2022 E-One TYPHOON N: complaints, problems and recalls

Reported: 2022-05-24 (May 24, 2022)

E-One Incorporated is recalling certain 2022 Commercial, Cyclone 2, Cyclone N, and Typhoon N fire trucks. An additional resistor was incorrectly installed on the printed circuit board, which can disrupt CAN network communication and cause vehicle lighting to fail.

Consequence: Inoperable vehicle lighting can reduce visibility and increase the risk of a crash.

Remedy: E-One Incorporated will replace the modules, free of charge. Owner notification letters were mailed on July 22, 2022. Owners may contact E-One Incorporated's customer service at 1-352-237-1122.

Reported: 2022-07-26 (July 26, 2022)

E-One Incorporated (E-One) is recalling certain 2019-2021 Cyclone 2, 2020 Commercial, Quest 2, 2020-2021 Typhoon, 2021 Cyclone N, and 2020-2022 Typhoon N fire trucks. The neutral screw connection within the QO Plug-On Neutral Load Center may be loose. If that connection is loose, the affected load center can overheat.

Consequence: An overheated load center can increase the risk of a fire.

Remedy: Dealers will inspect and repair, or replace the load center, free of charge. Owner notification letters were mailed October 24, 2022. Owners may contact E-One's customer service at 1-352-237-1122.

Reported: 2022-08-01 (August 1, 2022)

E-One Incorporated (E-One) is recalling certain 2021-2022 Cyclone N and Typhoon N vehicles. The steering gears may have been assembled incorrectly, which can cause the gears to fracture.

Consequence: A fractured steering gear can cause a loss of steering control, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the steering gears, as necessary, free of charge. Owner notification letters were mailed October 24, 2022. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2022-10-20 (October 20, 2022)

E-One Incorporated (E-One) is recalling certain 2022 Cyclone 2, Cyclone N, and Typhoon N vehicles. The tie rod clamps may have been improperly heat-treated, causing them to crack and allowing the tie rods to separate.

Consequence: Tie rod separation can result in a sudden loss of steering, increasing the risk of a crash.

Remedy: Dealers will replace the tie rod clamps, free of charge. Owner notification letters are expected to be mailed November 30, 2022. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2023-05-09 (May 9, 2023)

E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone N and Typhoon N vehicles. The electronic sensor for the aerial device may fail and not display accurate data on the angle of inclination.

Consequence: Without accurate display data, the aerial device may inadvertently contact the cab and increase the risk of injury to the operator.

Remedy: Dealers will update the electronic sensor software, or install a new electronic sensor, as necessary, free of charge. Owner notification letters were mailed July 11, 2023. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2023-06-30 (June 30, 2023)

E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone 2, Cyclone N, and Typhoon N vehicles. The transmission cooler may be insufficiently welded, which can result in engine coolant contaminating the transmission fluid.

Consequence: Contaminated transmission fluid may cause transmission failure and a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will replace the transmission cooler and fluids, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact E-ONE customer service at 1-352-237-1122.

Reported: 2024-01-08 (January 8, 2024)

E-One Incorporated (E-One) is recalling certain 2021-2023 ARFF, Cyclone N, 2020-2024 Commercial, 2020, 2022-2023 Cyclone 2, 2023 Cyclone E, 2022 Typhoon, and 2020-2023 Typhoon N vehicles. In the event of a short circuit or wiring failure, the firmware in the vehicle multiplex system may fail to shut off the output pin, resulting in overloaded electrical circuits.

Consequence: Overloaded electrical circuits can overheat, increasing the risk of fire.

Remedy: The equipment manufacturer, Weldon, will update the firmware, free of charge. Owner notification letters were mailed January 24, 2024. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2024-01-12 (January 12, 2024)

E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone 2, Cyclone N, Typhoon N, and 2023 Cyclone E vehicles. The steering assist bracket may have been machined incorrectly.

Consequence: The incorrectly machined bracket may cause a reduction in hydraulic force, requiring greater steering effort and increasing the risk of a crash.

Remedy: Dealers will inspect and replace the steering assist bracket, free of charge. Owner notification letters were mailed February 7, 2024. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2024-08-30 (August 30, 2024)

E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone 2, 2022-2024 Cyclone N, and Typhoon N vehicles. The engine crossmember may break, allowing the cooling fan to contact the fan shroud and become damaged.

Consequence: A damaged cooling fan can result in an engine stall while driving and increase the risk of a crash.

Remedy: Dealers will inspect and repair the crossmember as necessary, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact E-One customer service at 1-352-237-1122.

Reported: 2024-10-11 (October 11, 2024)

E-One Incorporated (E-One) is recalling certain 2020-2024 Cyclone 2, Typhoon N, 2021- 2024 Cyclone N, and 2021 Quest 2 vehicles. The engine crossmember may break, allowing the cooling fan to contact the fan shroud and become damaged.

Consequence: A damaged cooling fan can result in an engine stall while driving and increase the risk of a crash.

Remedy: Dealers will inspect and repair the crossmember as necessary, free of charge. Owner notification letters were mailed November 26, 2024. Owners may contact E-One Customer Service at 1-352-237-1122.