2023 Kia EV6: complaints, problems and recalls

While using I-Pedal mode the brake lights do not engage unless fully off of the accelerator. Even a large deceleration force does not engage any of the brake lights when coming to a full stop quickly. This is very dangerous as drivers behind cannot tell you are decelerating quickly.

Owner-reported narrative. Look up ODI 11523943 at NHTSA ↗

This car advertises that it is capable of fast charging on a level 2 charger up to 50amp. I purchased a level 2 charger capable of 50amps, but it causes the EV6 to overheat and stop charging. The dealership installed TSB ELE-283 but this does not fix the problem and is not an acceptable fix. I have owned this car 5 months, and it has been to the dealership service department 3 times for failing to charge. Kia has admitted that their dealerships don’t have the capacity to charge at the higher speeds, so they cannot replicate the issue and just k…

Owner-reported narrative. Look up ODI 11527152 at NHTSA ↗

I purchased my EV6 in April 2023, after 2 months, my charging abruptly stops, I will restart it and it fails minutes later. I have taken the car to the dealership 2x and they are unable to find the cause, I did further research and found an update that was applied on the second visit. This did not resolve the issue. I am having to drop the charging level down to "reduced" to get by. There are no warning messages on the dash or on the computer, at least none that Kia could find. There isn't a recall for this either. My concern is the safet…

Owner-reported narrative. Look up ODI 11529293 at NHTSA ↗

When using 1 pedal driving, it isn't necessary to use the brake pedal to stop the EV. The EV6 will only illuminate the brake lights when the accelerator pedal is completely released, or when the brake pedal is depressed. Since using 1 pedal driving does not require depressing the brake pedal to stop, the following vehicle has no indication or warning that the EV6 is stopping. I have experienced several instances of near rear-end collisions because of this dangerous issue with the Kia EV6. I emailed Kia asking if they were going to offer an OTA …

Owner-reported narrative. Look up ODI 11531901 at NHTSA ↗

When charging with L2 40A home charger vehicle gives a charging failed error. I live in Arizona where since the temperature has gone above 90 degrees in June the issue started. It will charge for a few minutes than fault. I have used this charger on other vehicles without issue. I need to change the vehicles charging settings ro reduced charging current for it to charge without error but this can take twice as long to charge on the reduced settings. I am convinced this is temperature related and the vehicle cannot charge high current in su…

Owner-reported narrative. Look up ODI 11532565 at NHTSA ↗

This issue has been persistent for at least 4 times a week for the past 4 months since getting the vehicle. The issue starts right after starting and driving the vehicle within about 5 mins after start-up the speakers start making an EXTREMELY loud/piercing abnormal sound while the vehicle is driving or even parked. I immediately have to pull over (while the loud noise is still happening) and turn the car on and over several time hoping the noise stops. The noise is extremely loud and abnormal static noise the entire time the issue occurs. The …

Owner-reported narrative. Look up ODI 11533606 at NHTSA ↗

The motor inverter for the rear motor failed while I was driving. The power cut out, and luckily I was able to drift over to the side of the road. On a highway, it would have been very dangerous. The dealer diagnosed the inverter issue, and said it needs to be replaced. The car has not been inspected by the manufacturer, the police, or insurance representatives. A warning message appeared the moment the power cut out. It said, "Check electric vehicle system."

Owner-reported narrative. Look up ODI 11533689 at NHTSA ↗

The car starts charging on my level 2 home charger then after about 10-20 min will stop and send me a message saying charging interrupted and will stop charging. I have taken it in to the dealership and they say they can see the code but that they did the recalls for it and it should be fixed. It is not and keeps happening. I am taking it back to the dealer tomorrow so they can look at it again

Owner-reported narrative. Look up ODI 11535958 at NHTSA ↗

Reported: 2024-01-31 (January 31, 2024)

Kia America, Inc. (Kia) is recalling certain 2023-2024 Niro EV and 2023 EV6 vehicles. One of the drive shafts may have been improperly heat-treated, allowing it to break under load and resulting in a loss of drive power.

Consequence: A loss of drive power increases the risk of a crash.

Remedy: Dealers will replace the drive shaft, free of charge. Owner notification letters were mailed March 28, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC295.

Reported: 2024-03-14 (March 14, 2024)

Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.

Consequence: A loss of drive power increases the risk of a crash.

Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters are expected to be mailed April 29, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC302.

Reported: 2024-11-18 (November 18, 2024)

Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.

Consequence: A loss of drive power increases the risk of a crash.

Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC327. This recall expands and replaces previous recall number 24V-200. Vehicles previously repaired under recall 24V-200 will need to have the new remedy completed.

Reported: 2026-07-02 (July 2, 2026)

Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 and 2024 EV9 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.

Consequence: A fire increases the risk of injury.

Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 7, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC375. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.