2008 Chevrolet EXPRESS: complaints, problems and recalls

2008 CHEVY 3500 EXPRESS VAN WITH ABOUT 40,000 MILES. HAVE A PROBLEM WITH THE STABILATRACK SYSTEM AND THE DEALER SAID IT IS A WIRING PROBLEM. IT IS A FLEET VAN. HAVE HAD THE PROBLEM ON 2 OF 15. TRANSMISSION DOWN SHIFTS WHEN THIS HAPPENS, SPEED IS LIMITED TO ABOUT 15 MPH, SPEEDOMETER QUITS. STABILATRACK LIGHT TURNS ON. *TR

Owner-reported narrative. 40,000 miles reported. Look up ODI 10355907 at NHTSA ↗

WHILE DRIVING VAN AT START OF RUSH HOUR TRAFFIC. AND NEED TO STOP AT TRAFFIC LIGHT. THE ROAD A HEAD OF ME MERGES FROM 3 LANE TO 2. WHEN LIGHT CHANGED I STEPPED ON PEDAL TO MERGE LEFT. AND GAS PEDAL STAYED TO FLOOR. I AM NOT SURE IF I STEPPED ON PEDAL A FEW TIMES TO GET IT UNSTUCK, AS I HAD MY FOOT ON BRAKE TO SLOW VAN DOWN. I AM NOT SURE OF THE SEQUENCE. BUT VAN THEN STARTING TO SLOW DOWN. ALL THIS HAPPEN IN UNDER A MINUTE. IF IT HAD NOT SLOWED DOWN I WOULD OF RAN IN TO THE BACK OF CAR IN FRONT OF ME. IT WAS VERY SCARY. SINCE THEN PEDAL HAS WOR…

Owner-reported narrative. 44,950 miles reported. Look up ODI 10360231 at NHTSA ↗

TL*THE CONTACT OWNS A 2008 CHEVROLET EXPRESS VAN. THE CONTACT WAS DRIVING AND CAME ACROSS A DARK ROAD. THE CONTACT WAS FORCED TO USE THE HIGH BEAMS AND WHEN THEY WERE TURNED ON, THEY CAUSED ALL OF THE EXTERIOR LIGHTS TO FAIL. THE CONTACT TURNED THE HEADLIGHTS ON AND OFF, BUT THE HIGH BEAMS NO LONGER WORKED. THE DEALER INSPECTED THE VEHICLE AND STATED THAT BOTH LIGHT BULBS FAILED. THE CONTACT WAS CONCERNED ABOUT THE FAILURE SINCE THEY WERE ABLE TO USE THE LOW BEAMS. THE LOW BEAM HEAD LIGHTS AND HIGH BEAM HEAD LIGHTS WERE IDENTICAL AND THE FAILUR…

Owner-reported narrative. 37,405 miles reported. Look up ODI 10368483 at NHTSA ↗

MY ROTORS KEEP WARPING AND ENDANGERING MY LIFE!!!!!!!!!!!!!!!! I AM ON MY FOURTH SET OF ROTORS IN 84,000 MILES!!!! AND ON TOP OF THAT I HAVE THE ORIGINAL BRAKE PADS. AS A MATTER OF FACT FROM 14,000 MI TO 94,000 MY BRAKE PADS HAVE NOT WORN AT ALL. I HAD TO CUT THE ROTORS AT 30,000, AND THEN AT 50,000 THEY WERE WARPED AND TOO THIN TO RESURFACE. I REPLACED THEM AGAIN. AT 80,000 I HAD TO HAVE THEM CUT BECAUSE THEY WERE WARPED. THEN AT 85,000 I HAD TO HAVE THEM REPLACED AGAIN BECAUSE THEY WERE WARPED. MY ROTORS GET TO HOT THAT WHEN I BRAKE, MY WH…

Owner-reported narrative. 36,000 miles reported. Look up ODI 10382230 at NHTSA ↗

WHILE MERGING ON THE EXPRESSWAY THE TRANSMISSION FAILED TO SHIFT OUT OF FIRST OR SECOND GEAR CAUSING HIGH ENGINE RPM'S . I HAD TO SHIFT INTO NEUTRAL AND BACK INTO DRIVE SEVERAL TIMES BUT IT STILL FAILED TO SHIFT INTO ANY GEAR. I HAD TO PUT ON FLASHERS ( HEAVY TRAFFIC ) AND MAKE MY WAY TO THE EMERGENCY LANE. WHEN I CAME TO A COMPLETE STOP AND SHIFTED BACK INTO DRIVE IT SHIFTED CORRECTLY. I HAVE HAD THIS PROBLEM FOR SEVERAL MONTHS TO PRESENT DATE. I TOOK THE VAN TO THE DEALERSHIP WHO SAID THEY COULD NOT REPLICATE THE PROBLEM AND THEIR WERE NO COD…

Owner-reported narrative. 35,000 miles reported. Look up ODI 10459776 at NHTSA ↗

TL* THE CONTACT OWNS A 2008 CHEVROLET EXPRESS. THE CONTACT WAS DRIVING 45 MPH WHEN THE EXTERIOR AND INTERIOR LIGHTS FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER SEVEN TIMES. THE DEALER STATED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE WAS 47,115.

Owner-reported narrative. 12,000 miles reported. Look up ODI 10467651 at NHTSA ↗

WHILE DRIVING DOWN THE ROAD AT APPROXIMATELY 50 MPH ALL WARNING LIGHTS ON THE DASH LIT UP, THE SPEEDOMETER CEASED TO FUNCTION, THE RADIO CUT OUT, THE AIRBAGS WERE REPORTING AS NONFUNCTIONAL, THE ABS SYSTEM WAS REPORTING NONFUNCTIONAL. TOOK VEHICLE TO LOCAL MECHANIC WHO SAID THE PROBLEM APPEARED TO BE CAUSED BY CORROSION ON THE ABS SENSOR AS WELL AS CORROSION ON THE POWER DISTRIBUTION CABLES INTO THE FUSE BOX. ACCORDING TO THE MECHANIC GM WAS AWARE OF THE PROBLEM, AS TECHNICAL BULLETINS DATING BACK TO AROUND 2005 WERE ISSUED. HE ALSO STATED SHOU…

Owner-reported narrative. 73,000 miles reported. Look up ODI 10577161 at NHTSA ↗

THE SIDE DOORS ON BOTH SIDES VERY HARD TO OPEN BECAUSE YOU CANNOT GREASE THEM, THE SUNROOF LEAKS ,BACK REAR DOORS HANDLES STOP WORKING, TOOK THESE PROBLEMS SEVERAL TIMES TO BE ADDRESS AND PAID FOR SOME OF THE WORK TO BE DONE TO NO AVAIL STILL HAVE THE PROBLEMS, I HAVE A SON THAT'S DISABLE AND ITS VERY DANGEROUS IF SOMETHING HAPPENS AND WE CANNOT GET HIM OUT THE DOORS, PLUS THE SUNROOF LEAKS SO BAD THAT ANYONE IN THE REAR WILL GET SOAK AGAIN PAID TO HAVE IT DONE BUT TO NO AVAIL. CALL GM BUT AGAIN NO HELP JUST WAS TOLD THEY KNEW ABOUT THE PROBLEM…

Owner-reported narrative. 199 miles reported. Look up ODI 10578689 at NHTSA ↗

Reported: 2008-07-11 (July 11, 2008)

GM IS RECALLING 2,481 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA G-CUTAWAY FLEET VAN EQUIPPED WITH A 6.0L (RPO LY6) V8 ENGINE, 4L80E (RPO MT1) TRANSMISSION, 4.10 (RPO GT5) AXLE AND 75 MPH GOVERNOR (RPO 9D7). THESE VEHICLES HAVE A CONDITION IN WHICH THE TRANSMISSION MAY BE DAMAGED DUE TO FIRST GEAR ENGAGEMENT AT HIGHWAY SPEEDS AND THEN DOES NOT TRANSMIT POWER WITH D4 OR R SELECTED. THIS MAY BE PRECEDED BY ENGINE SHUTDOWN IF THE VEHICLE EXCEEDS 81 MILES PER HOUR IN CERTAIN CONDITIONS.

Consequence: THE VEHICLE MAY BE STRANDED ON OR NEAR A HIGHWAY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPROGRAM THE TRANSMISSION AND ENGINE CONTROL MODULES FREE OF CHARGE. THE RECALL BEGAN ON OR ABOUT JULY 30, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Reported: 2008-07-14 (July 14, 2008)

GM IS RECALLING 567 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA CUTAWAY VEHICLES WITH A 139" WHEEL BASE. THE FRAME RAIL ON THE DRIVER'S SIDE MAY BE WIDER THAN SPECIFICATION.

Consequence: IF THE FRAME RAIL IS WIDER THAN SPECIFICATION, OVER TIME IT MAY CONTACT THE FUEL TANK HOUSING, RESULTING IN A POSSIBLE FUEL LEAK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE CLEARANCE BETWEEN THE FRAME RAIL AND FUEL TANK HOUSING AND WILL REWORK THE FRAME RAIL IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JULY 30, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-966-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Reported: 2008-07-28 (July 28, 2008)

GM IS RECALLING 151 MY 2008 CHEVROLET EXPRESS AND GMC SAVANA VEHICLES EQUIPPED WITH ALL WHEEL DRIVE (AWD). SOME OF THESE VEHICLES HAVE TRANSFER CASES THAT WERE MANUFACTURED WITH AN INCORRECT PART THAT CAN CAUSE EARLY FAILURE OF A DRIVE CHAIN. IF THE CHAIN BREAKS, SHIFTING THE TRANSMISSION TO PARK MAY NOT KEEP THE VEHICLE STATIONARY.

Consequence: IF THE VEHICLE IS PARKED ON AN INCLINE OR BUMPED, IT MAY ROLL AND STRIKE A PERSON, OBJECT, OR ANOTHER VEHICLE WITHOUT WARNING, AND CAUSE PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT THE TRANSFER CASE DATE CODE AND, IF NECESSARY, REPLACE THE TRANSFER CASE. THE RECALL BEGAN ON AUGUST 15, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Reported: 2008-10-24 (October 24, 2008)

CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATION IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.

Reported: 2008-10-24 (October 24, 2008)

CUMMINGS IS RECALLING 42 MY 2006-2008 FORD E150, E350, CHEVROLET EXPRESS, MY 2006 FORD E250, GMC SAVANNA, DODGE SPRINTER CONVERSION VANS, AND MY 2007 NEWMAR DUTCHSTAR MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: CUMMINGS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR CUMMINGS AT 1-763-498-7887.

Reported: 2009-07-06 (July 6, 2009)

MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.

Reported: 2009-07-06 (July 6, 2009)

MAIN MOBILITY IS RECALLING 185 MODEL YEAR 2005 THROUGH 2009 CHEVROLET EXPRESS AND GMC SAVANA VANS MANUFACTURED BETWEEN APRIL 1, 2005 AND JUNE 25, 2009, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: MAIN MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.

Reported: 2009-11-19 (November 19, 2009)

CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

Consequence: THIS DEFECT COULD RESULT IN A FIRE.

Remedy: CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.

Reported: 2010-05-13 (May 13, 2010)

MAIN MOBILITY IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 CONVERSION VANS BUILT ON CHEVROLET EXPRESS AND GMC SAVANA CHASSIS FROM OCTOBER 2007 THROUGH MAY 2010 AND FITTED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION, SHOULD THE "UP" BUTTON BE RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL AND MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

Consequence: WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

Remedy: MAIN MOBILITY WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. A SOFTWARE SOLUTION FOR THIS SAFETY DEFECT IS UNDER INVESTIGATION. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MAIN MOBILITY AT 1-716-759-6811.

Reported: 2012-04-17 (April 17, 2012)

MAIN MOBILITY IS RECALLING CERTAIN CONVERSION VANS BUILT ON MODEL YEAR 2008-2010 CHEVROLET EXPRESS, 2009 GMC SAVANA, AND 2010 FORD TRANSIT CONNECT CHASSIS, AND FITTED WITH CERTAIN BRAUN WHEELCHAIR LIFTS. OVER TIME AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE WHEELCHAIR LIFT’S OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

Consequence: A WHEELCHAIR OCCUPANT MAY DEFEAT OR RIDE OVER THE INSUFFICIENTLY LATCHED ROLL STOP. IF THIS OCCURS WHEN THE LIFT PLATFORM IS IN AN ELEVATED POSITION, THE WHEELCHAIR’S OCCUPANT COULD FALL AND SUSTAIN INJURY.

Remedy: MAIN MOBILITY IS WORKING WITH BRAUN TO NOTIFY OWNERS, AND BRAUN DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. MAIN MOBILITY HAS NOT PROVIDED A NOTIFICATION SCHEDULE. OWNERS MAY CONTACT MAIN MOBILITY AT 1-716-759-6811.