2024 Gillig LOW FLOOR: complaints, problems and recalls
Explore the records behind recurring owner reports.
Key facts
0 owner complaints analyzed
9 distinct recall campaigns
Not available median reported failure mileage
Scope: 2024 model year. Data snapshot: . 0 complaints include usable failure mileage.
Most common problems
No owner complaints are recorded for this selection. A complaint can name multiple components.
Component breakdown
Number of unique complaints naming each component. Top eight shown.
No usable records for this chart.
| Category | Count |
|---|
No records.
Reported problems by failure mileage
Complaint counts in mileage bands. These are not failure rates per vehicle or mile.
| Category | Count |
|---|---|
| Under 25,000 | 0 |
| 25,000 to 49,999 | 0 |
| 50,000 to 74,999 | 0 |
| 75,000 to 99,999 | 0 |
| 100,000 to 149,999 | 0 |
| 150,000 and above | 0 |
Under 25,000: 0; 25,000 to 49,999: 0; 50,000 to 74,999: 0; 75,000 to 99,999: 0; 100,000 to 149,999: 0; 150,000 and above: 0
No usable failure mileage is recorded. 0 complaints have missing, zero or invalid mileage.
Complaints over time
Year the complaint was filed, not the vehicle model year or incident year. The snapshot year is partial.
No usable records for this chart.
| Category | Count |
|---|
No records.
Pattern summary
There is not enough complaint evidence to summarize patterns.
Calculated from recorded counts. An AI narrative has not been published for this selection.
Examples from the source records
Examples provide context, not a representative sample or a verified diagnosis.
Recall history
9 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
24V514000 · Steering:Critical Fasteners
Reported: 2024-07-05 (July 5, 2024)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses. The steering spline shaft fasteners may have been improperly tightened, allowing the steering spline shaft to loosen.
Consequence: A loose steering shaft can cause a complete loss of steering control, increasing the risk of a crash.
Remedy: Gillig will tighten the fasteners, free of charge. Owner notification letters were mailed August 13, 2024. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
NHTSA campaign record ↗24V811000 · Visibility:Windshield Wiper/Washer
Reported: 2024-10-29 (October 29, 2024)
Gillig, LLC (Gillig) is recalling certain 2024 Low Floor buses. A defective welded joint may cause the wiper arm to suddenly fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 104, "Windshield Wiping and Washing Systems."
Consequence: Inoperative wipers can reduce the driver's ability to see out of the windshield, increasing the risk of a crash.
Remedy: Gillig will replace the wiper motor arm, free of charge. Owner notification letters were mailed December 12, 2024. Owners may contact Gillig customer service at 1-800-735-1500.
NHTSA campaign record ↗24V958000 · Equipment:Emergency:Fire Supression:Wiring | Electrical System:Wiring:Relays/Solenoids
Reported: 2024-12-20 (December 20, 2024)
Gillig, LLC (Gillig) is recalling certain 2021-2024 Low Floor style transit buses. The fire suppression relay cable may be damaged, chafing against the mounting bolt, and fail.
Consequence: Failure of the fire suppression system can increase the risk of injury during a fire.
Remedy: Dealers will replace the relay cable, free of charge. Owner notification letters were mailed December 31, 2024. Owners may contact GILLIG customer service at 1-800-735-1500.
NHTSA campaign record ↗24V959000 · Electrical System:Ignition:Interlock/Lockout
Reported: 2024-12-20 (December 20, 2024)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor style transit buses. The high voltage electric air compressor may not be connected to the High Voltage Interlock Loop (HVIL). Therefore, the HVIL cannot detect a loose or disconnected compressor power cable.
Consequence: Failure to alert the operator to a power cable issue can increase the risk of injury by electrical shock.
Remedy: Dealers will install an additional electrical harness, extending the HVIL loop to the air compressor, free of charge. Owner notification letters were mailed February 12, 2025. Owners may contact GILLIG customer service at 1-800-735-1500.
NHTSA campaign record ↗25V076000 · Equipment:Appliance:Tv/Radio/Speakers
Reported: 2025-02-11 (February 11, 2025)
Gillig, LLC (Gillig) is recalling certain 2019-2024 Low Floor transit buses. The rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to detach and fall.
Consequence: A monitor that detaches and falls from the ceiling increases the risk of injury.
Remedy: Gillig will replace the rivet-nut fasteners, free of charge. Owner notification letters were mailed March 18, 2025. Owners may contact Gillig customer service at 1-800-735-1500.
NHTSA campaign record ↗25V203000 · Electrical System:Propulsion System:Traction Battery
Reported: 2025-04-01 (April 1, 2025)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses. The high voltage batteries may have loose hardware that can fall inside the battery pack and create a short circuit.
Consequence: A short circuit increases the risk of a fire. In addition, the battery contactors may open suddenly and cause a loss of drive power, increasing the risk of a crash.
Remedy: Gillig will install new battery fasteners as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Gillig customer service at 1-800-735-1500.
NHTSA campaign record ↗26V142000 · Fuel System, Diesel:Delivery:Hoses, Lines/Piping, And Fittings
Reported: 2026-03-12 (March 12, 2026)
Gillig, LLC (Gillig) is recalling certain 2021-2026 Low Floor transit buses. The air compressor intake pipe may contact and damage the fuel line.
Consequence: A damaged fuel line may leak, increasing the risk of a fire.
Remedy: Gillig will inspect, replace, and reorient the intake pipe as necessary, free of charge. Owner notification letters were mailed April 24, 2026. Owners may contact Gillig's customer service at 1-800-735-1500.
NHTSA campaign record ↗26V144000 · Electrical System:Propulsion System: Cables
Reported: 2026-03-12 (March 12, 2026)
Gillig, LLC (Gillig) is recalling certain 2023-2026 Low Floor transit buses. The high voltage cable, connecting the inverter to the drive unit, contains a splice connection that reduces the amp capacity rating.
Consequence: Reduced capacity may cause the cable to overheat, increasing the risk of a fire.
Remedy: Gillig will reprogram the software as an interim repair. For the final remedy, Gillig will replace the high voltage cable. Both repairs will be provided free of charge. Owner notification letters are expected to be mailed July 27, 2026. Owners may contact Gillig's customer service at 1-800-735-1500.
NHTSA campaign record ↗26V190000 · Equipment:Other:Labels
Reported: 2026-03-26 (March 26, 2026)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses equipped with Michelin X InCity Grip D rear tires. The rear Gross Axle Weight Rating (GAWR) on the federal placard may exceed the tire load rating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims - Other Than Passenger Cars."
Consequence: Referencing an incorrect GAWR can lead to unintentionally overloading the rear tires, increasing the risk of a crash.
Remedy: Gillig will replace the federal placard, free of charge. Owner notification letters are expected to be mailed April 24, 2026. Owners may contact Gillig customer service at 1-800-735-1500.
NHTSA campaign record ↗