2000 Fleetwood TIOGA: complaints, problems and recalls

WHILE DRIVING AND WITHOUT WARNING THE TIRES EXPERIENCED TREAD SEPARATION WHICH MADE IT DIFFICULT FOR THE DRIVER TO CONTROL THE VEHICLE (SIZE#LT22575R16 PLEASE PROVIDE THE DOT#). *NLM

Owner-reported narrative. Look up ODI 10020058 at NHTSA ↗

THE INSIDE DUAL CLASS D TIRE OF A 23 FOOT MOTORHOME (APPROXIMATELY 10,000 POUNDS) WENT FLAT DUE TO CRACKING FAILURE OF THE VALVE STEM. INSTEAD OF REMAINING INTACT, SINCE IT WAS SUPPORTED BY THE OTHER DUAL TIRE, THE FLAT TIRE DEVELOPED A 12 INCH SIDEWALL SPLIT WHERE IT MEETS THE TREAD. ABOVE THE MID-RANGE OF THE SPLIT THE TREAD SEPARATED FROM THE TIRE EXPOSING A 3X6 INCH SECTION OF STEEL BELTS. I OBSERVED ON THE INSIDE OF THIS TUBELESS TIRE FLEX FRACTURES, THAT HAD SEVERED THE CORD OF THE SIDEWALL BUT NOT THE OUTER RUBBER, EXTENDING SEVERAL INC…

Owner-reported narrative. Look up ODI 10207274 at NHTSA ↗

WITH THE COACH EMPTY EXCEPT FOR FULL FUEL, FULL LP AND DRIVER, THE FRONT AXLE WEIGHT IS 4440 LBS. THIS LEAVES ONLY 160 LBS OF WEIGHT BEFORE EXCEEDING THE GAWR ON THE FRONT AXLE. THEREFORE, A MEDIUM WEIGHT PERSON SITTING ON THE PASSENGER SIDE COULD EXCEED THIS WEIGHT BEFORE ANY OTHER SUPPLIES ARE LOADED ON THE COACH. THIS IS A MAJOR SAFETY PROBLEM THAT I AM NOT WILLING TO LIVE WITH AND SHOULD NOT HAVE BEEN SOLD WITH THESE MINIMAL CARGO CARRYING WEIGHTS. *AK

Owner-reported narrative. Look up ODI 719736 at NHTSA ↗

TIRE BLEW OUT AND THE TREAD SEPARATED AT 65 MPH; WE WERE VERY LUCKY THAT THE TIRE WAS AN INSIDE DUAL TIRE ON THE REAR. OTHERWISE A CRASH WAS HIGHLY PROBABLE.*AK (TIRESIZE: LT225/75R1)

Owner-reported narrative. Look up ODI 756841 at NHTSA ↗

NEW TIRE DUE TO WARRANTY EXCHANGE, LESS THAN 2000 MILES ON REAR TIRES OF MOTORHOME. TRAVELING ON FWY APPROXIMATELY 65 MPH AND PASSANGER REAR INSIDE TIRE BLEW-OUT. COMPLETE TREAD SEPARATION AND SIDEWALL BLOWOUT. AIR PRESSURE CHECKED PRIOR TO LEAVING ON TRIP LESS THAN 150 MILES PRIO TO BLOW-OUT. THIS TIRE AND 3 OTHERS, SAME SIZE AND BRAND, HAD JUST BEEN REPLACED DUE TO WEATHER CRACKING OF PRIOR TIRES. PRIOR TIRES HAD LESS THAN 15,000 MILES ON THEM BEFORE REPLACEMENT. LUCKILY NO CRASH, DUE TO THE BLOWOUT HAPPENING ON CROWDED SUNDAY AFTERNOON…

Owner-reported narrative. Look up ODI 766933 at NHTSA ↗

WHILE DRIVING, RIGHT REAR INNER DUELLER FIRESTONE STEELTEX R4S TIRE P225/75R16 EXPERIENCED TREAD SEPARATION, DOT # 8X1L1X11200. *SLC

Owner-reported narrative. Look up ODI 876908 at NHTSA ↗

WE HAD A BLOWOUT OF TIRE - TIRE WAS CORRECTLY INFLATED. COST OF CHANGING TIRE WAS $55.00 THE TIRE HAD 6000 MILES AND FIRESTONE STORE CHARGED ME HALF PRICE OF A NEW TIRES - $68.00 WOULD NOT DO FULL REPLACEMENT OF TIRE WHICH I THINK THEY SHOULD HAVE. FIRSTONE STEELTEX-RADIAL R4S LT225/75R16M5

Owner-reported narrative. Look up ODI 9004439 at NHTSA ↗

Reported: 2000-04-10 (April 10, 2000)

VEHICLE DESCRIPTION: CLASS C MOTOR HOMES EQUIPPED WITH A SPARE WHEEL . THIS WHEEL HAS INSUFFICIENT WEIGHT CARRYING CAPACITY WHEN MATCHED TO A MAXIMUM LOADED TIRE. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

Consequence: PREMATURE WHEEL FAILURE CAN RESULT IN A LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL REPLACE THE SPARE WHEEL WITH A NEW HIGHER CAPACITY WHEEL.

Reported: 2003-11-04 (November 4, 2003)

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.

Reported: 2007-03-19 (March 19, 2007)

CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Reported: 1999-06-04 (June 4, 1999)

VEHICLE DESCRIPTION: MOTOR HOMES. A GENERATOR BATTERY CABLE MAY HAVE BEEN ROUTED TOO CLOSE TO A NOTCH IN THE HEAT SHIELD, RESULTING IN DAMAGE TO THE BATTERY CABLE INSULATION.

Consequence: THIS CAN LEAD TO AN ELECTRICAL SHORT, AND POSSIBLY A FIRE.

Remedy: DEALERS WILL INSPECT AND REPAIR, INCLUDING REPLACEMENT OF ANY DAMAGED WIRING OR OTHER VEHICULAR COMPONENTS, IF NECESSARY.