2023 Chevrolet BOLT EV: complaints, problems and recalls

Been almost rear ended twice, both drivers said my brake lights were out, after checking, brake lights were working but are so low on car they did not see them

Owner-reported narrative. Look up ODI 11494365 at NHTSA ↗

I have purchased the Autel Energy EVSE for my vehicle and had it installed by certified electricians in my garage. The unit malfunctions frequently and requires it to be restarted. The unit is hard wired and and the only way to reset it is to turn the breaker off and back on, as instructed by the manufacturer. NEV specifically says that using the breaker as a switch is no recommended. The purpose of the breaker is a power interruption device in case of an electrical fault. Using it as a switch to turn power off and back on could prematurel…

Owner-reported narrative. Look up ODI 11494961 at NHTSA ↗

A description of the problem is contained in the 'additional' information box below.

Owner-reported narrative. Look up ODI 11498710 at NHTSA ↗

The brake lighting only includes the upper light and the lower lights of the vehicle. The lights on the hatch do not light up when braking. Given that the upper light and lower lights are relatively small and hard to see from a close distance or in taller vehicles, this poses a significant risk for rear-ending from another vehicle.

Owner-reported narrative. Look up ODI 11526242 at NHTSA ↗

Yes I almost got rear-ended three times in the last 3 weeks because the brake lights on the Chevy Bolt are below the bumper and the tail lights do not go on when you step on the brakes only the Collision lights and the turn signal lights

Owner-reported narrative. Look up ODI 11526465 at NHTSA ↗

My wife had just parked the vehicle in our garage and had plugged it into the charger. She walked to the back of the vehicle to open the rear hatch and as she was raising the hatch she felt an electrical shock up her arm, it was strong enough that she immediately came into the house holding her elbow. It couldn't have been static electricity, she was already in contact with the vehicle when the shock occurred, the humidity was very high as it had been raining, plus the vehicle should be grounded through the charging plug. I immediately went …

Owner-reported narrative. Look up ODI 11530025 at NHTSA ↗

- The car did not start and we were left stranded in an unsafe place. When I turned the car on I immediately saw and error saying "Conditions not correct for shift" and then it wouldn't turn back off - safety was at risk because it was super hot and my 5 year old with autism could not make it home in our own car - not taken to dealer however many reports on social media for the same issue. [XXX] -not yet however I have an appointment at the dealership to have it inspected later this week - zero issues or warnings before this happened INFORM…

Owner-reported narrative. Look up ODI 11541055 at NHTSA ↗

Was sitting at a stop light when I accelerated on green I felt a lurch, it felt like someone had hit me from behind. Within 15 seconds of acceleration this light came on, a car with an exclamination point on it, and said to pull over ASAP. Car would not go any faster than 30mph and luckily I was not on an interstate or major highway. I was able to pull over in a parking lot and at that time the car was disabled. I could not put it in driver or reverse and it did not want to turn off I had to open the door to turn it off. On Star diagnosti…

Owner-reported narrative. Look up ODI 11549415 at NHTSA ↗

Reported: 2022-12-15 (December 15, 2022)

General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.

Consequence: A vehicle fire can increase the risk of injury.

Remedy: Dealers will install metal foil at the carpet near the pretensioner exhaust, and install a pretensioner cover as necessary, free of charge. Owner notification letters were mailed between January 23, 2023 and April 25, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N222383790.

Reported: 2023-08-10 (August 10, 2023)

General Motors, LLC (GM) is recalling certain 2022-2023 Chevrolet Bolt EV vehicles. The instrument panel may be missing the perforation on the underside of the panel cover that allows the passenger-side air bag to deploy properly.

Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.

Remedy: Dealers will replace the instrument panel, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N232414710.

Reported: 2023-12-14 (December 14, 2023)

General Motors, LLC (GM) is recalling certain 2017-2023 Chevrolet Bolt EV vehicles. This recall includes certain vehicles previously repaired incorrectly under NHTSA recall number 22V-930. After a crash with seat belt pretensioner deployment, the pretensioner exhaust may ignite carpet fibers near the B-pillar, causing a fire.

Consequence: A fire increases the risk of injury.

Remedy: Dealers will inspect both front seat belt pretensioners and, if necessary, install metal foil at the carpet near the pretensioner exhaust. Certain vehicles will also need a pretensioner cover installed. Repairs will be performed free of charge. Owner notification letters were mailed January 24, 2024. These vehicles were previously recalled for this same issue under recall number 22V-930 and will need to have the new remedy performed. Owners may contact GM EV Concierge at 1-833-EVCHEVY (1-833-382-4389) (TTY 711 / 1-800-833-2438) or Customer Service at 1-800-222-1020. GM's number for this recall is N232421970.