2007 Chevrolet KODIAK: complaints, problems and recalls

MY 2007 YUKON HAS NO DASH INSTRUMENT LIGHTS DURING DAYLIGHT. THE ONLY GAUGE ILLUMINATION IS WHEN THE HEADLIGHTS ARE TURNED ON. DURING DAYLIGHT, THE GAUGES ARE IMPOSSIBLE TO SEE WITH SUNGLASSES. AND ALMOST IMPOSSIBLE TO SEE WITHOUT SUNGLASSES. THIS IS VERY DANGEROUS BECAUSE YOU HAVE TO TAKE YOUR EYES OFF THE ROAD FOR A CONSIDERABLE TIME TO VIEW THE GAUGES. I HAVE TAKEN TO THE DEALER AND GMC; THEY HAVE NO ANSWERS. *NM

Owner-reported narrative. Look up ODI 10180832 at NHTSA ↗

GENERAL MOTORS SPECIFY THE FOLLOWING FOR MY VEHICLE: 2007I POST-DIESEL EMISSION WARNING ON THE POST-EMISSION DIESEL ENGINE IT IS A REQUIREMENT THAT THE EXHAUST TIP COOLER SUPPLIED BY GM IS INSTALLED FOR EVERY DIESEL EQUIPPED VEHICLE. IF YOU DO NOT INSTALL TO EXHAUST TIP COOLER THERE IS A HIGH PROBABILITY THAT YOU WILL START A FIRE IN THE IMMEDIATE VICINITY OF THE VEHICLE DURING REGENERATION (TEMPERATURE IN EXCESS OF 1,000 F). IF NOT INSTALLED THEN THE SECONDARY MANUFACTURER ASSUMES ALL LIABILITY FOR AN INCIDENT. THIS PART IS NOT OPT…

Owner-reported narrative. 6,000 miles reported. Look up ODI 10216039 at NHTSA ↗

I PICKED UP A NEW C4500 KODIAK PICK UP CONVERSION FROM MONROE TRUCK EQUIPMENTS FLINT LOCATION. IT WAS DELIVERED WITH MONROE'S SO-LOW SUSPENSION COMPONENTS AND A PICK-UP BED. IT HAD 0.7 MILES AT DELIVERY. IMMEDIATELY UPON ENTERING THE HIGHWAY, THE VEHICLE HAD A MODERATE TO SEVERE FRONT END VIBRATION--EVIDENT AT 46-50 MPH AND AGAIN-- WITH SEVERE STEERING WHEEL VIBRATION-- AT THE POSTED HIGHWAY SPEED. IT HAD MODERATE BUMP STEER ISSUES WHEN ENCOUNTERING ROUGH ROADS MAKING IT EVEN HARDER TO CONTROL AT HIGHWAY SPEEDS. THE VEHICLE WILL DART ONE D…

Owner-reported narrative. 1 miles reported. Look up ODI 10217562 at NHTSA ↗

I TOOK DELIVERY OF A NEW C4500 KODIAK CREW CAB WITH 0.7 MILES. I FIRST NOTICED A LOUD WIND-HOWL COMING FROM THE RIGHT REAR PASSENGER DOOR. I WAS DISAPPOINTED THAT THE VEHICLE HAD SUCH LOUD INTERIOR NOISE AT HIGHWAY SPEED. IT WASN'T UNTIL I ENCOUNTERING HEAVY FREEZING RAIN, THAT I REALIZED THAT THIS MOISTURE WAS ACCUMULATING IN THE DOOR JAMB OF THE AFOREMENTIONED DOOR, FREEZING, AND MAKING IT IMPOSSIBLE TO OPEN THE DOOR. UPON FURTHER INSPECTION, THE DOOR WAS ASSEMBLED AT GM INCORRECTLY AND THE LEADING EDGE OF THE DOOR WAS 3/8" OUT OF ALIGNME…

Owner-reported narrative. 1 miles reported. Look up ODI 10217563 at NHTSA ↗

I TOOK DELIVERY OF A NEW C4500 KODIAK 169" WHEELBASE WITH 0.7 MILES AT MONROE TRUCK EQUIPMENTS FLINT LOCATION. IT WAS DUSK. UPON ENTERING THE HIGHWAY, I NOTICED THAT THE HEADLIGHTS WERE AIMED ONLY ABOUT 13 FEET IN FRONT OF THE CAB AND THAT THE LIGHTING WAS VERY DIM. I STOPPED AT THE FIRST REST-AREA TO FIND THAT THE DRIVERS HEADLIGHT (SEALED BEAM) WAS NOT FUNCTIONAL. I WAS FORCED TO COMPLETE MY JOURNEY WITH THE HIGHBEAMS ON. THE VEHICLE WAS BRAND NEW. UPON REPLACING THE HEADLIGHT AT MY FIRST OPPORTUNITY, I NOTICED THAT THE AIMING MECHANISM…

Owner-reported narrative. 1 miles reported. Look up ODI 10217564 at NHTSA ↗

I OWN A 2007 KODIAK PICKUP CONVERSION WITH HYDRAULIC BRAKES. AFTER A HEAVY RAIN, I NOTICED WATER COMING FROM THE AREA OF THE BRAKE ACTUATOR ROD AT THE FIREWALL. NO FAILURE HAS ENSUED, BUT I WAS UNABLE TO DETERMINE IF THIS WAS A PRIMARY BRAKE PROBLEM OR A PROBLEM WITH THE WINDSHIELD SEAL. EVENTUALLY THE CORROSION OR MOISTURE IN THE PASSENGER FOOT WELL WILL CREATE A SAFETY PROBLEM. *TR

Owner-reported narrative. 300 miles reported. Look up ODI 10217566 at NHTSA ↗

IN REFERENCE TO COMPLAINT #10217562, THIS IS AN ADDENDUM. THE VEHICLE HAS SINCE BEEN TO AN ALIGNMENT FACILITY, AND IT HAS BEEN DETERMINED THAT THE STEERING WHEEL WAS REPOSITIONED APPROXIMATELY 50 DEGREES OFF CENTER BY THE END MANUFACTURER---MONROE TRUCK EQUIPMENT. THIS DEVIATION FROM CENTER WAS SUBSEQUENTLY REPORTED BY US TO AN ENGINEER AT ZF LINKSYSTEM (THE MANUFACTURER OF THE STEERING GEAR), AND THEIR OPINION WAS THAT THE STEERING GEAR WAS NOT AT ITS OPTIMAL POSITION--THIS ADVERSELY AFFECTS STEERING "PLAY" AND THE RANGE OF STEERING LEFT OR …

Owner-reported narrative. 1 miles reported. Look up ODI 10220076 at NHTSA ↗

TL*THE CONTACT OWNS A 2007 CHEVROLET KODIAK 4500. WHILE DRIVING APPROXIMATELY 55 MPH, THE FRONT AXLE SHAKES AND CAUSES THE PASSENGER SIDE TIRE TO WEAR FASTER. THE FAILURE OCCURS INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT SERVICED. THE CURRENT MILEAGE WAS 18,000 AND FAILURE MILEAGE WAS 1,000. UPDATED 4/25/08 *CN

Owner-reported narrative. 1,000 miles reported. Look up ODI 10224086 at NHTSA ↗

Reported: 2007-04-10 (April 10, 2007)

ON CERTAIN TRUCKS, THE REAR DRIVE AXLE HOUSING WAS MANUFACTURED WITH STEEL BELOW THE SPECIFIED THICKNESS AND, AS A RESULT, IT COULD DEVELOP A CRACK.

Consequence: IF A CRACK DEVELOPS AND IS NOT DETECTED AND REPAIRED, THE OUTBOARD END OF THE HOUSING COULD EVENTUALLY SEPARATE, ALLOWING THE HUB, AXLE SHAFT, OR WHEEL AND BRAKE ASSEMBLY TO SEPARATE FROM THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE AXLE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 12, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR GMC AT 1-866-996-9463.

Reported: 2007-05-02 (May 2, 2007)

ON CERTAIN MEDIUM DUTY CONVENTIONAL AND TILT CAB TRUCKS EQUIPPED WITH 7.8L DIESEL ENGINES AND AIR BRAKES, THE AIR COMPRESSOR MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM.

Consequence: IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLE WAS STATIONARY (BRAKES APPLIED) THE AIR BRAKES WOULD REMAIN APPLIED AND PREVENT THE VEHICLE FROM MOVING. IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, THE DUAL SYSTEM AIR PRESSURE GAUGES WOULD REGISTER THE DROP IN PRESSURE. IF THE PRESSURE CONTINUED TO DROP, THE LOW AIR PRESSURE WARNING BUZZER AND WARNING LAMP WOULD ACTIVATE AS DESIGNED, WARNING THE DRIVER TO MOVE THE VEHICLE TO A SAFETY LOCATION. IF THE DRIVER IGNORES THESE WARNINGS AND CONTINUES TO DRIVE THE VEHICLE, AND IF THERE WAS A CONTINUED LOSS OF PRESSURE, THE REAR SPRING PARKING BRAKES WOULD AUTOMATICALLY APPLY, PREVENTING THE TRUCK FROM BEING DRIVEN.

Remedy: DEALERS WILL REPLACE THE AIR COMPRESSOR HEAD. THE RECALL BEGAN ON MAY 23, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR ISUZU AT 1-800-255-6727.

Reported: 2007-08-28 (August 28, 2007)

ON CERTAIN STRAIGHT TOWING OR NON-TOWING TRUCKS EQUIPPED WITH BENDIX AIR BRAKES, THE AIR BRAKE PARK CONTROL VALVE MAY DEVELOP EITHER AN INTERNAL AIR LEAK OR AN AIR RESTRICTION. THE PARK BRAKE MAY NOT RELEASE OR MAY RELEASE ONLY PARTIALLY.

Consequence: IF THE VEHICLE IS ON AN UNEVEN SURFACE, THE PARK BRAKE MAY NOT HOLD THE VEHICLE AND COULD RESULT IN UNINTENDED VEHICLE MOVEMENT AND A VEHICLE CRASH. THIS CONDITION DOES NOT AFFECT NORMAL SERVICE BRAKING.

Remedy: DEALERS WILL INSPECT AND REPLACE THE EXTERNAL CHECK VALVE ON THE AIR BRAKE PARK CONTROL VALVE IF THE INSPECTION DETERMINES THE EXTERNAL CHECK VALVE IS DAMAGED, THE AIR BRAKE PARK CONTROL VALVE WILL BE REPLACED AND MAY REQUIRE THE REPLACEMENT OF AN INTERNAL CHECK VALVE IN THE AIR BRAKE PARK CONTROL VALVE. REMEDY WILL BE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 22, 2007. OWNERS MAY CONTACT GM AT 1-800-862-4389 OR ISUZU AT 1-800-255-6727.

Reported: 2007-10-04 (October 4, 2007)

ON CERTAIN MEDIUM DUTY TRUCKS EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THE STEERING GEAR MAY HAVE BEEN PRODUCED INCORRECTLY. A STEERING GEAR WITH THIS CONDITION MAY PRODUCE THE FEELING OF HITTING A CURB AND A CRACKING OR PINGING SOUND WHEN THE STEERING WHEEL IS TURNED.

Consequence: THE STEERING WHEEL POSITION MAY BE OFF-CENTER AND INCREASED EFFORT MAY BE REQUIRED WHEN TURNING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT FOR CERTAIN DATE CODES AND VERIFY THE MILEAGE ON STEERING GEARS AND REPLACE GEARS AS NECESSARY. THE RECALL BEGAN ON OCTOBER 25, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR ISUZU AT 1-800-255-6727.

Reported: 2009-07-29 (July 29, 2009)

GM IS RECALLING 1,880 MODEL YEAR 2007 CHEVROLET KODIAK AND T-SERIES, GMC TOPKICK AND T-SERIES, AND ISUZU F-SERIES AND H-SERIES PASSENGER VEHICLES EQUIPPED WITH 7.8L DIESEL ENGINE. THE AIR COMPRESSOR IN SOME OF THESE VEHICLES MAY NOT BUILD ENOUGH AIR PRESSURE TO SUPPORT THE AIR BRAKE SYSTEM. IF THIS CONDITION WERE TO OCCUR WHILE THE VEHICLES WAS STATIONARY (BRAKES APPLIED), THE AIR BRAKES WOULD REMAIN APPLIED AND PREVENT THE VEHICLE FROM MOVING.

Consequence: IF THE DRIVER IGNORES THESE WARNINGS AND CONTINUES TO DRIVE THE VEHICLE, AND IF THERE WAS A CONTINUED LOSS OF PRESSURE, THE REAR SPRING PARKING BRAKES WOULD AUTOMATICALLY APPLY, PREVENTING THE TRUCK FROM BEING DRIVEN.

Remedy: DEALERS WILL INSPECT THE AIR COMPRESSOR FOR ITS ABILITY TO BUILD AIR PRESSURE, AND EITHER MODIFY THE AIR COMPRESSOR BY ELIMINATION OF THE SUPPRESSION VALVE OR REPLACE THE AIR COMPRESSOR ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727 OR AT WWW.GMOWNERCENTER.COM.