2010 Chevrolet EXPRESS: complaints, problems and recalls

TL* THE CONTACT OWNS A 2010 CHEVROLET EXPRESS. THE CONTACT STATED WHILE DRIVING 15 MPH THE ABS AND STABILITRAC WARNING LAMPS ILLUMINATED. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED TWICE AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE RIGHT REAR WIRING HARNESS WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE REMEDY FAILED TO REPAIR THE PROBLEM. THE VEHICLE WAS TAKEN BACK TO THE LOCAL MECHANIC WHO DIAGNOSED THAT THE THROTTLE SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE…

Owner-reported narrative. 39,000 miles reported. Look up ODI 10447919 at NHTSA ↗

I HAVE BEEN DEALING WITH GM HEAD OFFICE AND THEIR CALL CTR FOR OVER 1 + YEARS. I HAVE BEEN TELLING THEM THAT THERE IS HESITATION AT THE PEDAL AT ACCELERATION, CONSTANT NOISE FROM THE ENGINE - SOUNDS LIKE A MACHINE GUN. THEY ARE ALWAYS TELLING ME THAT THESE ARE "VEHICLE CHARACTERISTICS"!!!! I DON'T BELIEVE THEM! THEN THEY PUT ME ON A OIL CONSUMPTION AS I WAS ALMOST OUT OF OIL FOR A 3 YEAR OLD VEHICLE WITH ONLY 40,000KMS. THEY WERE MONITORING THIS EVERY 1,000 APPROX. I CAN SMELL GAS IN MY OIL, SO THEY SENT A SAMPLE OFF TO CAT, WHICH THEY TE…

Owner-reported narrative. Look up ODI 10470603 at NHTSA ↗

THIS VEHICLE HAS HAD MULTIPLE INCIDENTS OF CUTTING OUT AND STALLING CAUSING LOSS OF STEERING AND BRAKES, AND JUST BEFORE IT COMPLETELY SHUTS DOWN IT WILL POWER BACK UP. IN APRIL 2011 AN OPERATOR STATED "INTERMITTENTLY WHEN MAKING A LEFT HAND TURN AT APPROX. 10 - 15 MPH WITH ACCELERATION THE TRACTION LIGHT COMES ON AND VAN CUTS OUT FOR A FEW SECONDS LIKE SOMEONE SHUT OFF THE KEY, IT POWERS MOST OF THE WAY DOWN AND THEN WILL COME BACK ON ITS OWN." DURING THIS TIME THE STEERING AND BRAKES ARE COMPROMISED. IN NOVEMBER 2011 AN OPERATOR STATED "PO…

Owner-reported narrative. 11,000 miles reported. Look up ODI 10485175 at NHTSA ↗

AN OPERATOR REPORTED IN AUGUST OF 2012 THAT "THE ENGINE DIES AFTER DRIVING ABOUT 1 MILE, THEN RESTARTS." IN SEPTEMBER 2012 WE HAD ONE OPERATOR DOCUMENT HIS FINDING OVER A TWO WEEK PERIOD, HIS REPORTS INCLUDE: "9/14/12 LEFT BRAKE PULL, GOING STRAIGHT AT 50 MPH AFTER ABOUT 1 TO 2 MILES OF OPERATION." "9/10/12 FRONT BRAKES SEEMED TO COME ON, SPEED DROPPED ABOUT 15 MPH FROM 55 MPH, THIS WAS WITHIN THE FIRST 4-5 MILES TRAVELED." "9/12/12 VAN PULLED TO RIGHT, RIGHT BRAKE CAME ON WHILE GOING AROUND A LEFT HAND CORNER , SPEED DROPPED 10 - 15 MPH." …

Owner-reported narrative. 47,850 miles reported. Look up ODI 10485188 at NHTSA ↗

ON OCTOBER 23, 2012 AT 3:00 PM THE VAN PULLED TO THE RIGHT WHILE IN A LEFT TURN, STEERING FIRST TO THE RIGHT AND THEN TO THE LEFT WHEN BRAKES WERE APPLIED. VAN SPEED WAS ABOUT 25-30 MPH, DRIVER WAS ABLE TO CONTROL STEERING BUT ONLY WITH FORCE. LIGHT FOR STABILITY CONTROL CAME ON AS STEERING CONTROL WAS LOST AND WAS OFF WHEN VAN STOPPED. ENGINE RPM FOLLOWED GAS PEDAL LIFT, AND BRAKE APPLY. THE VAN WENT ONTO THE GRAVELLECD SHOULDER OF THE ROAD DURING THIS INCIDENT. *TR

Owner-reported narrative. 44,500 miles reported. Look up ODI 10485210 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 CHEVROLET EXPRESS CARGO VAN. THE CONTACT STATED THAT THE CONNECTORS AND CABLES NEAR THE FUEL TANK WERE FOUND TO BE BURNED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS BUT THE MECHANIC STATED THAT THEY COULD NOT DETERMINE THE PROBLEM. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000.

Owner-reported narrative. 65,000 miles reported. Look up ODI 10542927 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, ANOTHER VEHICLE CRASHED INTO THE FRONT DRIVER'S SIDE WHICH CAUSED THE VEHICLE TO FLIP OVER AND THEN LANDED ON ALL FOUR WHEELS. THERE WERE FIVE OCCUPANTS IN THE VEHICLE THAT SUFFERED FROM INJURIES TO THE BACK, INCLUDING LACERATIONS AND CONTUSIONS TO THE BODY. ONE OF THE PASSENGER WAS EJECTED FROM THE VEHICLE AND FRACTURED THEIR PELVIS AND FEMUR. THE FRONT DRIVER'S SIDE SEAT BELT BUCKLE UNLATCHED INDEPENDENTLY HOWEVER, THE DRIVER DID NOT SUST…

Owner-reported narrative. Look up ODI 10597854 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 CHEVROLET EXPRESS VAN. THE CONTACT STATED THAT WHILE MAKING A TURN, THE STEERING WHEEL SHOOK UNCONTROLLABLY AND BECAME VERY HARD TO MANEUVER. THE CONTACT WAS A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE LOWER ISOLATION GROMMET ON THE FRONT SHOCK FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

Owner-reported narrative. 65,000 miles reported. Look up ODI 10653365 at NHTSA ↗

Reported: 2010-03-12 (March 12, 2010)

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES FOR FAILING TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 103, "WINDSHIELD WIPING AND WASHING SYSTEMS." THESE VEHICLES WERE BUILT WITH HEATING, VENTILATION, AND AIR CONDITIONING (HVAC) CONTROL KNOBS THAT MAY FRACTURE AND SPIN ON THE CONTROL SHAFT. THE DRIVER MAY NO LONGER BE ABLE TO CONTROL THE HEATING, COOLING, AND VENTILATION FOR THE VEHICLE.

Consequence: IF THIS CONDITION AFFECTS THE DEFROST SYSTEM WHEN IT IS REQUIRED, IT MAY DECREASE THE DRIVER'S VISIBILITY, AND COULD POSSIBLY RESULT IN A CRASH.

Remedy: DEALERS WILL REPLACE ALL HVAC CONTROL KNOBS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 11, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Reported: 2010-04-06 (April 6, 2010)

GENERAL MOTORS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2010 CHEVROLET EXPRESS AND GMC SAVANA VANS 2500, 3500 AND 4500 SERIES. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH THE GENERATOR MAY DEVELOP A LOW RESISTANCE SHORT WITHIN THE VOLTAGE REGULATOR.

Consequence: THE LOW RESISTANCE SHORT COULD EVENTUALLY GENERATE ENOUGH HEAT TO RESULT IN AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL INSPECT AND REPLACE ANY SUSPECT GENERATORS IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Reported: 2012-04-17 (April 17, 2012)

MAIN MOBILITY IS RECALLING CERTAIN CONVERSION VANS BUILT ON MODEL YEAR 2008-2010 CHEVROLET EXPRESS, 2009 GMC SAVANA, AND 2010 FORD TRANSIT CONNECT CHASSIS, AND FITTED WITH CERTAIN BRAUN WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE WHEELCHAIR LIFT’S OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

Consequence: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR’S OCCUPANT COULD FALL AND SUSTAIN INJURY.

Remedy: MAIN MOBILITY IS WORKING WITH BRAUN TO NOTIFY OWNERS, AND BRAUN DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. MAIN MOBILITY HAS NOT PROVIDED A NOTIFICATION SCHEDULE. OWNERS MAY CONTACT MAIN MOBILITY AT 1-716-759-6811.

Reported: 2014-03-17 (March 17, 2014)

General Motors LLC (GM) is recalling certain model year 2009-2014 Chevrolet Express and GMC Savana vans manufactured January 27, 2009, through March 7, 2014 with a gross vehicle weight rating of 10,000 pounds and less and equipped with front passenger air bags. In the affected vehicles, during a frontal impact below the air bag deployment threshold, if an unbelted front passenger's head hits the instrument panel above where the passenger air bag is located, the panel may not sufficiently absorb the impact. As such, these vehicles fail to meet the requirements of Federal Motor Vehicle Safety Standard number 201, "Occupant Protection in Interior Impact."

Consequence: In the event of a crash below the air bag deployment threshold, an unbelted front passenger seat occupant has an increased risk of injury.

Remedy: GM will notify owners, and dealers will modify the passenger instrument panel free of charge. Notices to the owners of the heavy duty vans were mailed on April 28, 2014. The recall began on May 19, 2014. Chevrolet owners may call 1-800-630-2438. GMC owners may call 1-866-996-9463. GM's number for this recall is 14082.

Reported: 2018-04-26 (April 26, 2018)

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.