2002 Honda PASSPORT: complaints, problems and recalls

CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING THE VEHICLE WILL SHUT OFF CAUSING CONSUMER TO PULL OVER. DEALER NOTIFIED. TS

Owner-reported narrative. Look up ODI 10004143 at NHTSA ↗

TRANSMISSION WENT DEAD WITHOUT WARNING, HAD BAD SEAL. PH

Owner-reported narrative. Look up ODI 10005888 at NHTSA ↗

CONSUMER STATES THAT WHILE DRIVING, THE REAR PASSENGER SIDE TIRE BLEW OUT CAUSING THE CONSUMER TO PULL OVER. SIZE#1956515 PLEASE PROVIDE THE DOT#. DEALER NOTIFIED. *PH

Owner-reported narrative. Look up ODI 10031716 at NHTSA ↗

WHILE DRIVING 30 MPH AND APPLYING THE BRAKES WHILE ON A BUMPY SERVICE BRAKES FAILED. TAKEN VEHICLE TO DEALERSHIP, AND THE CAUSE OF PROBLEM WAS NOT RESOLVED BY THE MECHANIC.*AK

Owner-reported narrative. 40,000 miles reported. Look up ODI 10042545 at NHTSA ↗

WHILE DRIVING 55 MPH, THE DRIVER APPLIED THE BRAKES AND WITHOUT WARNING THE VEHICLE ACCELERATED. THE DRIVER APPLIED THE BRAKES BUT FAILED. THIS CAUSED THE DRIVER TO COLLIDE WITH THE VEHICLE IN FRONT. UPON, IMPACT BOTH FRONTAL AIR BAGS FAILED TO DEPLOY. THE DRIVER SUSTAINED MAJOR INJURIES AND WAS TRANSPORTED TO THE HOSPITAL BY AMBULANCE. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. THE CAUSE HAS NOT BEEN DETERMINED AT THIS TIME. PLEASE PROVIDE FURTHER DETAILS. *NM

Owner-reported narrative. Look up ODI 10082121 at NHTSA ↗

WHILE DRIVING ENGINE WARNING LIGHT ILLUMINATED. CONSUMER PULLED OVER, AND HAD THE VEHICLE TOWED. DEALERSHIP INFORMED THE CONSUMER THAT THE PROBLEM PERTAINED TO ENGINE SLUDGE. *AK

Owner-reported narrative. 32,000 miles reported. Look up ODI 10099859 at NHTSA ↗

WHILE PARKING, THE VEHICLE'S RUBBER COVER ON THE BRAKE PEDAL SLIPPED OFF THE PEDAL, CAUSING THE CONSUMER'S FOOT TO SLIDE OFF THE PEDAL AND HIT AGAINST THE ACCELERATOR PEDAL, WHICH IN TURN, CAUSED THE VEHICLE TO LURCH FORWARD AND HIT A CONCRETE WALL. THE DEALER WAS NOTIFIED. *AK THE AIR BAG DID NOT DEPLOY. THE CONSUMER STATED THAT A BENT PLATE ACROSS THE BOTTOM OF THE PEDAL LEVER WAS THE CAUSE OF THE FAILURE AND ACCIDENT. *TC *SC

Owner-reported narrative. 36,785 miles reported. Look up ODI 10102011 at NHTSA ↗

TL*THE CONTACT OWNS A 2002 HONDA PASSPORT. THE CONTACT STATED THAT THE FRAME RUSTED, CAUSED THE STABILIZER BAR TO FRACTURE AND SEPARATE FROM THE VEHICLE. THE DEALER DEEMED THE VEHICLE AS UNSAFE TO DRIVE AND ADVISED HAVING THE FRAME REPLACED. THE CONTACT DECLINED THE OFFER. THE MANUFACTURER WAS CONTACTED BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 116,500.

Owner-reported narrative. 116,500 miles reported. Look up ODI 10325700 at NHTSA ↗

Reported: 2005-10-07 (October 7, 2005)

CERTAIN SPORT UTILITY VEHICLES THAT HAVE BEEN EXPOSED TO FUEL CONTAMINATED WITH SILICON MAY DEVELOP SMALL PIN HOLES IN THE FUEL PUMP FEED PORT. SILICON HAS BEEN IDENTIFIED IN THE FUEL SYSTEMS OF AFFECTED VEHICLES AND IN CERTAIN FUEL AVAILABLE IN THE REGION OF TYLER, TEXAS. THIS RECALL WILL BE LAUNCHED FOR VEHICLES REGISTERED IN TEXAS AND THE FOUR SURROUNDING STATES: OKLAHOMA, ARKANSAS, NEW MEXICO AND LOUISIANA.

Consequence: A FUEL LEAK COULD LEAD TO A VEHICLE FIRE.

Remedy: FOR VEHICLES REGISTERED IN THE STATES IDENTIFIED ABOVE, DEALERS WILL PROVIDE A NEW COVER OVER THE EXISTING FEED PORT ON THE FUEL PUMP OR, IF THE EXISTING FEED PORT HAS ALREADY BEEN DAMAGED, DEALERS WILL INSTALL A NEW FUEL PUMP THAT IS EQUIPPED WITH THE NEW COVER. THE NEW COVER WILL BE MADE OF A DIFFERENT MATERIAL. THE RECALL BEGAN ON NOVEMBER 25, 2005. OWNERS MAY CONTACT ISUZU AT 1-800-255-6727.

Reported: 2010-09-22 (September 22, 2010)

ISUZU IS RECALLING CERTAIN MODEL YEAR 1998-2002 ISUZU RODEO AND MODEL YEAR 2002 ISUZU AXIOM VEHICLES, AND HONDA IS RECALLING CERTAIN 1998-2002 HONDA PASSPORT VEHICLES, THAT WERE ORIGINALLY SOLD, OR ARE CURRENTLY REGISTERED, IN THE STATES OF MAINE, NEW HAMPSHIRE, VERMONT, MASSACHUSETTS, RHODE ISLAND, CONNECTICUT, NEW YORK, NEW JERSEY, PENNSYLVANIA, DELAWARE, MARYLAND, THE DISTRICT OF COLUMBIA, WEST VIRGINIA, OHIO, INDIANA, MICHIGAN, ILLINOIS, WISCONSIN, MINNESOTA, IOWA, MISSOURI, AND KENTUCKY. VEHICLES THAT HAVE EXPERIENCED SUSTAINED EXPOSURE TO HIGHLY CORROSIVE MATERIALS USED IN SOME JURISDICTIONS FOR ROAD DEICING PURPOSES MAY EXPERIENCE EXCESSIVE CORROSION IN THE VICINITY OF THE FORWARD MOUNTING POINT BRACKET FOR THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK PRIOR TO THE TIME THAT SUCH CORROSION WOULD NORMALLY BE EXPECTED.

Consequence: EXCESSIVE CORROSION MAY RESULT IN THE LEFT OR RIGHT REAR SUSPENSION LOWER LINK BRACKET BECOMING DETACHED FROM THE FRAME, WHICH CAN AFFECT VEHICLE HANDLING AND POTENTIALLY CAUSE A CRASH.

Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION LOWER LINK BRACKET AREA. FOR VEHICLES IN WHICH LITTLE OR NO CORROSION IS FOUND, THE AREA WILL BE TREATED WITH AN ANTI-CORROSIVE COMPOUND. FOR VEHICLES IN WHICH CORROSION HAS DAMAGED THE REAR SUSPENSION LOWER LINK BRACKET AND AFFECTED ITS CONNECTION TO THE VEHICLE FRAME, A REINFORCEMENT BRACKET WILL BE INSTALLED. IN THE RARE EVENT THE CORROSION IS SO SEVERE THAT THE REINFORCEMENT BRACKET REMEDY WOULD NOT BE APPROPRIATE, A REPURCHASE OFFER WILL BE EXTENDED TO THE VEHICLE'S OWNER. ALL INSPECTIONS AND REMEDIES WILL BE PROVIDED FREE OF CHARGE FOR VEHICLES THAT ARE 10 YEARS OLD OR LESS. FOR VEHICLES OLDER THAN 10 YEARS, ISUZU WILL OFFER A FREE REMEDY, BUT ONLY IF THE VEHICLE IS PRESENTED TO AN ISUZU SERVICE FACILITY, OR HONDA DEALER (AS APPLICABLE), DEALER WITHIN 12 MONTHS OF WHEN OWNER NOTIFICATIONS WERE ISSUED. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. ISUZU OWNERS MAY CONTACT ISUZU AT 1-800-255-6727. HONDA OWNERS MAY CONTACT HONDA AT 1-800-999-1009.