2009 Bmw F 800 GS: complaints, problems and recalls

REAR WHEEL BEARING DETERIORATION AT 12,000 MILES ON A BMW F800GS. RIDING UNDER NORMAL CIRCUMSTANCES. CHECK THE BEARING AFTER READING AN INTERNET POST ABOUT SEVERAL OTHER PEOPLE WITH THE SAME MAKE AND MODEL HAVING BEARING FAILURES. THE BEARING FELT PITTED AND GRITTY. I TOOK IT TO THE DEAL AND THEY REPLACED THEM UNDER WARRANTY WITH FACTORY PARTS. UNCHECKED THIS WOULD HAVE MOST LIKELY LEAD TO A CATASTROPHIC FAILURE WITH POSSIBLE INJURY OR DEATH. *TR

Owner-reported narrative. 11,000 miles reported. Look up ODI 10289384 at NHTSA ↗

I HAD THE REAR WHEEL BEARINGS ON MY 2009 BMW F800GS MOTORCYCLE CHECKED DURING ITS ROUTINE 6,000 MILE SERVICE. THE BEARINGS ON MY BIKE SHOWED EVIDENCE OF ACCELERATED WEAR. THEY WERE REPLACED BY THE BMW SHOP, UNDER WARRANTY. ONE WOULD EXPECT SUCH BEARINGS TO LAST A _MINIMUM_ OF 50,000 MILES, AND SO FAILURE WITH SO LITTLE MILEAGE WAS UTTERLY UNEXPECTED. ON A MOTORCYCLE, REAR WHEEL BEARING FAILURE AT SPEED COULD LEAD TO LOSS OF CONTROL OF THE VEHICLE, RESULTING IN INJURY OR DEATH TO THE OPERATOR. *TR

Owner-reported narrative. 6,356 miles reported. Look up ODI 10289703 at NHTSA ↗

AFTER 9000 MILES THE CLUTCH ON MY 2009 F800GS SUDDENLY STARTED TO SLIP ON THE FREEWAY WHEN DOWNSHIFTING AND ACCELERATING. THERE WAS NO PREVIOUS SYMPTOMS OF ANY PROBLEMS IN THE DRIVE TRAIN/CLUTCH APART THAT THE ADJUSTMENT OF THE CLUTCH WAS TO THE LAST LIMIT (ALL SERVICE DONE BY BMW DEALER). SINCE THEN ANY ACCELERATION MAKES THE RPM JUMP 1000+ RPM BEFORE GRADUALLY COMING DOWN AND ACTUAL ACCELERATION OCCURRING. THIS CAN BE A SAFETY PROBLEM AS A LOSS OF ACCELERATION CAN LEAD TO AN ACCIDENT OR DEATH ON A MOTORCYCLE. *TR

Owner-reported narrative. 8,950 miles reported. Look up ODI 10320268 at NHTSA ↗

WHEEL BEARING ON CHAINRING SIDE OF REAR HUB WORE OUT PREMATURELY AT 9,000 MILES. OTHER BEARINGS ON FRONT AND REAR HUBS WERE FUNCTIONING WELL. HAD I NOT CHECKED THIS BEARING, AFTER READING ABOUT MULTIPLE SUCH INCIDENTS, CATASTROPHIC FAILURE COULD HAVE OCCURRED WHILE TRAVELING AT FREEWAY SPEED LEADING TO PERSONAL INJURY AND POTENTIALLY INJURY TO OTHERS. *TR

Owner-reported narrative. 9,000 miles reported. Look up ODI 10330369 at NHTSA ↗

TL* THE CONTACT OWNS A 2009 BMW F800 GS MOTORCYCLE. WHILE TRAVELING 75 MPH, THE CONTACT ATTEMPTED TO DOWNSHIFT FROM SIXTH TO FIFTH GEAR AND THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE COMPUTER WAS UPDATED. THE FAILURE RECURRED FOLLOWING REPAIRS. THE DEALER THEN PERFORMED A SECOND COMPUTER SOFTWARE UPDATE TO CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 2,200 AND THE CURRENT MILEAGE WAS 4,200.

Owner-reported narrative. 2,200 miles reported. Look up ODI 10351946 at NHTSA ↗

THROTTLE RESPONSE IS TOO SHARP AND TAKES YOU BY SURPRISE WITHOUT WARNING DURING NORMAL OPERATION. THIS RESPONSE CAN BE RAPID ACCELERATION OR DECELERATION WHEN A DEFORMITY IN THE ROAD IS DRIVEN OVER. THE RAPID RESPONSE IS EVEN MORE EXACERBATED AT LOW SPEEDS WHEN TRYING TO MANEUVER RESIDENTIAL SURFACE ROADS. I HAVE TAKEN THE VEHICLE TO THE DEALER WITH NO KNOWN REPAIRS. I HAVE HAD A COMPUTER SOFTWARE UPGRADE TO NO AVAIL. I HAVE SEARCHED MANY ADVENTURE TYPE FORUMS WHERE MANY PEOPLE ARE HAVING THE SAME PROBLEMS WITH NO KNOWN REPAIR FROM THE FAC…

Owner-reported narrative. 600 miles reported. Look up ODI 10410935 at NHTSA ↗

THE STATOR OF THE ALTERNATOR FRIED, SO THE BATTERY STARTED DISCHARGING AND WHEN EMPTY THE COMPUTER AND THE ENGINE STALLED. I HAD THE STATOR REWINDED AND THE SAME PROBLEM REPEATED 5000 MILES LATER. I HAD IT REWINDED A SENCOND TIME AND IT HAPPENED AGAIN. I AM INTO MY 3RD REWIND AND JUST EXPECTING THE PROBLEM TO REAPPEAR...

Owner-reported narrative. 21,126 miles reported. Look up ODI 10458740 at NHTSA ↗

STATOR / FLYWHEEL NO LONGER CHARGING BATTERY. RAN ON BATTERY POWER UNTIL ENGINE QUIT ON FREEWAY AT 65 MPH. COASTED TO SHOULDER AND WAITED FOR TOW. 2ND TIME THIS HAPPENED. FIRST TIME AT 28,000 MILES. *TR

Owner-reported narrative. 39,040 miles reported. Look up ODI 10587345 at NHTSA ↗

Reported: 2009-03-18 (March 18, 2009)

BMW IS RECALLING 754 MY 2009 F800 GS VEHICLES. THE AXLE SHAFT WALL THICKNESS MAY NOT HAVE BEEN MANUFACTURED ACCORDING TO SPECIFICATIONS.

Consequence: IF THE WALL THICKNESS WAS NOT SUFFICIENT, THE AXLE SHAFT COULD DEFORM AND COULD BREAK INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE FRONT WHEEL QUICK-RELEASE AXLE AND REPLACE IT WITH AN IMPROVED AXLE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Reported: 2009-12-30 (December 30, 2009)

BMW IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 F650 GS AND F800 GS MOTORCYCLES MANUFACTURED BETWEEN JANUARY 2008 AND DECEMBER 2009. DURING ENGINE OPERATION, A VACUUM IS CREATED IN ORDER TO DRAW FRESH AIR INTO THE CANISTER. THIS AIR THEN MIXES WITH THE FUEL VAPORS CAPTURED BY THE CANISTER, AND IS SUBSEQUENTLY COMBUSTED. DUE TO THE ROUTING OF THE VENTILATION HOSE, WATER NEAR THE END OF THE HOSE COULD BE DRAWN INTO THE CHARCOAL CANISTER.

Consequence: WATER COULD FLOW INTO THE CANISTER CAUSING A STALLING CONDITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND ADD AN ADDITIONAL HOSE AND ROUTE IT SUCH THAT THE PRESENT DEFECT IS PREVENTED. THIS REMEDY WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 13, 2010. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Reported: 2010-06-16 (June 16, 2010)

BMW IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 F650 GS AND F 800 GS MOTORCYCLES MANUFACTURED FROM SEPTEMBER 27, 2007 THROUGH MARCH 30, 2009. THE DRIVE CHAINS MAY NOT HAVE BEEN PRODUCED TO SPECIFICATION. AS A RESULT, OVER TIME THE DRIVE CHAIN COULD BREAK.

Consequence: IF THE BROKEN CHAIN BECOMES TRAPPED BETWEEN THE REAR WHEEL AND THE FRAME, THE REAR WHEEL COULD LOCK UP, POSSIBLY RESULTING IN A CRASH.

Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE DRIVE CHAIN AND SPROCKETS ON THE AFFECTED MOTORCYCLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 30, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.