2007 Chevrolet CORVETTE: complaints, problems and recalls

TL* THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. ON 4/29/07 WHILE SITTING AT A STOP LIGHT PREPARING TO DRIVE THE CLUTCH WOULD NOT ENGAGE, CAUSING THE RPMS TO INCREASE AT A HIGHER RATE. THE DRIVER SMELLED SMOKE AND OIL BURNING. THIS INCIDENT OCCURRED TWICE WITHIN THE SAME DAY. THE DEALER STATED THAT THEY COULD NOT DIAGNOSE THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS 1000. *AK

Owner-reported narrative. 1,000 miles reported. Look up ODI 10189411 at NHTSA ↗

ON 2006 AND 2007 CHEVY CORVETTE'S THE REAR AXLE NUT WORKS ITSELF LOSE. MY "07" HAS 4,200 MILES ON IT. I CHECKED THE NUT'S AND FOUND THE DRIVERS SIDE TIGHT. BUT THE PASSENGER SIDE WAS 3/4 TURN SHORT OF SNUG, AND WELL SHORT OF THE 118LB TORSUE REQUIREMENT. I HEARD ABOUT IT ON ONE OF THE VETTE FORUM BOARDS. CHEVY HAS DONE NOTHING TO ALERT FOLKS OF THE PROBLEM. THERE ARE MANY PEOPLE IN MY CLUB THAT OF RETIREMENT AGE AND DO LITTLE IF ANY OF THE MAINTENANCE ON THEIR CARS. THEY HAD NO IDEA OF THIS HAPPENING. *TR

Owner-reported narrative. Look up ODI 10192282 at NHTSA ↗

WE WERE AT A STOP LIGHT AND SMELLED OIL BURNING. THIS HAPPENED A COUPLE OF TIMES BEFORE WE DECIDED TO LOOK UNDER THE CAR. WHEN WE DID THERE WAS OIL ALL OVER THE OIL PAN AND ALL THE WAY TO THE REAR OF THE CAR. TOOK THE CAR TO THE CHEVY DEALER AND THEY TIGHTENED THE BOLTS ON THE OIL PAN. THE SERVICE MANAGER TOLD US WHEN WE HAD IT IN THAT THERE WAS A SERVICE BULLETIN FOR THIS AND THE REAR MAIN SEAL HAD A PROBLEM WITH LEAKING AND THAT IT SHOULD BE REPLACED IF ANY ONE BROUGHT A VEHICLE IN WITH THIS PROBLEM. TOOK THE CAR HOME AND DROVE FOR A C…

Owner-reported narrative. 3,500 miles reported. Look up ODI 10199733 at NHTSA ↗

TL*THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. WHILE DRIVING 30 MPH, THE STEERING BECOMES DIFFICULT TO MANEUVER AND CAUSES THE VEHICLE TO SKID SIDEWAYS. THE CONTACT CALLED GM AND THEY INFORMED HIM THAT THE FAILURE WAS DUE TO A MANUFACTURER DEFECT. THERE ARE NO RECALLS AVAILABLE FOR THIS FAILURE. THE VEHICLE HAS NOT BEEN TO THE DEALER. THE CURRENT MILEAGE WAS 37 AND FAILURE MILEAGE WAS 26. THE CONSUMER STATED THE VEHICLE SKIPPED SIDEWAYS WHILE DRIVING ON ROUGH ROADS AT A MODERATE SPEED OF 20-40 MPH. THE STEERING HAS AN OUT OF CONTROL FEELI…

Owner-reported narrative. 26 miles reported. Look up ODI 10200860 at NHTSA ↗

JUST BOUGHT A NEW 2007 CORVETTE. VEHICLE "SKIPS SIDEWAYS" AT MODERATE SPEEDS (30 MPH) ON ROUGH ROADS. THIS IS A KNOW GM MANUFACTURE DEFECT THAT WAS COMPLETELY FIXED IN THE 2008 CORVETTE. EXPERIENCED THE "SKIP SIDEWAYS" ON THE WAY HOME FROM THE CHEVROLET DEALER. VEHICLE HAD 26 MILES ON IT WHEN PURCHASED AND NOW HAS 37 MILES ON IT. I GOT ONLINE TO THE "CORVETTE FORUM" AND WAS IMMEDIATELY REFERRED TO THE SEP 07 CAR AND DRIVER MAGAZINE ARTICLE SPECIFICALLY ADDRESSING THIS ISSUE. THE PROFESSIONAL DRIVERS IN THE ARTICLE RATE THE 2007 CORVETTE S…

Owner-reported narrative. 30 miles reported. Look up ODI 10200869 at NHTSA ↗

THE REAR WINDOW IN THE 2007 CHEVROLET CORVETTE HAS A DESIGN FLAW AND CAUSES DISTORTION TO THE POINT IT MAKES ONE DIZZY WHEN LOOKING THROUGH THE REAR VIEW MIRROR. THE WINDOW HAS BEEN REPLACED TWICE BY THE DEALERSHIP, HOWEVER THEY STATE THEY WILL NO LONGER DO ANYTHING ANY MORE ABOUT IT. THIS DISTORTION IS FOUND IN ALL OF THE CORVETTES AT THE DEALERSHIP, THE REGIONAL MANAGER LOOKED AT THEM AND HAS SAID THEY WILL NOT DO ANYTHING MORE, AS IT APPEARS IT IS THE PROBLEM LIES IN THE DESIGN. NO WHERE IN THE OWNER'S MANUAL, ADVERTISEMENTS, OR SUCH DOES…

Owner-reported narrative. 3,685 miles reported. Look up ODI 10202103 at NHTSA ↗

I HAVE HAD MY NEW 2007 CORVETTE FOR ONLY A FEW DAYS AND HAVE ONLY 37 MILES ON IT (26 MILES AT PURCHASE), BUT I AM ALREADY VERY DISAPPOINTED IN THE VEHICLES STEERING. I HAVE HAD 5 CORVETTES AND HAVE ALWAYS OWNED ONE AS AN ADULT AND I TRULY FEEL THAT THE STEERING IN THIS 2007 CORVETTE IS ?UNSAFE?. WHEN DRIVING HOME FROM THE GM DEALER, THE VEHICLE SKIPPED SIDEWAYS ON ROUGH ROADS AT A MODERATE SPEED (20-40 MPH). I GOT ONLINE TO THE CORVETTE FORUM AND WAS IMMEDIATELY REFERRED TO THE SEP 07, CAR AND DRIVER MAGAZINE ARTICLE SPECIFICALLY ADDRESSING …

Owner-reported narrative. 26 miles reported. Look up ODI 10202493 at NHTSA ↗

TL*THE CONTACT OWNS A 2007 CHEVROLET CORVETTE. THE VEHICLE HAS GOODYEAR EAGLE TIRES. UPON INSPECTION OF THE TIRES, THE CONTACT NOTICED THAT THE TWO FRONT TIRES HAD EXCESSIVE TREAD WEAR, AS WELL AS SEVERAL BULGES ON THE INTERIOR SIDEWALL. THE DEALER REFUSED TO INSPECT THE TIRES IN ORDER TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE CONTACT STILL HAS POSSESSION OF THE TIRES. THE FAILURE AND CURRENT MILEAGES WERE 12,033. UPDATED 08/04/08. *LJ UPDATED 08/05/08

Owner-reported narrative. 12,033 miles reported. Look up ODI 10233515 at NHTSA ↗

Reported: 2009-12-23 (December 23, 2009)

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.

Consequence: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.

Remedy: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.

Reported: 2014-05-14 (May 14, 2014)

General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.

Consequence: The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.