2004 Chevrolet TAHOE: complaints, problems and recalls

WHEN DRIVING IN THE RAIN OR SNOW WINDSHIELD FOGGED UP, MAKING IT VERY DIFFICULT FOR THE DRIVER TO SEE OUT OF THE WINDSHIELD. CONSUMER KEPT THE DEFROSTER ON, BUT THE PROBLEM STILL RECURRED. *AK

Owner-reported narrative. Look up ODI 10053995 at NHTSA ↗

VEHICLE (2004 CHEVROLET Z71 4X4) PULLS CONSISTENTLY TO THE RIGHT UPON FIRM BRAKE APPLICATION (SUCH AS FROM A 65 MPH COASTING CONDITION). AT THE SAME TIME, THE VEHICLE'S REAR END SWINGS OUT TO THE LEFT MAKING FOR A VERY UNSTABLE SITUATION. WHEN YOU LET OFF OF THE BRAKE PEDAL THE VEHICLE DARTS TO THE LEFT DUE, I ASSUME, TO THE LEFT-INPUT ON THE STEERING WHEEL THAT YOU'VE HAD TO SUSTAIN TO KEEP THE TRUCK IN ITS LANE. I DROVE SEVERAL LOANERS FROM THE SELLING DEALER THAT, TO MY SURPRISE, ALL DID THE EXACT SAME THING. SEVERAL DEALERSHIP SERVICE D…

Owner-reported narrative. 52 miles reported. Look up ODI 10057108 at NHTSA ↗

WHILE DRIVING 60 MPH THE VEHICLE'S RPMS REVVED UP. THE VEHICLE WOULD NOT ACCELERATE ANY HIGHER THAT 15 MPH. THE DEALER INSPECTED THE VEHICLE THEN DRAINED THEN DRAINED THE TRANSMISSION FLUID. THE DEALER INDICATED THAT THEY NEEDED TO REPLACE THE TRANSMISSION. THEY DIDN'T INDICATE WHY THEY WERE REPLACING THE TRANSMISSION OR WHAT CAUSED THE FAILURE. *AK *NM

Owner-reported narrative. 2,000 miles reported. Look up ODI 10057632 at NHTSA ↗

LOSS OF MOST STEERING AND SERVICE BRAKES SIMULTANEOUSLY. STEERING FLUID LOSS DUE TO IMPROPERLY INSTALLED STEERING FLUID HOSE CLAMP. AN ASSEMLY CLIP WAS LEFT ON THE HOSE CLAMP AT THE FACTORY WHICH PREVENTED HOSE CLAMP FROM TIGHTENING. THE SIMULTANEOUS LOSS OF MOST STEERING AND BRAKING WOULD HAVE CAUSED SERIOS ACCIDENT IF EVENT HAD OCCURED ON MOUNTAINOUS ROAD OR IF VEHICLE WAS OPERATED BY PERSON WITH LESS STRENGTH. NO WARNING LIGHT OR INDICATION ON DRIVER INFORMATION CENTER APPEARED. SHOULD NOT THESE TWO CRITICAL SYSTEMS FUNCTION INDEPENDANTLY? …

Owner-reported narrative. 5,058 miles reported. Look up ODI 10066381 at NHTSA ↗

WHILE DRIVING 60 MPH CONSUMER HEARD A LOUD NOISE. THE TAILGATE WINDOW FELL INWARD AND CRASHED ON THE FLOOR.*AK

Owner-reported narrative. Look up ODI 10072285 at NHTSA ↗

CONSUMER COMPLAINED ABOUT STEERING ASSEMBLY PROBLEM. CONSUMER TOOK VEHICLE TO THE DEALER, AND DEALER WAS NOT ABLE TO DUPLICATE THE PROBLEM. *AK

Owner-reported narrative. 3,000 miles reported. Look up ODI 10073497 at NHTSA ↗

EMERGENCY BRAKE GOES TO THE FLOOR, DOES NOT WORK LUCKILY DISCOVERED UPON SAFETY INSPECTION MY UNDERSTANDING IS THAT CHEVROLET TRUCKS AND SUV'S ARE ALL HAVING THIS PROBLEM, ISN"T THIS A SAFETY ISSUE, SINCE I CAN NOT PASS A SAFETY INSPECTION, HOW MANY PEOPLE HAVE TO DIE.*AK

Owner-reported narrative. Look up ODI 10074622 at NHTSA ↗

LOUD POPPING/PINGING NOISES COMING FROM EXHAUST SYSTEM WHEN CAR IS IN IDLE POSITION OR WHEN CAR HAS BEEN TURNED OFF. DEALERSHIP REPLACED MUFFLER BUT PROBLEM STARTED AGAIN ABOUT 3 WEEKS LATER. GM STATES IT IS A KNOWN PROBLEM, BUT THERE IS CURRENTLY NOT A FIX FOR IT. SAYS IT IS DEFINITELY THE EXHAUST SYSTEM.*AK

Owner-reported narrative. 2,537 miles reported. Look up ODI 10078444 at NHTSA ↗

Reported: 2004-02-04 (February 4, 2004)

CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.

Consequence: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.

Remedy: DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.

Reported: 2005-04-22 (April 22, 2005)

ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.

Consequence: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.

Remedy: DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.