2006 Bmw K1200 R: complaints, problems and recalls

TL*THE CONTACT OWNS A 2006 BMW K1200 R MOTORCYCLE. THE BRAKES FAILED WHILE THE VEHICLE WAS IN MOTION. THE MANUFACTURER STATED THAT THEY COULD NOT DUPLICATE THE FAILURE WITH THE ABS BECAUSE THEY NO LONGER PRODUCE THOSE PARTICULAR BRAKES. THE VEHICLE HAS NOT YET BEEN REPAIRED. THE CONTACT HAS SEEN SEVERAL COMPLAINTS FOR THIS SAME FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 15,000. UPDATED 03/12/09. *LJ THE CONSUMER STATED THE BRAKES FAILED WHILE TRAVELING DOWN A STEEP BANK AT 5 MPH. WHEN HE APPLIED THE BRAKES, THE ABS FEATURE ACTIVATED…

Owner-reported narrative. 15,000 miles reported. Look up ODI 10258361 at NHTSA ↗

WHILE DEMONSTRATING THE ABS BRAKING SYSTEM ON MOTORCYCLES FOR A NUMBER OF MOTORCYCLE SAFETY INSTRUCTORS (IN A PARKING LOT,) I HAD RIDDEN WITHIN 5 MINUTES A HANDFUL OF SUCCESSFUL ABS DEMO RUNS. I WAS STARTING AT ONE SIDE OF THE LOT, GETTING UP TO 30-40 MPH, AND APPLYING THE BRAKES WITH ENOUGH FORCE FOR THE ABS TO ACTIVATE. DURING THE DEMONSTRATION, AFTER APPROXIMATELY HALF OF A DOZEN SUCCESSFUL RUNS, I DID THE EXACT SAME THING EXCEPT THE ABS FAILED TO ACTIVATE, WHICH RESULTED IN A FRONT TIRE SKID AND A SINGLE VEHICLE CRASH. THERE WAS NO INDIC…

Owner-reported narrative. 19,893 miles reported. Look up ODI 10262860 at NHTSA ↗

TL* THE CONTACT OWNS A 2006 BMW K1200R. THE CONTACT STATED THE VEHICLE INDEPENDENTLY SHIFTS OUT OF SECOND GEAR. THE CONTACT STATED THIS FAILURE OCCURS IN SECOND GEAR, BUT THEN THE FAILURE WILL PROGRESS TO INCLUDE THIRD AND FORTH GEAR. THE DEALER STATED THE RODS IN THE TRANSMISSION WERE BENT AND THAT CAUSES THE FAILURE. THE MANUFACTURER WAS AWARE OF THE DEFECT, BUT THERE IS NO REMEDY. THE FAILURE MILEAGE WAS 300 AND THE CURRENT MILEAGE WAS 4,000.

Owner-reported narrative. 300 miles reported. Look up ODI 10419846 at NHTSA ↗

WHILE RIDING THE VEHICLE, A STRONG FUEL SMELL WAS DETECTED. WHILE STOPPING TO INVESTIGATE, THE REAR TIRE LOCKED UP, BUT A CRASH WAS AVOIDED. I FOUND A LARGE VOLUME OF FUEL SPRAYING FROM BOTH SIDES OF THE MOTORCYCLE. THE FUEL CAME IN CONTACT WITH THE ALTERNATOR, THE HOT EXHAUST, AND THE REAR TIRE. BY THE TIME THE IGNITION WAS TURNED OFF TO TURN OFF THE FUEL PUMP, MY PANTS AND BOOTS HAD BEEN SATURATED WITH FUEL. UPON FURTHER INVESTIGATION, I FOUND THE PLASTIC FUEL LINE QUICK DISCONNECT COUPLER FROM THE FUEL PUMP TO THE INJECTOR SUPPLY LINE HAD CR…

Owner-reported narrative. 16,728 miles reported. Look up ODI 10439842 at NHTSA ↗

ABS BRAKE MODULATOR UNIT FAILED ON PANIC STOP. STOPPING DISTANCE WAS SIGNIFICANTLY INCREASED AND NO POWER BRAKING ASSIST WAS AVAILABLE. COLLISION WITH ANOTHER VEHICLE WAS NARROWLY AVOIDED. ABS MODULATOR HAD TO BE REPLACED. COST OF PART IN EXCESS OF $2000 AND 6 HOURS OF LABOR. *TR

Owner-reported narrative. 15,000 miles reported. Look up ODI 10456032 at NHTSA ↗

TL* THE CONTACT OWNS A 2006 BMW K1200 R MOTORCYCLE. THE CONTACT STATED THAT THE ANTI LOCK BRAKING SYSTEM ENGAGED WHEN THE BRAKES WERE APPLIED. THE BRAKES THEN RELEASED MOMENTARILY WHILE THE VEHICLE JERKED FORWARD BEFORE THE MANUAL BRAKES FINALLY ENGAGED. THE FAILURE RECURRED INTERMITTENTLY AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS ADVISED TO DRAIN ALL BRAKING FLUID FROM THE MANUAL BRAKES AND THE ANTI LOCK BRAKES. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE CONTACT WAS THEN INFORMED THAT TH…

Owner-reported narrative. 28,000 miles reported. Look up ODI 10460822 at NHTSA ↗

I RODE BIKE TO WORK AND PARKED IT ON SIDE STAND. AFTER WORK I NOTED A WET SPOT UNDER BIKE BUT COULD NOT DETERMINE IF IT WAS OIL OR GAS. ON THE RIDE HOME I NOTED A PETROLEUM SMELL WHEN AT STOP LIGHTS. I PARKED THE BIKE IN THE GARAGE ON ITS SIDE STAND AND GASOLINE STARTED LEAKING FROM THE LEFT SIDE OF THE BIKE. I CALLED THE DEALER AND RODE IT OVER. UPON PARKING THE BIKE GAS BEGAN TO LEAK AGAIN. THE DEALER CHECKED THE BIKE CONFIRMING A GAS LEAK ORIGINATING IN THE AREA OF THE FUEL INJECTOR/DELIVERY SYSTEM. PARTS HAVE BEEN ORDERED AND IT IS S…

Owner-reported narrative. 16,000 miles reported. Look up ODI 10480052 at NHTSA ↗

I NOTICED PETROLEUM SMELL WHEN AT A STOP LIGHT WHEN RIDING THE BIKE HOME FROM WORK. WHEN I PARKED THE BIKE ON THE SIDE STAND IN THE GARAGE FUEL BEGAN TO LEAK DOWN THE LEFT SIDE OF THE MOTORCYCLE. I IMMEDIATELY CALLED MY BMW MECHANIC WHO INFORMED ME TO RIDE THE BIKE OVER TO THE SHOP FOR INSPECTION. WHEN THE BIKE WAS PARKED AT THE SHOP THE MECHANIC OBSERVED THE FUEL LEAKING FROM THE LEFT SIDE OF THE BIKE. THEY KEPT THE BIKE AND EARLY NEXT WEEK I RECEIVED A CALL THAT THE FUEL PUMP WAS LEAKING GASOLINE. THE REPLACEMENT PRICE WAS 460 PLUS LABOR…

Owner-reported narrative. 16,700 miles reported. Look up ODI 10485783 at NHTSA ↗

Reported: 2006-05-15 (May 15, 2006)

ON CERTAIN MOTORCYCLES, UNDER RAPID, REPEATED, AND UNUSUALLY HARSH BRAKING, LOSS OF ABS CAPABILITY COULD TEMPORARILY OCCUR.

Consequence: TEMPORARY LOSS OF ABS BRAKING COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL ADD A PHYSICAL RESTRICTION, IN THE FORM OF A BANJO BOLT WITH A FLOW RESTRICTOR TO THE BRAKE LINE, AND ON CERTAIN MODELS DEALERS WILL INSTALL NEW FRONT BRAKE DISCS OF A SLIGHTLY LARGER THICKNESS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 5, 2006, AND WILL BE A PHASED MAILING THROUGH OCTOBER 2006. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Reported: 2007-02-23 (February 23, 2007)

ON CERTAIN MOTORCYCLES, FREQUENT SHORT TRIPS PARTICULARLY DURING COLD TEMPERATURES, CAN CAUSE WATER TO ACCUMULATE IN THE OIL TANK, AND WHEN THE ENGINE IS RUNNING, ESCAPING WATER VAPOR CAN CONDENSE ON THE OIL TANK AIR BLEED VALVE. IN FREEZING TEMPERATURES, THIS WATER COULD FREEZE AND BLOCK THE AIR BLEED VALVE.

Consequence: IT IS POSSIBLE THAT A PRESSURE BUILD UP IN THE OIL TANK COULD CAUSE IT TO RUPTURE, ALLOWING OIL TO LEAK ONTO THE REAR TIRE. AN OIL LEAK COULD CAUSE A FIRE. OIL ON THE REAR TIRE COULD CAUSE LOSS OF CONTROL.

Remedy: DEALERS WILL INSTALL A NEW OIL TANK CAP CONTAINING A VALVE TO PREVENT OVERPRESSURE IN THE TANK FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Reported: 2010-10-08 (October 8, 2010)

BMW IS RECALLING CERTAIN MODEL YEAR 2005-2011 MOTORCYCLES. THE BEARINGS COULD BE SUBJECT TO CORROSION. THIS COULD LEAD TO REDUCED MOVEMENT OF THE LINK LEVER.

Consequence: THIS COULD AFFECT THE HANDLING OF THE MOTORCYCLE INCREASING THE RISK A DRIVER MAY LOSE CONTROL OF THE VEHICLE RESULTING IN A CRASH.

Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Reported: 2020-08-10 (August 10, 2020)

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.