2012 Ic Bus CE: complaints, problems and recalls

ENGINE FAILED DUE TO LOST COMPRESSION DURING A SCHOOL ROUTE.

Owner-reported narrative. 88,691 miles reported. Look up ODI 11309601 at NHTSA ↗

Reported: 2011-05-18 (May 18, 2011)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011-2012 IC AC, BE, CE, HC AND INTERNATIONAL 4300, AND TERRASTAR COMMERCIAL TRUCKS MANUFACTURED FROM FEBRUARY 25, 2010, THROUGH APRIL 4, 2011, AND EQUIPPED WITH A MAXXFORCE 7 ENGINE. A CAP ON THE RETURN FUEL VALVE MAY FALL OFF ALLOWING AIR TO BE DRAWN INTO THE FUEL SYSTEM POSSIBLY RESULTING IN ENGINE HARD START, NO START, OR STALL CONDITIONS.

Consequence: ENGINE STALL ON THE ROADWAY INCREASES THE RISK OF A VEHICLE CRASH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE RETURN FUEL VALVE CAP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 18, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2011-05-20 (May 20, 2011)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 IC CE AND BE SCHOOL BUSES MANUFACTURED FROM MAY 27, 2010, THROUGH MARCH 8, 2011, EQUIPPED WITH MAXXFORCE 7 ENGINES. A CAP ON THE RETURN FUEL VALVE MAY FALL OFF, ALLOWING AIR TO BE DRAWN INTO THE FUEL SYSTEM, POSSIBLY RESULTING IN ENGINE HARD START, NO START, OR STALL CONDITIONS.

Consequence: ENGINE STALL ON THE ROADWAY INCREASES THE RISK OF A VEHICLE CRASH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE RETURN FUEL VALVE CAP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 12, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2011-07-22 (July 22, 2011)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 IC CE AND RE SCHOOL BUSES MANUFACTURED FROM OCTOBER 8, 2009, THROUGH APRIL 14, 2011. THESE BUSES WERE BUILT WITHOUT OR INCORRECTLY INSTALLED FLOOR CHANNEL REINFORCEMENTS. ACCORDINGLY, THE BUSES FAIL TO CONFORM WITH THE SEAT BACK REAR FORCE AND DISPLACEMENT REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: NONCOMPLIANCE TO THE STANDARD INCREASES THE PASSENGER'S RISK OF REARWARD EJECTION FROM THE SEAT WHICH MAY CAUSE PERSONAL INJURY OR DEATH IN THE EVENT OF A CRASH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE SEPTEMBER 16, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2011-07-21 (July 21, 2011)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2012 IC BE, CE, AND FE SCHOOL BUSES MANUFACTURED FROM NOVEMBER 1, 2006, THROUGH MAY 2, 2011. THE REFLECTIVE TAPE FOR THE REAR EXIT DOOR MAY NOT HAVE BEEN TOTALLY COMPLETED. ACCORDINGLY, THE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

Consequence: THIS NONCOMPLIANCE MAY REDUCE CONSPICUITY OF THE REAR DOOR, REDUCING THE ABILITY OF EMERGENCY PERSONNEL TO IDENTIFY AND GAIN ACCESS TO THE REAR EXIT DURING AN EMERGENCY, POSSIBLY INCREASING THE OCCUPANT'S RISK OF PERSONAL INJURY OR DEATH DURING AN EMERGENCY.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE BUSES AND ADD REFLECTIVE TAPE IF NECESSARY. THE SAFETY RECALL BEGAN ON AUGUST 3, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2011-08-18 (August 18, 2011)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2007-2012 IC CE AND BE SCHOOL BUSES MANUFACTURED FROM JUNE 27, 2006, THROUGH MARCH 23, 2011, EQUIPPED WITH A MAXXFORCE 7 ENGINE FEATURE CODE 12NTH, 12NTD, 12NTE, 12NTG, 12VYY, OR 12627 AND ALTERNATOR FEATURE CODE 0008GGR, 0008GGM, 0008GWX, OR 0008GEL. THE POSITIVE ALTERNATOR CABLE MAY RUB ON THE ENGINE CONTROL MODULE MOUNTING BRACKET, POSSIBLY CHAFING ITS INSULATION AND CAUSING AN ELECTRICAL SHORT.

Consequence: AN ELECTRICAL SHORT MAY CAUSE A VEHICLE FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE ALTERNATOR CABLE AND THE INSTALLATION OF THE TIE STRAPS TO ROUTE THE ALTERNATOR CABLE AWAY FROM THE ENGINE CONTROL MODULE MOUNTING BRACKET. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 27, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2011-08-18 (August 18, 2011)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2007-2012 IC CE AND BE COMMERCIAL BUSES MANUFACTURED FROM JUNE 27, 2006, THROUGH MARCH 23, 2011, EQUIPPED WITH A MAXXFORCE 7 ENGINE FEATURE CODE 12NTH, 12NTD, 12NTE, 12NTG, 12VYY, OR 12627 AND ALTERNATOR FEATURE CODE 0008GGR, 0008GGM, 0008GWX, OR 0008GEL. THE POSITIVE ALTERNATOR CABLE MAY RUB ON THE ENGINE CONTROL MODULE MOUNTING BRACKET, POSSIBLY CHAFING ITS INSULATION AND CAUSING AN ELECTRICAL SHORT.

Consequence: AN ELECTRICAL SHORT MAY CAUSE A VEHICLE FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL INSPECT AND REPLACE, IF NECESSARY, THE ALTERNATOR CABLE. TIE STRAPS WILL BE INSTALLED TO ROUTE THE ALTERNATOR CABLE AWAY FROM THE ENGINE CONTROL MODULE MOUNTING BRACKET. THESE REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 27, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2012-02-16 (February 16, 2012)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011-2012 IC BUS BE AND CE AND CERTAIN MODEL YEAR 2012 RE SCHOOL BUSES MANUFACTURED FROM APRIL 8, 2010 THROUGH JULY 1, 2011, EQUIPPED WITH C. E. WHITE SEAT CUSHIONS. THE SELF-LATCHING MECHANISM USED TO RETAIN THE SEAT CUSHION TO THE FRAME MAY NOT ACTIVATE. THUS, THESE SEATS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: IF THE SEAT CUSHION IS NOT SECURELY LATCHED TO THE SEAT STRUCTURE, THE SEAT COULD BECOME DISLODGED, INCREASING THE RISK OF INJURY TO THE VEHICLE OCCUPANTS.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE SEATS FREE OF CHARGE. OWNERS MAY CONTACT NAVISTAR AT 260-461-1890.

Reported: 2012-02-16 (February 16, 2012)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2012-2013 IC BUS CE AND RE SCHOOL BUSES MANUFACTURED FROM DECEMBER 2, 2010, THROUGH JANUARY 26, 2012, AND EQUIPPED WITH BENDIX ATR-6 ANTILOCK TRACTION RELAY VALVES. IN EXTREMELY COLD CONDITIONS, THESE BENDIX RELAY VALVES MAY POTENTIALLY DEVELOP INTERNAL LEAKAGE. INTERNAL LEAKAGE CAN LEAD TO AIR PRESSURE BEING DELIVERED TO AFFECTED PRIMARY OR SECONDARY BRAKES CAUSING CONTINUOUS BRAKE APPLICATION.

Consequence: UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE DRIVER TO LOSE CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH. ALSO, THE BRAKES MAY BE APPLIED WITHOUT ILLUMINATING THE BRAKE LIGHTS, FAILING TO GIVE PROPER WARNING TO OTHER DRIVERS.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL PROVIDE A TEMPORARY REPAIR UNTIL BENDIX DEVELOPS A PERMANENT REMEDY. THE SAFETY RECALL BEGAN ON APRIL 40, 2012. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. OWNERS MAY CONTACT NAVISTAR AT 260-461-1890.

Reported: 2012-06-21 (June 21, 2012)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2012 AND 2013 IC CE, RE, AND BE SCHOOL BUSES MANUFACTURED FROM APRIL 1, 2011, THROUGH MARCH 31, 2012, EQUIPPED WITH PROLO ROOF ESCAPE HATCHES. INCREASED FRICTION BETWEEN THE REAR PLATE ASSEMBLIES, P/NO. 009327, AND THE NYLON REAR POP-UP SUPPORT, P/NO. 008956, MAY RESULT IN AN OPENING FORCE OF THE PROLO ROOF HATCHES THAT EXCEEDS FEDERAL STANDARD REQUIREMENTS. THUS, THESE HATCHES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

Consequence: IN THE EVENT OF AN EMERGENCY, EGRESS OF THE BUS MAY BE HINDERED POSSIBLY RESULTING IN INJURY TO THE VEHICLE OCCUPANTS.

Remedy: NAVISTAR WILL NOTIFY OWNERS. SPECIALTY MANUFACTURING, INC. (SMI) WILL PROVIDE SERVICE KITS ALONG WITH REPAIR INSTRUCTIONS TO DEALERS AND OWNERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 3, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890 OR SMI AT 1-800-951-7867.

Reported: 2012-06-21 (June 21, 2012)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2012 AND 2013 IC BUS CE AND RE COMMERCIAL BUSES MANUFACTURED FROM APRIL1, 2011, THROUGH MARCH 31, 2012, EQUIPPED WITH PROLO ROOF ESCAPE HATCHES. INCREASED FRICTION BETWEEN THE REAR PLATE ASSEMBLIES, P/NO. 009327, AND THE NYLON REAR POP-UP SUPPORT, P/NO. 008956, MAY RESULT IN AN OPENING FORCE OF THE PROLO ROOF HATCHES THAT EXCEEDS FEDERAL STANDARD REQUIREMENTS. THUS, THESE HATCHES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

Consequence: IN THE EVENT OF AN EMERGENCY, EGRESS OF THE BUS MAY BE HINDERED POSSIBLY RESULTING IN INJURY TO THE VEHICLE OCCUPANTS.

Remedy: NAVISTAR WILL NOTIFY OWNERS. SPECIALTY MANUFACTURING, INC. (SMI) WILL PROVIDE SERVICE KITS ALONG WITH REPAIR INSTRUCTIONS TO DEALERS AND OWNERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 3, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890 OR SMI AT 1-800-951-7867.

Reported: 2012-06-22 (June 22, 2012)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011-2012 IC CE SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 7, 2010 THROUGH SEPTEMBER 9, 2010. THE INTERIOR LOWER LINING FAILS TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, “SCHOOL BUS BODY JOINT STRENGTH.”

Consequence: IN THE EVENT OF A CRASH, THERE IS AN INCREASED RISK OF PERSONAL INJURY TO VEHICLE OCCUPANTS.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND RETIGHTEN JOINT SCREWS TO THE PROPER SPECIFICATION, FREE OF CHARGE. THE RECALL BEGAN ON JULY 23, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890.

Reported: 2013-01-17 (January 17, 2013)

Navistar is recalling certain model year 2012-2013 IC Bus brand model 1300FBC, CE, HC, and RE buses; model year 2011-2013 International brand model Durastar, model year 2013 International brand Workstar trucks; model year 2013 Holiday Rambler brand model Ambassador and Endeavor vehicles; and model year 2013 Monaco brand model Diplomat and Knight vehicles. These vehicles were manufactured August 5, 2010 through September 6, 2012 and are equipped with certain 2011-2013 model year I-6 engines with feature codes 12NUK, 12NUL, 12NUM, 12NUN, 12NUP, 12NUR, 12NUS, 12NUT, 12NUU, 12NUV, 12NUX, 12NUY and 12NUZ. The injection pressure regulator (IPR) harness wire may break due to vibrational damage. This could cause an unexpected shut down of the engine.

Consequence: An unexpected engine shut down while driving may increase the risk of a vehicle crash.

Remedy: Navistar will notify owners, and dealers will replace the IPR wire connector free of charge. The safety recall began on March 15, 2013. Owners may contact Navistar at 1-800-448-7825.

Reported: 2013-08-07 (August 7, 2013)

Navistar, Inc. is recalling certain model year 2013-2014 IC Bus AE, and 2011-2014 BE, CE, and RE buses. These buses were manufactured February 11, 2010, through June 17, 2013. The passenger seat foam padding did not adequately reduce the impact forces to the knee in the lower outside corners of the seat back during compliance testing. Thus, these buses fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 222, "School Bus Passenger Seating and Crash Protection."

Consequence: In the event of a crash, the seat padding may not properly protect against knee impact force, increasing the risk of injury.

Remedy: Navistar will notify owners, and dealers will install polystyrene blocks in the lower outside corners of each seat to increase the knee protection, free of charge. The recall began on October 10, 2013. Owners may contact Navistar at 1-800-448-7825. Navistar's recall campaign number is 13512.

Reported: 2014-02-07 (February 7, 2014)

Navistar Inc. (Navistar) is recalling certain model year 2010-2011 IC bus 3200, model year 2012 and 2014 IC bus CE and model year 2011-2013 IC bus HC transit buses and model year 2008-2013 International 4300 and model year 2013 International Workstar commercial trucks equipped with Eaton hybrid automated transmissions. The software controlling the affected transmissions may improperly raise the vehicle's engine speed during downshifts without the driver's input.

Consequence: The increase in engine speed may result in unintended acceleration, increasing the risk of a crash.

Remedy: Navistar will notify owners and Eaton authorized service facilities will update the Hybrid Control Module Software version, free of charge. The recall began on May 28, 2014. Owners may contact Navistar at 1-331-332-1590.

Reported: 2014-02-07 (February 7, 2014)

Navistar, Inc. is recalling certain model year 2012-2014 model year CE school buses manufactured December 31, 2010, through November 6, 2012, and equipped with Eaton-brand hybrid automated transmissions. The software controlling the affected transmissions may improperly raise the vehicle's engine speed during downshifts without the driver's input.

Consequence: The increase in engine speed may result in unintended acceleration, increasing the risk of a crash.

Remedy: Navistar will notify owners and Eaton authorized service facilities will update the Hybrid Control Module Software version, free of charge. The recall began on May 28, 2014. Owners may contact Navistar at 1-331-332-1590.

Reported: 2014-11-03 (November 3, 2014)

Navistar, Inc.(Navistar) is recalling certain model year 2007-2015 IC CE transit buses manufactured January 23,2006, to May 12, 2014, 2008, and 2011 IC FE transit buses manufactured October 5, 2006, to September 28, 2009, and 2009-2010, and 2013 IC RE transit buses manufactured September 19, 2007, to November 29, 2011, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Navistar will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The interim notices were mailed on December 29, 2014. The recall began on January 29, 2015. Owners may contact Navistar customer service at 1-331-332-1590 or Ricon customer service at 1-800-322-2884. Navistar's number for this recall is 14517.

Reported: 2014-11-03 (November 3, 2014)

Navistar, Inc. (Navistar) is recalling certain model year 2013-2015 IC AE, 2007-2015 IC BE, CE, 2007-2011 IC FE, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Navistar will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on January 29, 2015. Owners may contact Navistar customer service at 1-331-332-1590 or Ricon customer service at 1-800-322-2884. Navistar's number for this recall is 14518.

Reported: 2015-11-19 (November 19, 2015)

Kingmor Supply, Inc. (Kingmor) is recalling certain model year 2005-2017 IC CE school buses manufactured September 1, 2005, to May 1, 2017, and modified to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts built by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy: Kingmor will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 18, 2015. Owners may contact Kingmor customer service at 1-800-782-4474, or Ricon Customer Service at 1-800-322-2884. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Reported: 2015-12-22 (December 22, 2015)

Navistar, Inc. is recalling certain model year 2007-2015 IC BE and CE school buses, 2013-2015 IC AE school buses, 2007-2011 IC FE school buses, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy: Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on February 19, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Reported: 2015-12-23 (December 23, 2015)

Navistar, Inc. is recalling certain model year 2007-2015 IC CE transit buses, 2008-2011 IC FE transit buses and 2009-2013 IC RE transit buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy: Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on February 19, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Reported: 2016-11-18 (November 18, 2016)

Navistar, Inc. (Navistar) is recalling certain model year 2011-2016 IC Bus CE school buses manufactured November 3, 2009, to February 26, 2015, and 2012-2015 IC Bus BE school buses manufactured August 2, 2010, to September 15, 2014. The affected vehicles have a water shutoff valve, inside, forward of driver heater (feature code 48PPJ or 48PPP) that has a formed heater hose that over time, may fatigue and split resulting in hot engine coolant fluid leaking into the driver's foot area.

Consequence: If hot, pressurized coolant suddenly spills into the operator's foot area, there is an increased risk of a burn injury or a crash.

Remedy: Navistar will notify owners, and dealers will replace the formed heater hose with a more robust one, free of charge. The recall began on January 4, 2017. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 16510.

Reported: 2016-11-18 (November 18, 2016)

Navistar, Inc. (Navistar) is recalling certain model year 2011-2016 IC Bus CE transit buses manufactured July 1, 2010, to February 4, 2015, and one IC Bus BE transit bus manufactured on November 2, 2010. The affected vehicles have a water shutoff valve, inside, forward of driver heater (feature code 48PPJ or 48PPP) that has a formed heater hose that over time, may fatigue and split resulting in hot engine coolant fluid leaking into the driver's foot area.

Consequence: If hot, pressurized coolant suddenly spills into the operator's foot area, there is an increased risk of a burn injury or a crash.

Remedy: Navistar will notify owners, and dealers will replace the formed heater hose with a more robust one, free of charge. The recall began on January 4, 2017. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 16511.