2007 Kenworth T300: complaints, problems and recalls

TL*THE CONTACT OWNS A 2007 KENWORTH T300. WHEN THE CONTACT CLOSED THE DRIVER'S SIDE DOOR WHILE THE VEHICLE WAS PARKED, THE WINDSHIELD DETACHED FROM THE BODY STRUCTURE. THERE WAS NO WARNING PRIOR TO THE FAILURE. HE WAS VERY CONCERNED OF THE SAFETY RISK INVOLVED AND THE POSSIBILITY OF THE WINDSHIELD DETACHING WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 10,000. THE CONSUMER STATED THE DESIGN OF THE GASKET THAT WAS SUPPOSE TO HOLD THE GLASS TO THE TRUCK. THE W…

Owner-reported narrative. 10,000 miles reported. Look up ODI 10232503 at NHTSA ↗

TL*THE CONTACT OWNS A 2007 KENWORTH T300. WHILE DRIVING APPROXIMATELY 18 MPH, THE STEERING WHEEL LOCKED WHEN A LEFT TURN WAS MADE. THE CONTACT HEARD AN EXCESSIVELY LOUD NOISE AT THE TIME OF THE FAILURE. HE ALSO EXPERIENCED DIFFICULTY WITH THE STEERING WHEEL PULLING TOWARDS THE LEFT. AFTERWARDS, THE STEERING WHEEL RELEASED AND WAS OPERABLE. THE FAILURE OCCURRED WITHOUT PRIOR WARNING. THE FAILURE RECURRED ON FIFTEEN SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER ON THREE OCCASIONS, BUT THE FAILURE PERSISTS. THE VEHICL…

Owner-reported narrative. 130,000 miles reported. Look up ODI 10240100 at NHTSA ↗

TL*THE CONTACT OWNS A 2007 KENWORTH T300. WHILE DRIVING APPROXIMATELY 18 MPH, THE STEERING WHEEL LOCKED WHEN A LEFT TURN WAS MADE. THE CONTACT HEARD AN EXCESSIVELY LOUD NOISE AT THE TIME OF THE FAILURE. HE ALSO EXPERIENCED DIFFICULTY WITH THE STEERING WHEEL PULLING TOWARDS THE LEFT. AFTERWARDS, THE STEERING WHEEL RELEASED AND WAS OPERABLE. THE FAILURE OCCURRED WITHOUT PRIOR WARNING. THE FAILURE RECURRED ON FIFTEEN SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER ON THREE OCCASIONS, BUT THE FAILURE PERSISTS. THE VEHICL…

Owner-reported narrative. 130,000 miles reported. Look up ODI 10240128 at NHTSA ↗

Reported: 2007-03-02 (March 2, 2007)

CERTAIN TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE TRAILER LIGHT LINE MAY HAVE BEEN ROUTED USING TOO TIGHT OF A BEND RADIUS. THIS ROUTING METHOD COULD CAUSE THE WIRES WITHIN THE HARNESS PLUG TO BE PULLED AWAY FROM THE CHASSIS PLUG RESULTING IN AN INTERMITTENT OR COMPLETE ELECTRICAL POWER LOSS TO THE TRAILER.

Consequence: SHOULD POWER BE LOST, THE ELECTRICAL CIRCUITS WOULD NOT PROVIDE POWER TO THE ANTILOCK SYSTEM ON THE TOWED VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REROUTE THE LIGHT LINE TO ELIMINATE THE EXCESSIVE BEND RADIUS AND REPLACE ANY PLUG OR HARNESS THAT HAS BEEN DAMAGED FREE OF CHARGE. THE RECALL BEGAN ON APRIL 16, 2007. OWNER MAY CONTACT KENWORTH AT 425-828-5440.

Reported: 2007-03-16 (March 16, 2007)

ON CERTAIN TRUCKS, THE WIRING, PARTS, OR TRANSMISSION PROGRAMMING REQUIRED FOR THE AUTO NEUTRAL FEATURE TO FUNCTION AS DESIGNED WERE EITHER NOT INSTALLED, CONNECTED, OR PROGRAMMED PROPERLY.

Consequence: IF ANY OF THESE CONDITIONS EXISTS, THE TRANSMISSION WILL NOT AUTOMATICALLY SHIFT INTO NEUTRAL WHEN LEFT IN DRIVE WITH THE PARKING BRAKE SET ENGAGED. THE VEHICLE COULD MOVE WITHOUT WARNING INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE AFFECTED VEHICLES TO ENSURE THE AUTO NEUTRAL FEATURE FUNCTIONS PROPERLY AND, IF NEEDED, WILL MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE RECALL BEGAN ON MAY 9, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440.

Reported: 2007-03-22 (March 22, 2007)

ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.

Consequence: IF A FATIGUE FAILURE OCCURS AND IS LEFT UNATTENDED, THE AXLE MAY LOCK UP OR THE END OF THE AXLE COULD COME OFF, WHICH MAY RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE AXLES FREE OF CHARGE. THE RECALL BEGAN ON MAY 9, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440 AND PETERBILT AT 1-940-591-4196.

Reported: 2007-05-21 (May 21, 2007)

ON CERTAIN TRUCKS EQUIPPED WITH CUMMINS ISC OR PACCAR PX8 ENGINES, THE JUMPER WIRE BETWEEN THE GRID HEATER RELAY TO THE FUSE BLOCK HAS BEEN ROUTED IN SUCH A WAY THAT THE POTENTIAL EXISTS FOR IT TO RUB AGAINST THE RADIATOR SUPPORT.

Consequence: THE SUSPECT WIRE IS DOWN STREAM OF THE FUSE; THIS CHAFF POINT COULD CAUSE THE 250 AMP CHARGE WIRE TO ARC, POTENTIALLY CAUSING A FIRE.

Remedy: DEALERS WILL INSPECT THE ROUTING OF THE JUMPER WIRE. IF THE WIRE IS NOT ROUTED CORRECTLY, IT WILL BE INSPECTED FOR RUBBING OR CHAFFING AND REPLACED IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 22, 2007. OWNERS MAY CONTACT KENWORTH AT 425-828-5440.

Reported: 2008-06-03 (June 3, 2008)

PACCAR IS RECALLING 36 MY 2007-2008 T270, T370 AND MY 207 T300 TRUCKS EQUIPPED WITH DUAL UNDER-CAB FUEL TANKS AND AN IN-CAB BATTERY BOX (ICBB). A HARNESS SUPPORT BRACKET MOUNTED ON THE UNDERSIDE OF THE CAB MAY COME IN CONTACT WITH THE FUEL LINE AT THE TOP OF THE FUEL SPLITTER VALVE.

Consequence: THE EDGE OF THE BRACKET MAY COMPROMISE THE FUEL LINE CAUSING AN INTERRUPTION IN FUEL FLOW, OR LOSS OF FUEL RESULTING IN COMPROMISED VEHICLE PERFORMANCE OR POTENTIALLY CAUSING A FIRE.

Remedy: DEALERS WILL RE-WORK THE EXISTING ICBB CABLE ROUTING BRACKET AND REPLACE THE FUEL SPLITTER VALVE BRACKET TO PROVIDE ADEQUATE CLEARANCE BETWEEN COMPONENTS. THE RECALL BEGAN O JUNE 30, 2008. OWNERS MAY CONTACT KENWORTH AT 1-425-828-5440.