2016 Crossroads SUNSET TRAIL: complaints, problems and recalls

I RECENTLY PURCHASED A NEW 2016 CROSSROADS 240BI RECREATIONAL VEHICLE (RV) FROM A DEALER IN VERMONT.THE SEWAGE TANK WAS HOOKED UP WRONG ALLOWING RAW SEWAGE TO SPILL OUT OF THE SEWAGE TANK AND INTO THE RV SHOWER AND ULTIMATELY ONTO THE GROUND OF A CAMPGROUND, STATE PARK OR HIGHWAY (DEPENDING ON THE LOCATION I WAS CAMPING.THE DEALER IS AWARE OF THE PROBLEM AND SCHEDULED THE REPAIR FOR ABOUT A MONTH AWAY, BUT INDICATED THAT IT WAS OK TO CONTINUE USING AND WAS NOT CONCERNED ABOUT THE RAW SEWAGE SPILLING. THE MANUFACTURER OF THE RV (CROSSROADS RV) …

Owner-reported narrative. Look up ODI 10758968 at NHTSA ↗

Reported: 2015-03-30 (March 30, 2015)

DS Corp, doing business as Crossroads RV (Crossroads), is recalling certain model year 2016 Crossroads Sunset Trail, Cruiser Aire, Cruiser, Cameo, and ReZerve recreational trailers manufactured March 4, 2015, to March 20, 2015. In the affected vehicles, the screws that attach the expanding room to the sliding mechanism cable may fail allowing the room to extend unintentionally while the vehicle is in motion.

Consequence: If the room extends while vehicle is in motion, there is an increased risk of a crash.

Remedy: Crossroads will notify owners, and dealers will replace the slide room mechanism attaching screws, free of charge. The recall began on April 6, 2015. Owners may contact Crossroads customer service at 1-855-226-7496. Crossroads number for this recall is 36.

Reported: 2015-04-13 (April 13, 2015)

DS Corp DBA Crossroads RV (Crossroads) is recalling certain model year 2016 Cruiser, Cruiser Aire, ReZerve, Elevation, Hampton, Longhorn, Longhorn Rezerve, Z1, Zinger, and Sunset Trail recreational trailers. In the affected trailers, the studs that are used to attach the wheels to the axle hubs may break.

Consequence: If the wheel studs break, the wheel could detach from the vehicle, increasing the risk of a crash.

Remedy: Crossroads has notified owners, and dealers will replace the defective hubs, free of charge. The recall began on April 14, 2015. Owners may contact Crossroads customer service at 1-855-226-7496. Crossroads number for this recall is 37.

Reported: 2015-09-22 (September 22, 2015)

DS Corp DBA Crossroads RV (Crossroads) is recalling certain model year 2015-2016 Sunset Trail trailers manufactured November 14, 2014, to September 1, 2015. The affected trailers are equipped with kitchen ranges that were installed without a panel to isolate the range from air movement.

Consequence: Without the required isolation panel, a back draft may occur from the top burner increasing the risk of a potential explosion, fire or carbon monoxide build up.

Remedy: Crossroads has notified owners, and dealers will install the panel to prevent air movement affecting the kitchen range, free of charge. The recall began on September 25, 2015. Owners may contact Crossroads at 1-855-226-7496 or by email at service@crossroadsrv.com. Crossroads' number for this recall is 38.

Reported: 2016-06-08 (June 8, 2016)

DS Corp DBA Crossroads RV (Crossroads) is recalling certain model year 2016-2017 Hill Country and Sunset Trail recreational trailers manufactured May 13, 2015, to April 18, 2016 and equipped with an outside kitchen compartment. In the affected trailers, the inside range burners may be extinguished unintentionally when the outside kitchen compartment door is opened.

Consequence: With the burners extinguished, the propane may continue to flow, creating a build up of propane gas, which in the presence of an ignition source, can increase the risk of a fire and/or explosion.

Remedy: Crossroads has notified owners, and dealers will install a piece of trim to cover the air gap behind the inside range to the outside kitchen, free of charge. The recall began on June 9, 2016. Owners may contact Crossroads customer service at 1-855-226-7496. Crossroad's number for this recall is 16-254.

Reported: 2017-11-22 (November 22, 2017)

Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.