1991 Chrysler TOWN AND COUNTRY: complaints, problems and recalls

TREAD SEPARATION ON FIRESTONE TIRE. REPLACEMENT TIRES BOUGHT IN 1999, LOW MILEAGE VEHICLE 18000 MILES ON TIRES - TREAD IS EXCELLENT. SECOND FAILURE - PREVIOUS IN 2002. SUPREME SI P205 70R15 DOT HYMO 552 019. BAR CODE 08492. *JB

Owner-reported narrative. Look up ODI 10014014 at NHTSA ↗

LOSS OF BRAKES --CAR IS EQUIPPED WITH ANTILOCK BRAKES --THIRD SEPARATE INCIDENT. *NLM

Owner-reported narrative. 144,819 miles reported. Look up ODI 10023158 at NHTSA ↗

THE BRAKE PEDAL BECAME HARD WHEN THE DRIVER MADE A SUDDEN STOP WHICH RESULTED IN EXTENDED STOPPING DISTANCES. THE DEALERSHIP REPAIRED THE VEHICLE BUT THE PROBLEM STILL EXIST. *NLM

Owner-reported narrative. 125,000 miles reported. Look up ODI 10040660 at NHTSA ↗

WHEN THE BRAKES ARE APPLIED THERE IS A DELAY BEFORE THE VEHICLE WILL STOP. *AK

Owner-reported narrative. Look up ODI 10066930 at NHTSA ↗

NHTSA RECALL 92V030000 CONCERNING BRAKE PUMP FAILURE. CONSUMER CONTACTED THE MANUFACTURER, AND WAS TOLD THAT VEHICLE WAS RECALLED, AND TO PROCEED TO THE DEALER FOR REPAIRS. CONSUMER HAD THE REPAIRS DONE, AND EXPERIENCED BRAKE FAILURE FOUR TIMES SINCE THE PUMP WAS REPLACED. ON EACH OCCASION THE PUMP WAS REPLACED WITH A DEFECTIVE PUMP. *AK

Owner-reported narrative. 120,000 miles reported. Look up ODI 10105292 at NHTSA ↗

DT:THE CONTACT RECEIVED NHTSA RECALL, CAMPAIGN 96V099000 CONCERNING ABS BRAKES. WHILE PULLING OUT OF A PARKING SPACE THE ABS ACTIVATED. THE VEHICLE WAS STOPPED WITHOUT INCIDENT. THE VEHICLE WAS REPAIRED UNDER THIS RECALL. HOWEVER, THE BRAKES FAILED TWICE WITHIN A WEEK. THE VEHICLE WAS REPAIRED AGAIN, AND THE CONTACT WAS AFRAID TO DRIVE THE VEHICLE. *AK

Owner-reported narrative. 130,000 miles reported. Look up ODI 10143945 at NHTSA ↗

TL*THE CONTACT OWNS A 1991 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING 30 MPH, THE ABS FAILED TO OPERATE AND THE VEHICLE TOOK 20-30 ADDITIONAL FEET TO STOP. THE ABS LIGHT ILLUMINATED INTERMITTENTLY. WHILE AT THE DEALER ON FEBRUARY 15, 2008, THEY STATED THAT THERE WAS FAILURE WITH THE WIRING AND THE VEHICLE NEEDED A CYLINDER MODULE AND ELECTRICAL WORK. THE REPAIR WOULD COST APPROXIMATELY $200. THE CONTACT HAD THE VEHICLE REPAIRED, BUT THE FAILURE RECURRED. THE DEALER STATED THAT NOTHING FURTHER COULD BE DONE. THE FAILURE MILEAGE WAS 104,000 …

Owner-reported narrative. 104,000 miles reported. Look up ODI 10219198 at NHTSA ↗

TL*THE CONTACT OWNS A 1991 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING 65 MPH, A POP SOUND WAS SUDDENLY HEARD AND THE AIR BAG DEPLOYED. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE AND THEN TOWED TO THE DEALER. THE DEALER INSPECTED THE VEHICLE AND STATED THAT THE SEAT BELT SHORTED OUT. THE DEALER HAD AN ENGINEER INSPECT THE VEHICLE AND TAKE PICTURES. THE FAILURE AND CURRENT MILEAGES WERE 99,000.

Owner-reported narrative. 99,000 miles reported. Look up ODI 10242328 at NHTSA ↗

Reported: 1991-11-01 (November 1, 1991)

THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE HOSE MAY LEAK OR DETACH AT ITS CRIMPED END FITTING RESULTING IN THE DISCHARGE OF HYDRAULIC FLUID.

Consequence: FLUID DISCHARGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.

Remedy: REPLACE THE ABS HIGH PRESSURE HOSE WITH A HOSE OF DIFFERENT DESIGN AND CONSTRUCTION.

Reported: 1992-03-10 (March 10, 1992)

THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE PUMP MAY BE POROUS WHICH WILL RESULT IN BRAKE FLUID LEAKAGE.

Consequence: FLUID LEAKAGE EVENTUALLY CAUSES THE LOSS OF BOTH THEANTI-LOCK BRAKE SYSTEM AND HYDRAULIC ASSIST FOR THE BRAKE SYSTEM, RESULTING ININCREASED LIKELIHOOD OF BRAKE LOCKUP AND INCREASED STOPPING DISTANCES, WHICHCOULD RESULT IN A VEHICLE ACCIDENT.

Remedy: REPLACE THE ABS HIGH PRESSURE PUMP AND HIGH PRESSURE HOSE IF THE LAST SIX DIGITS OF THE BAR CODE LABEL ON THE PUMP ARE BETWEEN 052300 AND 059262.

Reported: 1996-06-13 (June 13, 1996)

THE ABS HYDRAULIC CONTROL UNIT CAN EXPERIENCE EXCESSIVE BRAKE ACTUATOR PISTON SEAL WEAR CAUSING PUMP-MOTOR DETERIORATION.

Consequence: IF THIS CONDITION OCCURS, THE ABS FUNCTION COULD BE LOST AND REDUCED POWER ASSIST WOULD BE EXPERIENCED DURING VEHICLE BRAKING INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL TEST THE VEHICLE'S ANTI-LOCK BRAKE SYSTEM AND REPAIR THE VEHICLES IF NECESSARY. ALSO THE WARRANTY ON ALL ABS COMPONENTS WILL BE EXTENDED TO 10 YEARS OR 100,000 MILES (EXCEPT FOR THE BRAKE ACTUATOR PISTON ASSEMBLY AND THE PUMP-MOTOR ASSEMBLY WHICH WILL HAVE A LIFETIME COVERAGE). OWNERS WILL ALSO BE REIMBURSED FOR PREVIOUS ABS COMPONENT REPAIR COSTS.

Reported: 1996-11-18 (November 18, 1996)

THE STEERING WHEEL ARMATURE STAMPING CAN CRACK AND SEPARATE FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN.

Consequence: IF THE STEERING WHEEL SEPARATES FROM THE CENTER HUB ATTACHMENT TO THE STEERING COLUMN, LOSS OF CONTROL CAN OCCUR INCREASING THE RISK OF AN ACCIDENT.

Remedy: DEALERS WILL INSPECT THE STEERING WHEEL FOR ARMATURE CRACKS IN THE CENTER HUB ATTACHMENT AREA. ANY STEERING WHEELS SHOWING CRACKS WILL BE REPLACED. ALL OTHER VEHICLES WILL HAVE A REINFORCEMENT PLATE INSTALLED TO PREVENT STEERING WHEEL SEPARATION IN THE EVENT CRACKING OCCURS.

Reported: 1997-09-09 (September 9, 1997)

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. COVERS ON THE SOLID STALK MOUNTED SEAT BELT BUCKLES CAN BECOME DISLODGED CAUSING THE RELEASE BUTTON TO STICK INSIDE THE COVER. THE BUCKLE WOULD THEN BE ONLY PARTIALLY LATCHED.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL INSTALL A COVER RETAINING CLIP TO THE STALK MOUNTED BUCKLE COVER TO PREVENT DISLOCATION OF THE BUCKLE COVER.

Reported: 1997-09-09 (September 9, 1997)

VEHICLE DESCRIPTION: PASSENGER MINI-VANS. THE CENTER REAR SEAT, RIGHT OUTBOARD SIDE, SAFETY BELT ANCHOR HOOK CAN BECOME UNATTACHED FROM THE BODY ANCHOR POSITION.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE THE ANCHOR HOOK RETAINING CLIP WITH A REVISED PROFILE CLIP AND A COVER PLATE.

Reported: 1999-07-16 (July 16, 1999)

VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.

Consequence: THIS COULD ALLOW THE DRIVE ARM TO DISENGAGE FROM THE SHAFT LEADING TO A LOSS OF WIPER FUNCTION. THE DRIVER'S VISIBILITY WOULD BE IMPAIRED, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE LEFT HAND SIDE WINDSHIELD WIPER PIVOT ASSEMBLY.

Reported: 1999-09-02 (September 2, 1999)

VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.

Consequence: PERSONAL INJURY COULD OCCUR IF THE BOLTS BREAK ALLOWING THE LIFTGATE TO FALL SUDDENLY.

Remedy: DEALERS WILL INSPECT FOR LOOSE FASTENERS, IF THE FASTENERS ARE LOOSE, THE STRUT (AND INTEGRAL BOLTS) WILL BE REPLACED. IF THE BOLT SHOWS EVIDENCE OF TORQUE, THE BOLT WILL BE REMOVED, LARGER WASHERS WILL REPLACE THE EXISTING WASHER AND THE BOLT WILL BE REINSTALLED AND HAND TIGHTENED TO THE TARGET TORQUED.