1998 Ford RANGER: complaints, problems and recalls

I WAS INVOLVED IN A 20-25MPH REAR END COLISION. I HAD RAN INTO THE BACK OF AN OLD GMC PICKUP CAUSING $4000.00 WORTH OF DAMAGE TO THE FRONT END OF MY TRUCK. BOTH THE DRIVER AND THE PASSENGER AIRBAG NEVER DEPLOYED. WHILE THE TRUCK WAS IN THE SHOP FOR REPAIRS THE SHOP HAD FOUND OUT THE AIRBAG SENSOR WAS BAD. THEY TRIED TO REPLACE THE SENSOR BUT WAS INFORMED BY FORD THAT THE SENSOR ON THAT MAKE AND MODEL HAS BEEN CHANGED AND THE LOCATION OF THE SENSOR(S) ARE IN NOW LOCATED IN A DIFFERENT SPOT OTHER THEN ON THE RADIATOR MOUNTS. BECAUSE OF THIS CHANG…

Owner-reported narrative. 86,000 miles reported. Look up ODI 10000483 at NHTSA ↗

THE POWER THE CORD THAT THAT GOES TO THE CIGARETTE LIGHTER CAUGHT FIRE AND MELTED SOME OF THE WIRES LOCATED BEHIND SPEEDOMETER. CAUSE IS UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION. TS

Owner-reported narrative. Look up ODI 10001383 at NHTSA ↗

THE ENGINE FAILED. *DT *JB

Owner-reported narrative. Look up ODI 10006797 at NHTSA ↗

THE VEHICLE WAS INVOLVED IN A FRONTAL COLLISION, AND NONE OF THE AIR BAGS DEPLOYED. THE CONSUMER SUFFERED MINOR INJURIES. *JB

Owner-reported narrative. 166 miles reported. Look up ODI 10014855 at NHTSA ↗

WHILE PULLING INTO THE GARAGE THE VEHICLE SUDDENLY ACCELERATED AND CRASHED THROUGH THE BACK OF THE GARAGE AND RESULTED IN OVER $12,000 WORTH OF DAMAGE. *NLM

Owner-reported narrative. Look up ODI 10019914 at NHTSA ↗

THE CONSUMERS VEHICLE SUDDENLY ACCELERATED AND RESULTED IN A FRONTAL COLLISION THROUGH THE GARAGE. NEITHER THE DRIVER OR PASSENGER AIR BAGS DEPLOYED. *NLM

Owner-reported narrative. 17,000 miles reported. Look up ODI 10019915 at NHTSA ↗

BRAKE ROTORS ARE WEARING OUT PREMATURELY AND NEED TO BE REPLACED. *AK

Owner-reported narrative. 30,000 miles reported. Look up ODI 10022555 at NHTSA ↗

WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING. THE GEAR SHIFT FELL OUT OF THE CASE. *AK

Owner-reported narrative. Look up ODI 10026810 at NHTSA ↗

Reported: 2007-08-03 (August 3, 2007)

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 1997-10-28 (October 28, 1997)

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.

Consequence: THIS COULD POTENTIALLY RESULT IN DAMAGE TO THE FUEL LINE, OR IN SOME CASES, CAUSE A FUEL LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.

Reported: 1998-02-02 (February 2, 1998)

VEHICLE DESCRIPTION: LIGHT DUTY FOUR-WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH OFF-ROAD OPTION. THE TIRE AND RIM IDENTIFICATION INFORMATION IS INCORRECT ON THESE VEHICLES. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence: THE 16" TIRES COULD NOT BE INFLATED ON THE SPECIFIED 15X7.0J RIM.

Remedy: OWNERS WILL BE SENT A SAFETY CERTIFICAITON LABEL PARTIAL OVERLAY WHICH WILL CONTAIN THE CORRECT RIM SIZE, AND INSTRUCTIONS FOR AFFIXING THIS LABEL TO THE VEHICLE. IF AN OWNER SO DESIRES, THEIR FORD DEALER CAN INSTALL THE LABEL FOR THEM.

Reported: 1999-03-30 (March 30, 1999)

VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.

Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.

Reported: 1999-07-28 (July 28, 1999)

VEHICLE DESCRIPTION: ELECTRIC VEHICLES. THE TRANSAXLE MAY HAVE BEEN MANUFACTURED WITH THE PARK DETENT SPRING MISALIGNED. IF THE SPRING IS MISALIGNED, THE PARK MECHANISM MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION.

Consequence: IF THE PARK MECHANISM DOES NOT ENGAGE AND THE VEHICLE OPERATOR HAS NOT APPLIED THE PARKING BRAKE, THE VEHICLE COULD ROLL FREE AS IF IN NEUTRAL.

Remedy: DEALERS WILL INSPECT THE TRANSAXLE AND ANY WITH MISALIGNED PARK DETENT SPRINGS WILL BE REPLACED.