2004 Gmc SAVANA: complaints, problems and recalls

CONSUMER NOTICED VEHICLE WAS LEAKING OIL, DROPPED ABOUT TWO QUARTS OF OIL. VEHICLE HAD ONLY 1200 MILES. DEALER SATED THERE WAS NOTHING WRONG WITH THE VEHICLE. *AK

Owner-reported narrative. 900 miles reported. Look up ODI 10053715 at NHTSA ↗

CONSUMER NOTICED THAT WHILE DRIVING VEHICLE SHOOK UNCONTROLLABLY. CONSUMER DROVE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT STEERING SHAFT PITMAN AND IDLER ARM NEEDED TO BE REPLACED. CONSUMER INFORMED THE MECHANIC THAT THIS PROBLEM OCCURRED PREVIOUSLY, AND THE PROBLEM HAD NOT BEEN RESOLVED. *AK

Owner-reported narrative. Look up ODI 10101111 at NHTSA ↗

WHILE DRIVING REAR END FAILED, VEHICLE SKIDDED, AND IT CAUGHT ON FIRE. ALSO, TRANSMISSION WAS INOPERABLE, AND TAIL LIGHTS MALFUNCTIONED. CONTACTED GMC. *AK

Owner-reported narrative. 10,000 miles reported. Look up ODI 10105315 at NHTSA ↗

WHILE DRIVING 35 MPH CONSUMER'S VEHICLE WAS INVOLVED IN A FRONTAL COLLISION. UPON IMPACT, BOTH FRONTAL AIR BAGS FAILED TO DEPLOY. THIS CAUSED THE DRIVER TO SUSTAIN MAJOR INJURIES ,AND WAS TRANSPORTED TO A HOSPITAL BY AMBULANCE. VEHICLE WAS TOWED TO A GARAGE FOR INSPECTION. *AK

Owner-reported narrative. Look up ODI 10117552 at NHTSA ↗

DT: THE CONTACT COMPLAINED ABOUT A SEAT BELT FAILURE. THE SECOND ROW RIGHT SIDE PASSENGER'S SEAT BELT WAS INSERTED BACKWARDS INTO THE BUCKLE. THE SEAT BELT LOCKED IN THE BUCKLE AND WOULD NOT RELEASE. THE SEAT BELT WAS CUT TO RELEASE THE PASSENGER. THE VEHICLE WAS SEEN BY THE DEALER, WHO ORDERED THE APPROPRIATE PARTS FOR THE REPAIR. THE PARTS HAVE NOT ARRIVED, THEREFORE, NO REPAIRS HAVE BEEN MADE . *AK THE DRIVER SEAT RECLINER WAS NOT WORKING. UPDATED 03/17/06. *JB

Owner-reported narrative. 17,000 miles reported. Look up ODI 10145264 at NHTSA ↗

FUEL LINE FROM GAS TANK TO "QUICK CONNECT" SPLIT NEAR THE MUFFLER. WITH THE PRESSURE OF THE FUEL PUMP, GASOLINE WAS SPEWING OUT OF THE LINE UNDER THE TRUCK NEAR THE MUFFLER. IT HAD HAPPENED TWO WEEKS OR SO EARLIER BUT I DIDN'T NOTICE IT BECAUSE I'D HAD A GAS SPILL FROM A LEAF BLOWER IN THE BACK OF THE VAN AND THOUGHT THAT WAS THE SMELL (EVEN THOUGH I'D WIPED IT UP). I WENT TO MY MECHANIC TO SEE IF HE COULD CLEAN THE SPILL. HE FOUND THE SPLIT THAT WAS CAUSING THE ODOR. IT WOULD SEEM TO BE A REAL FIRE HAZARD. THE FUEL LINE IS PLASTIC, MY MECHAN…

Owner-reported narrative. 28,850 miles reported. Look up ODI 10195969 at NHTSA ↗

TL*THE CONTACT OWNS A 2004 GMC SAVANA. WHILE DRIVING LESS THAN 20 MPH AND APPROACHING A STOP SIGN, THE BRAKE PEDAL EXTENDED TO THE FLOOR. THE CONTACT HAD TO USE MAXIMUM EFFORT IN ORDER FOR THE BRAKES TO CATCH. HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V043000. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 87,927.

Owner-reported narrative. 87,927 miles reported. Look up ODI 10260707 at NHTSA ↗

NO INCIDENT ...YET. NOTICED THE SMELL OF GAS AFTER REFUELING JUST BEFORE CHRISTMAS 2012. IT HAS BEEN GETTING WORSE EVER SINCE. CHECKED OUT RECALLS AND SAW THIS ONE, BUT NEVER RECEIVED A RECALL NOTICE. CALLED LOCAL DEALER AND TOLD ME THAT IT WAS NOT COVERED. SOMETHING IS WRONG HERE. THIS RECALL (LISTED BELOW) IS EXACTLY WHAT IS THE ISSUE WITH MY GMC VAN. IT SHOULD BE INCLUDED IN THIS RECALL BUT FOR SOME REASON IS NOT. I AM GOING TO FIX IT MYSELF (AT MY OWN EXPENSE), BECAUSE IT IS A SAFETY ISSUE AND I AM NOT GOING TO RISK THE SAFETY OF MY…

Owner-reported narrative. 96,000 miles reported. Look up ODI 10497641 at NHTSA ↗

Reported: 2004-02-04 (February 4, 2004)

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.

Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

Reported: 2004-04-19 (April 19, 2004)

CERTAIN VANS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THESE VEHICLES MAY HAVE BEEN PRODUCED WITH SEAT BELT BUCKLE ASSEMBLIES CONTAINING A LATCH WITH A BRITTLE CONDITION THAT MAY NOT WITHSTAND THE FORCE REQUIREMENTS OF THE STANDARD.

Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, WHICH COULD RESULT IN INJURY TO THE OCCUPANT.

Remedy: DEALERS WILL REPLACE THE SAFETY BELT BUCKLE. THE RECALL BEAGN MAY 7, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Reported: 2004-07-06 (July 6, 2004)

CERTAIN VANS WERE BUILT WITH A TRANSMISSION SHIFT CABLE ASSEMBLY THAT MAY SEPARATE. IF THE CABLE ASSEMBLY SEPARATES, THE TRANSMISSION SHIFT LEVER POSITION AND THE TRANSMISSION INDICATOR MAY NO LONGER CORRELATE.

Consequence: IF THIS WERE TO OCCUR, THE VEHICLE COULD MOVE IN A DIRECTION NOT ANTICIPATED BY THE DRIVER, WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT THE TRANSMISSION SHIFT CABLE ASSEMBLY, AND IF NECESSARY, REPLACE IT. THE RECALL BEGAN ON AUGUST 19, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Reported: 2005-02-08 (February 8, 2005)

CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.

Consequence: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS WILL REPLACE THE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 23, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC TRUCKS AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493.

Reported: 2005-12-19 (December 19, 2005)

ON CERTAIN FULL-SIZE PASSENGER, CARGO, OR CUTAWAY VANS, THE FRONT AND REAR SEAT BELT BUCKLES WILL NOT LATCH OR WILL NOT UNLATCH.

Consequence: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALER WILL REPLACE ONLY THE UPPER BUCKLE COVER. THE RECALL WILL BE CONDUCTED IN PHASES. THE FIRST PHASE MAILING BEGAN DURING MARCH 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Reported: 2012-08-08 (August 8, 2012)

General Motors (GM) is recalling certain model year 2003-2004 Chevrolet Express and GMC Savana vehicles, equipped with a left side cargo door, and originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Water and road contaminants may become trapped in the protective conduit that covers the fuel filler pipe and may cause the pipe to corrode.

Consequence: Significant corrosion may allow fuel to leak during refueling, and in the presence of an ignition source; there is an increased risk of fire.

Remedy: GM will notify owners, and dealers will install a new fuel filler neck, free of charge. The safety recall began on October 1, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546 and GMC at 1-866-996-9463.

Reported: 2023-04-06 (April 6, 2023)

General Motors, LLC (GM) is recalling certain 2003-2023 Chevrolet Express Cutaway and GMC Savana Cutaway incomplete vehicles equipped with wiring for an optional rear heating, ventilation, and air-conditioning (HVAC) system. When the HVAC blower motor circuit is left unused with exposed connectors and wiring, the circuit can corrode and overheat.

Consequence: An overheated electrical circuit increases the risk of a fire.

Remedy: Dealers will properly seal the rear HVAC blower motor circuits at the left side B-pillar, free of charge. Owner notification letters were mailed May 2, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GMC's number for this recall is N222386050.