2020 Chrysler PACIFICA: complaints, problems and recalls

I JUST PURCHASED A NEW 2020 PACIFICA AND DISCOVERED IT HAS FIXED SECOND ROW SEAT HEADRESTS. THE USER'S MANUAL THAT CAME WITH MY VAN SHOWS ILLUSTRATIONS OF THE HEADRESTS WITH ARROWS POINTING TO THE HEADREST'S ADJUSTMENT BUTTONS ARE BUT THOSE BUTTONS DO NOT EXIST IN MY VAN. THERE ARE ALSO WRITTEN INSTRUCTIONS ON HOW TO ADJUST OR REMOVE THE HEADRESTS BUT I CANNOT DO THAT BECAUSE OF THE MISSING BUTTONS. THE DEALERSHIP VERIFIED THAT THE HEADRESTS ARE FIXED. THE FIXED HEADRESTS MEAN THAT MY FORWARD-FACING CARSEATS (THAT USE THE SEATBELT TO SECURE T…

Owner-reported narrative. 1,000 miles reported. Look up ODI 11297524 at NHTSA ↗

TL* THE CONTACT OWNS A 2020 CHRYSLER PACIFICA. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED AN CONTROL ACCELERATION FOR 20 SECOND, THE CHECK ENGINE WARNING LIGHT ILLUMINATED, THE BRAKE PEDAL WAS LOSING THE ABILITY TO HOLD THE VEHICLE, THE ENGINE RAV UP TO 7000 RPM AND THERE WAS A TICKING NOISE COMING FROM THE ENGINE AFTER THE VEHICLE COOL DOWN. THE VEHICLE WAS RESTARTED AND WAS DRIVING TO CHAMPAIGN CHRYSLER DODGE JEEP RAM DEALER, (1906 MORELAND BLVD, CHAMPAIGN, IL 61822) BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE…

Owner-reported narrative. 200 miles reported. Look up ODI 11310289 at NHTSA ↗

TL* THE CONTACT RENTED A 2020 CHRYSLER PACIFICA. THE CONTACT STATED THAT WHILE DRIVING 70 MPH CRASHED INTO TWO DEERS. THERE WERE NO REPORTED INJURIES. THE DRIVER'S AND PASSENGER SIDE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE DALLAS FT WORTH AIRPORT. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 3,100. THE VIN WAS NOT AVAILABLE.

Owner-reported narrative. 1,300 miles reported. Look up ODI 11324436 at NHTSA ↗

WHILE APPROACHING A STOP SIGN AND ALMOST COMPLETELY STOPPED THE ENGINE REVVED AND CAUSED THE VEHICLE TO ENTER THE INTERSECTION BEFORE I COULD STOP IT. THE ENGINE RETURNED TO IDLE A FEW SECONDS LATER. FORTUNATELY THERE WAS NO OTHER TRAFFIC AT THIS TIME. THE SECOND TIME THIS PROBLEM OCCURRED I WAS STOPPING AT A RED LIGHT AND ALMOST COMPLETELY STOPPED WHEN THE ENGINE REVVED. I HAD TO APPLY CONSIDERABLE BRAKE PRESSURE TO AVOID REAR ENDING THE VEHICLE IN FRONT OF ME. I OBSERVED THE TACHOMETER READ ABOUT 2500 RPM AND IT RETURNED TO IDLE AFTER ABOUT F…

Owner-reported narrative. 2,800 miles reported. Look up ODI 11351382 at NHTSA ↗

STOPPED AT A LIGHT, VEHICLE STARTED ACCELERATING UNTIL 3000 RPM FOR 2 SECONDS WHILE ONLY BRAKE WAS PRESSED.

Owner-reported narrative. 500 miles reported. Look up ODI 11352015 at NHTSA ↗

MY WIFE WAS STATIONARY AT A RED LIGHT WITH MY DAUGHTER IN THE SECOND ROW. A CAR APPROACHED THE LIGHT AND SLAMMED INTO THE BACK OF HER CAR II DON'T THINK THEY WERE SLOWING DOWN). SHE THEN HIT THE VEHICLE IN FRONT OF HER. THE AIR BAGS DID NOT DEPLOY AND THE SEATBELT DID NOT FULLY ENGAGE. AS A RESULT, SHE HIT THE STEERING WHEEL CAUSING FRACTURES, A CONCUSSION AND A MINOR BRAIN BLEED.*DT*DT*DT*JB*JB *TR*TR

Owner-reported narrative. 500 miles reported. Look up ODI 11367081 at NHTSA ↗

TL* THE CONTACT OWNS A 2020 CHRYSLER PACIFICA. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE SWAYED. THE SWAY, ELECTRIC STABILIZER, AND CRASH WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO WALT MASSEY CHRYSLER DODGE JEEP RAM (602 WESTERN BYPASS, ANDALUSIA, AL 36420, [phone removed]) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT AN UNKNOWN SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS…

Owner-reported narrative. 300 miles reported. Look up ODI 11384731 at NHTSA ↗

WENT FOR 1ST EVER OIL CHANGE, TECHNICIANS NOTICED COOLANT RESERVOIR WAS EMPTY (SHOULD NEVER BE) AND THERE WAS LEAKED COOLANT ALL OVER THE ENGINE AND BOTTOM OF CARS PROTECTION PADS (BAD ISSUE). TOLD ME (GET IT TO THE DEALER IMMEDIATELY), WHICH I DID, TAKING IT TO PHILLIPS CHRYSLER OF OCALA. IN ORDER FOR MY ENGINE NOT TO BLOW UP. I HAVE BEEN DRIVING THIS FOR 7000 MILES SINCE I PURCHASED IT WITH ZERO MILES. THE DEALERSHIP TECHNICIANS SAID (THEY HAVE NEVER SEEN THIS CONDITION) IT CAME FROM THE CHRYSLER OEM PLANT THIS WAY, SAID THAT ALL THE BOLTS…

Owner-reported narrative. 7,200 miles reported. Look up ODI 11389733 at NHTSA ↗

Reported: 2020-09-10 (September 10, 2020)

Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio displays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

Consequence: The lingering rearview image can distract the driver, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W30-W37.

Reported: 2023-01-17 (January 17, 2023)

Chrysler (FCA US, LLC) is recalling certain 2017-2023 Pacifica Plug-In Hybrid Electric vehicles (PHEVs). An internal transmission wiring connector may short circuit, resulting in an unexpected engine shutdown.

Consequence: An unexpected engine shutdown can cause a loss of drive power, increasing the risk of a crash.

Remedy: Dealers will update the Power Inverter Module (PIM) software and, if necessary, update the instrument panel cluster (IPC) and the electronic control module (ECM) software, free of charge. FCA US will notify dealers and begin notifying owners on or about: 03/21/2023 for 2021 model year vehicles, 05/02/2023 for 2019-2020 model year vehicles, and 06/15/2023 for 2017-2018 model year vehicles. FCA began notifying owners on February 23, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 03A.

Reported: 2024-10-24 (October 24, 2024)

Chrysler (FCA US, LLC) is recalling certain 2020-2023 Pacifica and 2020-2021, 2023 Voyager vehicles. An improperly secured connector for the side curtain air bags may prevent the air bags from deploying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 226, "Ejection Mitigation."

Consequence: An air bag that does not deploy during a crash increases the risk of injury.

Remedy: Dealers will secure the connector, free of charge. All vehicles have been remedied. Owner notification letters were mailed October 22, 2024. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is A8B.

Reported: 2025-12-17 (December 17, 2025)

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

Reported: 2026-06-04 (June 4, 2026)

Chrysler (FCA US, LLC) is recalling certain 2020-2022 Pacifica Plug-In Hybrid Electric (PHEV) vehicles. The battery pack may cause a vehicle fire, even when the vehicle is parked with the ignition in the "Off" position.

Consequence: A vehicle fire increases the risk of injury.

Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until their vehicle is repaired. Dealers will update the high voltage battery pack control module software. In addition, dealers will inspect and replace the battery pack assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed beginning June 23, 2026. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 52D. The Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on June 11, 2026.