2020 Jayco Fifth Wheel EAGLE: complaints, problems and recalls

DRIVERS SIDE CAMPER SLIDE CRACK. JAYCO WAS CALLED AND REPAIR SCHEDULED. JAYCO IS AWARE OF THE FRAME REINFORCEMENT NEEDED AND SIDE WALL CRACKING. NOT COVERING PROLONGED REPAIRS RELATED TO POOR MANUFACTURING PROCESS

Owner-reported narrative. Look up ODI 11388403 at NHTSA ↗

WITH LESS THAN 4500 MILES THE REAR AXLE FAILED, CAUSING SEVERE WEAR ON THE TIRE. WHEN RESEARCHING, THERE APPEARS TO BE A LOT OF COMPLAINTS IN REGARDS TO AXLE FAILURE. DEXTER REPLACED THE AXLE, BUT JAYCO WOULD NOT COVER THE REPLACEMENT UNDER WARRANTY, AND ADVISED I TAKE IT TO THE NEAREST JAYCO DEALERSHIP (72 MILES AWAY) USING THE SPARE. DURING THAT SHORT DRIVE TO HAVE THE REPAIRS DONE, THE SPARE SHOWED SEVERE WEAR ALSO.

Owner-reported narrative. 4,450 miles reported. Look up ODI 11406232 at NHTSA ↗

The contact owns a 2020 Jayco Eagle travel trailer. The contact received notification of NHTSA Campaign Number: 21V425000 (Equipment). The contact stated that the furnace was not operating properly, and the contact had to switch propane tanks. The dealer was made aware of the recall but informed the contact that parts were on backorder. The manufacturer was made aware of the failure but provided no assistance. Parts distribution disconnect.

Owner-reported narrative. Look up ODI 11440074 at NHTSA ↗

The contact owns a 2020 Jayco Trailer equipped with a Winntec 6020 two-stage propane regulator. The contact received a recall notification for NHTSA Campaign Number: 21V425000 (Equipment) however, the dealer informed the contact that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue but did not provide any assistance. The contact had not experienced a failure. Parts distribution disconnect.

Owner-reported narrative. Look up ODI 11445490 at NHTSA ↗

The contact owns a 2020 Jayco Eagle RV equipped with Winntec model 6020 two-stage propane regulators. The contact received a recall notification for NHTSA Campaign Number: 21V685000 (Equipment) however, the dealer informed the contact that the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and informed the contact that the parts were available but were on backorder for recall repairs. The contact…

Owner-reported narrative. Look up ODI 11448245 at NHTSA ↗

Structural frame cracks causing weakness over hitch.

Owner-reported narrative. Look up ODI 11462985 at NHTSA ↗

I have 2 recalls on this travel trailer, both related to propane systems. Recalls #20E-071 and 21V-425. 20E-071 was dated November 12,2020 and 21V-425 was dated August 2021. The dealer: Little Dealer Little Prices - 2350 West Deer Valley Road- Phoenix, AZ 85027 has failed to perform either of the recalls. I was gone there repeatedly to check on the status and was always told they were waiting for parts. In April of 2022 when I went to the dealer again I was told they work orders had been cancelled. Again, I furnished them with all the informat…

Owner-reported narrative. Look up ODI 11476145 at NHTSA ↗

Axel was manufactured with too much negative camber causing extreme tire ware. Blowouts could cause loss of control of vehicle.

Owner-reported narrative. Look up ODI 11479057 at NHTSA ↗

Reported: 2020-06-09 (June 9, 2020)

Jayco, Inc. (Jayco) is recalling certain 2020 Towable Eagle, Eagle HT, JayFlight, NorthPoint, Octane, Pinnacle, Seismic, and Talon recreational vehicles. The adhesive bond between the glass and the metal hinge frame of the frameless crank out vent and egress windows may fail which would then allow the glass to detach and fall out.

Consequence: If the window glass detaches while the vehicle is moving it could become a projectile, increasing the risk of injury or a crash.

Remedy: Jayco will notify owners, and dealers will inspect the frameless windows for proper adhesive bond strength, replacing the windows as necessary, free of charge. This recall began June 15, 2020. Owners may contact Jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901508.

Reported: 2021-06-04 (June 4, 2021)

Jayco, Inc. (Jayco) is recalling certain 2017-2018 Jayco Designer, 2017-2021 Eagle HT, Eagle, Jay Feather, Jay Flight SLX, Jay Flight, North Point, Octane Superlite, Pinnacle, White Hawk, 2017-2020 Eagle HT, 2018-2021 Jay Flight Bungalow, 2017-2019 Octane, and 2019-2020 Eagle HTX travel trailers and fifth wheels equipped with a Winntec model 6020 two-stage propane regulator. The regulator may fail, causing an increase in propane pressure.

Consequence: Increased propane pressure can enlarge the flames in gas appliances, increasing the risk of a fire.

Remedy: Dealers will replace the regulator and test the propane system for leaks, free of charge. Owner notification letters were mailed August 3, 2021. Owners may contact Jayco customer service at 1-800-283-8267.

Reported: 2021-09-02 (September 2, 2021)

Jayco, Inc. (Jayco) is recalling certain 2018-2021 Jayco Eagle, Talon, 2020 Eagle HT, 2021 Jay Feather, Jay Flight Bungalow, Jay Flight Octane, North Point, Octane Super Lite, Pinnacle, White Hawk, 2021-2022 Jay Flights SLX, Jay Flight, and 2017-2021 Seismic recreational vehicles, equipped with Winntec model 6020 two-stage propane regulators. The regulator may fail, causing an increase in propane pressure.

Consequence: Increased propane pressure can enlarge the flames in gas appliances, increasing the risk of a fire.

Remedy: Dealers will replace the regulator, and test the propane system for leaks, free of charge. Owner notification letters were mailed November 1, 2021. Owners may contact Jayco customer service at 1-800-283-8267.