2000 Gmc YUKON XL: complaints, problems and recalls

PURCHASED USED YUKON XL ON 10.17,02, ON JAN 6,2003 COMPUTER MODULE HAD TO BE REPLACED, CHEVY DEALER WANTED TO REPLACE IT FOR $800 PLUS LABOR, AFTER NEGOTIATIONS THE FINAL PRICE WAS $465, I HAVE AN EXTENDED WARRANTY WHICH OF COURSE DOESN'T COVER THE COMPUTER MODULE....IN TWO YEARS THE MODULE NEEDED REPLACEMENT? THE COMPUTER MODULE IS THE MAJOR PART, I DON'T LIKE THIS TRUCK, I WAS STUCK AND EVEN RECEIVED A TICKET BECAUSE IT WAS ON A SUNDAY NIGHT AND COULDN'T GET IT TOWED UNTIL MONDAY MORNING.....I THOUGHT THIS WOULD BE A DEPENDABLE CAR, WAS I MIS…

Owner-reported narrative. Look up ODI 10000939 at NHTSA ↗

WHILE TRAVELING ON THE HIGHWAY WITH THE CRUISE CONTROL SET AT 72MPH, WHICH HAD BEEN ON AND IN PLACE FOR ABOUT 20 MINUTES, I LOOKED DOWN AND SAW THAT THE CAR WAS NOW GOING 85 - EVEN THOUGH I HAD NOT TOUCHED THE ACCELERATOR. I DECIDED THAT I WOULD HIT THE BRAKE A LITTLE TO DEACTIVATE THE CRUISE AND RESET IT. AFTER TOUCHING THE BRAKE, BUT BEFORE I PUT MY FOOT ON THE ACCELERATOR THE CAR WAS BACK UP TO 80 - 85. I PLAYED AROUND WITH THE CRUISE CONTROL SWITCH, HOPING TO STOP THE PROBLEM. NOTHING WORKED IN THAT REGARD, SO I THOUGHT I WOULD JUST GET…

Owner-reported narrative. 61,115 miles reported. Look up ODI 10005329 at NHTSA ↗

I DISCOVERED TWO GAPS IN THE REAR SEALS ON THE LIFT GATE OF MY 2000 GMC YUKON XL. THE GAPS ARE AT THE BOTTOM CORNERS OF THE LIFT GATE (RIGHT AND LEFT SIDES) AND ARE APPROXIMATELY 1 TO 3 INCHES LONG AND ABOUT 1/16" WIDE. THESE GAPS WILL ALLOW EXHAUST GASSES TO COME INTO THE VEHICLE, OR WATER IN THE EVENT OF A HEAVY RAINSTORM. WE PLAN TO TAKE THE VEHICLE TO THE NEAREST DEALER VERY SOON, AS WE HAVE 35,990 MILES ON IT AND WE WANT IT FIXED UNDER WARRANTY. THE SEALS APPEAR TO BE INADEQUATE, I.E. INSUFFICIENT IN SIZE OR THICKNESS TO ADEQUATELY SEAL…

Owner-reported narrative. 35,990 miles reported. Look up ODI 10005575 at NHTSA ↗

I OWN A 2000 GMC YUKON XL. OVER THE PAST FEW MONTHS, I HAVE HAD A PROBLEM WITH THE VEHICLE CONTINUALLY BLOWING A FUSE (ECM B FUSE). UPON MY OWN RESEARCH INTO THE CIRCUITRY, I DETERMINED THE LIKELY PROBLEM WAS THE FUEL PUMP. I REPLACED THE FUEL PUMP AND UPON REMOVING AND INSPECTING THE OLD COMPONENT, I DISCOVERED THE HOT WIRE (GRAY WIRE) WHICH OPERATES THE PUMP MOTOR HAD BEEN HOT ENOUGH TO MELT THE INSULATION OFF THE WIRE. MOREOVER, THIS HOT WIRE HAD MELTED INTO ONE OF THE WIRES OF THE FUEL LEVEL SENDING UNIT, WHICH IS A GROUND CIRCUIT. THE…

Owner-reported narrative. 50,000 miles reported. Look up ODI 10010823 at NHTSA ↗

THE HORN WAS INOPERATIVE. EVERY TIME THE HORN WAS USED, IT BLEW A FUSE. *JB

Owner-reported narrative. Look up ODI 10014682 at NHTSA ↗

THE VEHICLE STALLED. THE DEALER DIAGNOSED THE PROBLEM AS BAD BARE WIRES INSIDE OF FUEL PUMP. THE WIRES SHORTED WHICH CAUSED VEHICLE TO STALL. *JB

Owner-reported narrative. Look up ODI 10014684 at NHTSA ↗

NOTICED ON SEVERAL OCCASIONS THAT VEHICLE SEEMED TO BE LEAKING FUEL WHEN PARKED AND TURNED OFF. MOST RECENT CASE OCCURRED SHORTLY AFTER REFUELING. DEALER DIAGNOSED AS A "CRACKED FUEL SENDING UNIT". APPARENTLY THIS ALLOWS FUEL TO BE SPEWED OUT OF THE TANK WHEN PARKED. DEALER INDICATED THAT IT WASN'T COVERED BY WARRANTY DUE TO MILEAGE. CO-WORKER DISCUSSED ALMOST IDENTICAL PROBLEM WITH HIS YUKON XL (EXCEPT HIS SPEWED MORE FUEL INTO HIS GARAGE AND NEED TO BE CLEANED-UP BY HAZMAT TEAM). THIS APPEARS TO BE MORE THAN A RANDOM OCCURRENCE OF A PRO…

Owner-reported narrative. 47,000 miles reported. Look up ODI 10018990 at NHTSA ↗

EMERGENCY BRAKES DO NOT ENGAGE. I DO NOT NORMALLY USE THE EMERGENCY BRAKE, AND ONLY NOTICED THIS PROBLEM AFTER THE WARRANTY EXPIRED. *NLM

Owner-reported narrative. Look up ODI 10019118 at NHTSA ↗

Reported: 2000-10-25 (October 25, 2000)

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE LOOSE OR MISSING REAR WHEELHOUSE PLUGS. UNDER CERTAIN VEHICLE OPERATING CONDITIONS, EXHAUST GASES CAN FLOW FORWARD AND ACCUMULATE IN THE REAR WHEELHOUSE.

Consequence: THESE GASES COULD FLOW INTO THE PASSENGER COMPARTMENT IF THE PLUG IS MISSING OR LOOSE AND COULD CAUSE POSSIBLE ILLNESS, UNCONSCIOUSNESS, OR DEATH.

Remedy: DEALERS WILL INSPECT THE VEHICLE FOR LOOSE OR MISSING WHEELHOUSE PLUGS AND INSTALL NEW PLUGS IF NECESSARY.

Reported: 2000-10-30 (October 30, 2000)

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES. SOME OF THESE VEHICLES HAVE A CLEARANCE CONDITION BETWEEN THE FRONT RIGHT-HAND BRAKE PIPE AND THE BODY CROSS SILL THAT COULD DECREASE TO THE POINT OF ALLOWING CONTACT DURING THE LIFE OF THE VEHICLE. IF CONTACT OCCURS AND THE BRAKE PIPE BECOMES DAMAGED, IN HALF OF THE BRAKE SYSTEM THERE CAN BE A LOSS OF BRAKE FLUID AND PRESSURE. THE BRAKE WARNING LAMP WILL BE ACTIVATED WHEN THE BRAKE FLUID LEVEL REACHES THE INDICATOR LIMIT.

Consequence: DURING BRAKING, THE PEDAL WILL BE LOWER THAN NORMAL AND STOPPING DISTANCES WILL BE LONGER. IF THIS OCCURS WHEN STOPPING DISTANCE IS LIMITED, A CRASH COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE FRONT RIGHT-HAND BRAKE PIPE FOR WEAR. IF THERE ARE SIGNS OF WEAR, THIS SECTION OF THE BRAKE PIPE WILL BE REPLACED WITH A NEW DESIGNED BRAKE PIPE SECTION. IF THERE ARE NOT SIGNS OF WEAR ON THE BRAKE PIPE, THE DEALER WILL INSTALL A SPACER CLIP TO ENSURE SUFFICIENT CLEARANCE BETWEEN THE BRAKE PIPE AND THE BODY CROSS SILL.

Reported: 2002-07-01 (July 1, 2002)

ON CERTAIN PICKUP AND UTILITY TRUCKS, SOME OF THESE VEHICLES HAVE AN AIR BAG SENSING DIAGNOSTIC MODULE (SDM) WHICH CONTAINS AN ANOMALY THAT COULD RESULT IN THE DRIVER AND PASSENGER'S AIR BAG FAILING TO DEPLOY DURING CERTAIN FRONTAL CRASHES.

Consequence: IN A VEHICLE CRASH, FRONT SEAT OCCUPANTS MAY RECEIVE MORE SEVERE INJURIES.

Remedy: DEALERS WILL RECALIBRATE THE SDM ON THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN AUGUST 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.

Reported: 2005-01-07 (January 7, 2005)

SOME PICKUP TRUCKS, VANS, AND SPORT UTILITY VEHICLES EQUIPPED WITH A HYDRAULIC PUMP DRIVESHAFT THAT CAN FRACTURE, RESULTING IN IMMEDIATE LOSS OF HYDRAULIC POWER STEERING ASSIST. ON CERTAIN VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, THE SAME CONDITION CAN RESULT IN LOSS OF POWER ASSIST FOR BRAKING AFTER THE RESERVE PRESSURE IS DEPLETED.

Consequence: AN INOPERATIVE PUMP CAN CAUSE INCREASED STEERING EFFORT, AND IN HYDRO-BOOST EQUIPPED VEHICLES ALSO INCREASED BRAKING EFFORT, BUT DOES NOT COMPLETELY ELIMINATE THE ABILITY TO STEER OR SLOW THE VEHICLE.

Remedy: DEALERS WILL REPLACE THE HYDRAULIC PUMP. THE CAMPAIGN BEGAN ON FEBRUARY 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Reported: 2005-04-14 (April 14, 2005)

CERTAIN TRUCKS AND SPORT UTILITY VEHICLES WERE BUILT WITH FUEL MODULE RESERVOIR ASSEMBLIES THAT CONTAIN FUEL PUMP WIRES CONNECTORS MAY OVERHEAT UNDER CERTAIN OPERATING CONDITIONS.

Consequence: IF THE IGNITION CIRCUIT WIRE IS EXPOSED, THE FUEL PUMP FUSE WILL BLOW, DISABLING THE FUEL PUMP AND CAUSING AN ENGINE STALL OR NO-START CONDITION. IF SUFFICIENT HEAT IS CONDUCTED TO THE PASS-THROUGH CONNECTOR, A HOLE IN THE CONNECTOR MAY RESULT, WHICH MAY CAUSE A 'SERVICE ENGINE SOON' LIGHT TO BE ILLUMINATED DURING THE EMISSION SYSTEM DIAGNOSTIC ROUTINE. FUEL VAPOR AND IN SOME CASES LIQUID FUEL MAY LEAK OUT OF THE FUEL TANK THROUGH THE HOLE IN THE CONNECTOR BODY. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. ALSO IF THE IGNITION CIRCUIT OR GROUND WIRE IS EXPOSED AND SHORTS TO THE FUEL LEVEL SENDER CARD WIRES, INACCURATE FUEL LEVEL READINGS MAY RESULT.

Remedy: DEALERS WILL REMOVE THE FUEL TANK, AND REMOVE THE MODULE RESERVOIR ASSEMBLIES FROM THE TANK, AND INSTALL A NEW SERVICE KIT FREE OF CHARGE. AN INTERIM LETTER TO OWNERS WAS MAILED ON MAY 25, 2005. THE OWNERS WERE RE-NOTIFIED ON OCTOBER 19, 2005, SINCE PARTS ARE NOW AVAILABE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463.

Reported: 2005-08-29 (August 29, 2005)

CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.

Consequence: THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS ARE TO REMOVE THE WHEEL SPEED SENSOR AND THOROUGHLY CLEAN THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING, APPLY RUST INHIBITOR TO THE CLEANED SURFACE, GREASE THE MOUNTING SURFACE, REINSTALL THE WHEEL SPEED SENSOR, AND CHECK THE PEAK-TO-PEAK OUTPUT VOLTAGE TO ENSURE THE WHEEL SPEED SIGNAL IS WITHIN SPECIFICATIONS. THE RECALL BEGAN SEPTEMBER 22, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.