2006 Gmc ENVOY XL: complaints, problems and recalls

DT: THE CONTACT WAS CONCERNED WITH ONE OF THE SAFETY FEATURES ON THE VEHICLE. WITHOUT WARNING THE ENGINE SHUT OFF. WHILE DRIVING THE ENGINE COOLING LIGHT ILLUMINATED AND VEHICLE SHUT DOWN. THE DEALER CORRECTED THE PROBLEM WITH THE ENGINE COOLING. *AK UPDATED 12/27/05. *JB

Owner-reported narrative. 90 miles reported. Look up ODI 10143763 at NHTSA ↗

DT*: THE CONTACT STATED WHEN THE BRAKE PEDAL IS APPLIED, AT VARIOUS SPEEDS, THE BRAKES JERK. THE DEALERSHIP REPLACED THE BRAKE CONTROL MODULE AND SENSOR, BUT THE PROBLEM HAS RETURNED. UPDATED 4/11/2006 - THE DAY THE VEHICLE WAS PURCHASED THE CONSUMER NOTICED THAT THE STABILITRACK SERVICE LIGHT AND STABILITRACK LIGHT WAS ILLUMINATED. THE VEHICLE MADE NOISE WHEN THE BRAKE WAS APPLIED OR WHEN THE VEHICLE ACCELERATED. THE CONSUMER CONTACTED THE DEALER AND TOOK THE VEHICLE IN TO BE SERVICED. THE VEHICLE WAS RETURNED TOT HE CONSUMER AND THE…

Owner-reported narrative. 1,932 miles reported. Look up ODI 10153239 at NHTSA ↗

DEAR SIR, TODAY WHILE DRIVING MY 2003 ENVOY SUV (APPROX 40,000 MILES ON THE OD ) I WAS MAKING A LEFT TURN ONTO A MAJOR HIGHWAY. ABOUT 3/4 WAY THROUGH THE TURN THE CAR ACCELERATED FULL SPEED WITHOUT MY HELP. SINCE THE ROADWAY WAS WET (NOT RAINING AT THE TIME) THE CAR SPED AND SPUN VIOLENTLY TO THE LEFT AND CRASHED INTO THE CONCRETE BARRIER SEPARATING THE FOUR LANE HIGHWAY. WE ( MY WIFE AND I) HIT THE BARRIER WITH A STRONG IMPACT BUT SUFFERED NO SERIOUS INJURY. (WE WERE BELTED) THIS AUTOMOBILE IS USED AS A TOWED VEHICLE AS WE TRAVEL T…

Owner-reported narrative. 40,100 miles reported. Look up ODI 10170582 at NHTSA ↗

THE FUEL TANK SENSOR MODULE ON MY 2006 GMC ENVOY FAILED CAUSING THE TANK LEVEL INDICATOR TO FLUCTUATE AND READ IMPROPERLY. THE VEHICLE HAD ONLY ABOUT 41,000 MILES ON IT AND WAS APPROXIMATELY TWO YEARS OLD. *TR THE FIX WAS TO REPLACE THE MODULE, AT A COST OF $700. THIS IS AN EXCESSIVE PRICE FOR A MODULE THAT SHOULD HAVE LASTED LONGER THAN TWO YEARS.

Owner-reported narrative. 41,000 miles reported. Look up ODI 10206915 at NHTSA ↗

HAD JUST FILLED THE FUEL TANK AND HAD DRIVEN ABOUT 5 MILES WHEN THE CHECK ENGINE LIGHT CAME ON AND THE FUEL GAUGE HAD GONE DOWN TO THE EMPTY MARK SETTING OFF THE LOW FUEL ALARM. PULLED OFF THE ROAD TO CHECK THE GAS CAP, AND IT WAS INSTALLED, BUT LOOSE. DISCOVERED THE O RING GASKET WAS MISSING FROM CAP. DROVE ANOTHER 10 MILES AND WENT TO AUTO PARTS STORE AND PURCHASED A REPLACEMENT CAP. ENGINE CHECK LIGHT EXTINGUISHED, BUT FUEL GAUGE SWEEPS BACK AND FORTH, SOMETIMES SETTING OFF LOW FUEL ALARM. WILL CALL DEALER ON MONDAY TO SEE IF THERE IS A SB F…

Owner-reported narrative. 33,702 miles reported. Look up ODI 10247496 at NHTSA ↗

I OWN A 2006 GMC ENVOY XL. WE HAVE 44000 MILES ON IT. WHEN WE FILL THE GAS THE GAUGE READS FULL. BY THE TIME I PULL OFF THE LOT THE GAUGE STARTS TO DROP TO EMPTY. NEVER KNOW HOW MUCH GAS IS IN THE TANK. RUNNING OUT OF GAS IN THE MIDDLE OF THE NIGHT ON THE HIGHWAY IS A LITTLE SCARY FOR MY WIFE. NOT TO MENTION A HUGE SAFETY ISSUE. *TR

Owner-reported narrative. 44,000 miles reported. Look up ODI 10248910 at NHTSA ↗

TL*THE CONTACT OWNS A 2006 GMC ENVOY XL. WHEN THE CONTACT STARTED THE IGNITION, HE HEARD A LOUD WHINING NOISE COMING FROM THE TRANSMISSION. THE FAILURE OCCURRED WITHOUT WARNING WHENEVER THE VEHICLE WAS IN OPERATION. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND CURRENT MILEAGE WAS 37,000.

Owner-reported narrative. 30,000 miles reported. Look up ODI 10257138 at NHTSA ↗

THE FUEL GAUGE SHOWS EMPTY EVEN WHEN THE TANK IS FULL. AFTER THE GAUGE HAS READ EMPTY FOR A WHILE, THE ENGINE LIGHT THEN COMES ON. THIS IS GOING TO COST ME 724.00 TO GET FIXED, B/C THE FUEL PUMP NEEDS REPLACING. *TR

Owner-reported narrative. 43,000 miles reported. Look up ODI 10258124 at NHTSA ↗

Reported: 2005-10-05 (October 5, 2005)

CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.

Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.

Reported: 2013-06-13 (June 13, 2013)

General Motors (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: Owners will be contacted and dealers will test the driver's door module. If the module is functioning properly, a protective coating will be applied. If the module is not functioning properly, it will be replaced. These repairs will be done free of charge. GM will notify Buick, Chevrolet, and GMC owners, Isuzu and Saab will contact their respective owners. The recall began on August 2, 2013. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, GMC owners at 1-866-996-9463, Isuzu owners at 1-800-255-6727, and Saab owners at 1-800-955-9007. GM's campaign number is 12180. This recall is an expansion of recall 12V-406.

Reported: 2014-07-02 (July 2, 2014)

General Motors LLC (GM) is recalling certain model year 2005-2007 SAAB 9-7x; 2006 Chevrolet Trailblazer EXT and GMC Envoy XL; and 2006-2007 Chevrolet Trailblazer, GMC Envoy, Buick Rainier and Isuzu Ascender vehicles. Fluid may enter the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board. A short may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing odor, smoke, or a fire.

Consequence: A short in the circuit board could lead to a fire, increasing the risk of personal injury. A fire could occur even while the vehicle is not in use. As a precaution, owners are advised to park outside until the remedy has been made.

Remedy: GM will notify owners, and dealers will inspect the part number on the door module, and install a new door module if necessary, free of charge. Parts for the remedy are not currently available. An interim letter was mailed to owners in August 2014. A second owner letter will be mailed when parts are available. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-222-1020 (Chevrolet), 1-800-462-8782 (GMC), 1-800-955-9007 (SAAB), and 1-800-255-6727 (Isuzu). GM's number for this recall is 14309. NOTE: This recall provides a new remedy for all vehicles covered by recall 13V-248. Vehicles whose modules were modified but not replaced as part of the previous recall remedy must have their vehicles remedied again under this campaign.

Reported: 2015-08-14 (August 14, 2015)

General Motors LLC (GM) is recalling certain model year 2007 Pontiac Grand Prix, 2006-2009 Buick LaCrosse, 2006-2007 Buick Rainier, Chevrolet Trailblazer, GMC Envoy, 2006 Chevrolet Trailblazer EXT, GMC Envoy XL, 2006-2008 Isuzu Ascender, and Saab 9-7x vehicles. In the affected vehicles, the headlamp driver module (HDM) may overheat and fail, causing the headlamps and daytime running lights to not illuminate.

Consequence: Headlamps that do not illuminate reduce the driver's ability to see the roadway and reduce the vehicle's visibility to oncoming vehicles, both of which increase the risk of a vehicle crash.

Remedy: GM will notify owners, and dealers will replace the HDM, free of charge. The recall began on May 17, 2016. Owners may contact Buick customer service at 1-800-521-7300 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14291.

Reported: 2015-09-24 (September 24, 2015)

General Motors LLC (GM) is recalling certain model year 2006-2007 Buick Rainier, Chevrolet Trailblazer and GMC Envoy vehicles, and 2006 GMC Envoy XL and Chevrolet Trailblazer EXT vehicles. Fluid may enter into the driver's door master power window switch module, causing corrosion that could result in a short in the circuit board, causing window switches to become inoperative. Previously, the affected vehicles may have had their master power window switch module treated with a protective coating, instead of having it replaced.

Consequence: The protective coating may not eliminate the risk that the circuit board could short and result in a fire, even while the vehicle is unattended.

Remedy: GM will notify owners, and dealers will install a new driver's door switch module, free of charge. The recall began on November 2, 2015. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is 15700.