRONT OR SIDE AIRBAGS. I SUSTAINED SIGNIFICANT HEAD AND FACIAL TRAUMA. *JB

Owner-reported narrative. 14,700 miles reported. Look up ODI 10100367 at NHTSA ↗

Reported: 2004-02-17 (February 17, 2004)

AS A RESULT OF AN NCAP TEST, CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE FRONT PASSENGER SEAT AIR BAG WAS NOT CORRECTLY WIRING.

Consequence: IN THE EVENT OF A CRASH, THE AIR BAG WILL NOT PROVIDE ADEQUATE PROTECTION.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS IN THE FRONT PASSENGER SEAT AIR BAG SYSTEM. THE RECALL BAGAN MARCH 5, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.

Reported: 2004-03-09 (March 9, 2004)

CERTAIN MINIVANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." SOME OF THESE VEHICLES WERE PRODUCED WITH AIR BAG WARNING LABELS INTENDED FOR THE CANADIAN MARKET. THUS, THE LABELS CONTAIN WARNINGS IN BOTH ENGLISH AND FRENCH. AS A RESULT, THE AREA OF THE ENGLISH WARNING IS ONLY 16 SQUARE CENTIMETERS, AS OPPOSED TO THE 30 SQUARE CENTIMETERS REQUIRED BY THE STANDARD.

Remedy: OWNERS WILL BE PROVIDED WITH AIR BAG CAUTION LABELS AND INSTALLATION INSTRUCTIONS WHICH WERE MAILED ON JULY 22, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.

Reported: 2004-06-10 (June 10, 2004)

THE TIRE INFLATION PRESSURE INDICATED ON THE VEHICLE CERTIFICATION LABEL IS NOT CORRECT. THE LABELS SHOW THE MAXIMUM TIRE PRESSURE AS 240 KPA/32 PSI WHEN IT SHOULD BE SHOWN AS 240 KPA/35 PSI. AS A RESULT OF THIS ERROR, THE LOAD RATIOS FOR THE 205/65R15 94H AND THE 215/60R16 95H TIRES EXCEED THE LEVELS PERMITTED BY FMVSS 120.

Consequence: IF THE TIRE IS OPERATED IN AN UNDER-INFLATED CONDITION, THE LOAD CARRYING CAPACITY OF THE VEHICLE MAY BE COMPROMISED, INCREASING THE RISK OF A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL THAT THEY CAN APPLY TO THEIR VEHICLE, OR THEY CAN HAVE A DEALER INSTALL THE LABEL, IF DESIRED. THE RECALL BEGAN ON JULY 16, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500, OPTION #4.

Reported: 2018-06-15 (June 15, 2018)

Mazda North America Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2006-2007 Mazdaspeed6 and 2004 MPV vehicles nationwide. Mazda is also recalling 2005-2006 MPV vehicles in Alabama, Arizona, Arkansas, California, Delaware, the District of Columbia, Florida, Georgia, Hawaii, Illinois, Indiana, Kansas, Kentucky, Louisiana, Maryland, Mississippi, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, South Carolina, Tennessee, Texas, Virginia, West Virginia, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. On July 9, 2019 this recall was expanded to include certain 2004-2011 RX-8 vehicles that were previously recalled under 16V-354 but have not yet been repaired. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these passenger air bag inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate inflator, free of charge. The recall began July 6, 2018. Mailing to the affected RX-8 owners began July 6, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: With the addition of the RX-8 vehicles, this recall fully supersedes recall 16V354.

Reported: 2019-10-31 (October 31, 2019)

Mazda North American Operations (Mazda) is recalling certain 2003-2008 Mazda6, 2004-2005 MPV, 2004 RX-8, and 2006-2007 Mazdaspeed6 vehicles. These vehicles had their passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Owners are advised not to drive their vehicles until the remedy is performed. Mazda will notify owners, and dealers will replace the front passenger air bag inflator with an alternate one, free of charge. The recall began December 3, 2019. Owners may contact Mazda customer service at 1-800-222-5500, option 4. Mazda's number for this recall is 2618F. Note: This recall supersedes recalls 13V130, 14V362, 14V773 and 15V869.