2022 Bmw 840I: complaints, problems and recalls

The Gear Shift area flawed design and defective assembly allows fluid spill to short out transmission and shifting ability. Assembly is not sealed correctly which allows a spilled fluid to leak through the gearshift on and into the the GWS. The GWS was not sealed causing a short in the the assembly & the need for its replacement at substantial cost to the owner. The drink holder is place next to gearshift area with no consideration that spilled fluid will cause the car to shut down and the GWS replacement. 06/21/2022

Owner-reported narrative. Look up ODI 11471107 at NHTSA ↗

Safety was compromised by drivetrain instability and a federal recall involving a starter motor defect that poses a fire risk. Despite this, BMW of Arlington has refused to authorize repairs or allow BMW of Austin to complete the necessary work, even after a $13,565 drivetrain failure diagnosis. On October 4, 2025, our 2022 BMW 840i became inoperable due to worn splines in the rear differential and drive shaft. BMW of Austin confirmed the failure was consistent with prior service-induced damage. The component is available for inspection. The iss…

Owner-reported narrative. Look up ODI 11694669 at NHTSA ↗

The contact owns a 2022 BMW 840I. The contact stated that while driving at 5 MPH, the vehicle stalled unexpectedly. There were no warning lights illuminated. The vehicle was blocking the garage. The contact received notification of NHTSA Campaign Number: 25V644000 (Electrical System). The local dealer was contacted regarding a loaner vehicle, but no assistance was provided. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the part for the recall repair was not yet available. There was no ETA for parts…

Owner-reported narrative. 59,000 miles reported. Look up ODI 11700556 at NHTSA ↗

Customer filing a complaint against BMW for untimely resolution of Recall #25V644. This recall is a known Safety Risk which began in the summer of 2025. It is now December 4, 2025, and discussions today with BMW North America, they cannot provide me an ETA of when parts will be available for my vehicle. Further info from BMW North America says they will mail me a letter sometime? in 2026 to tell me when parts are available but if I have electrical heating/smoke issues before that to take the car to the BMW Dealer. BMW appears to be pretty non…

Owner-reported narrative. Look up ODI 11702940 at NHTSA ↗

In September 2025, BMW issued a recall # 25V644 for a safety related potential fire issue on the starter for my 2022 840i Gran Coupe. It has now been 4 months, and BMW is still telling me they do not have the assigned parts to resolve this issue. Furthermore, NHTSA has somehow dropped this recall off the records for the VIN of my car, which is troubling. My compliant is BMW is not timely in their efforts to correct a safety fire issue for my vehicle.

Owner-reported narrative. Look up ODI 11713303 at NHTSA ↗

The contact owns a 2022 BMW 840I. The contact received notification of NHTSA Campaign Number: 25V644000 (Electrical System) in 2025. The contact had been working with the local dealer and was informed that parts were not available for the recall repair. The contact called the manufacturer and was informed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

Owner-reported narrative. Look up ODI 11731178 at NHTSA ↗

Drive Shaft Failed a second time within a year. This time they are saying the Differential stripped it this time. Both incidents i was on highway and car completed stalled out of the randomly no warning or alerts both times on interstate. BMW just provided services to my car i had front brakes replaced, oil change and open recall of starter repaired. Everything checked out to be good along with drive shaft and differential. Now they need replaced per BMW.

Owner-reported narrative. Look up ODI 11750305 at NHTSA ↗

Reported: 2025-09-25 (September 25, 2025)

BMW of North America, LLC (BMW) is recalling certain 2020 340I, X6, 2020-2025 840I, 2020-2022 740LI, 2019-2020 X7, and X5 vehicles. After repeated attempts, the starter motor may overheat from an electrical overload.

Consequence: An overheated starter motor can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.

Remedy: Dealers will replace the engine starter, free of charge. This recall includes vehicles repaired under recall 24V576 and those owners will need to have their vehicle repaired again. Owner notification letters were mailed February 9, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 17, 2025.

Reported: 2026-08-12 (August 12, 2026)

BMW of North America, LLC (BMW) is recalling certain 2022-2026 840i, 840i xDrive, 2021-2023 540i, 540i xDrive, M550i xDrive, and 2024-2026 750e xDrive vehicles. The connection between the driveshaft and the rear differential may become damaged, possibly resulting in a loss of power to the rear wheels or a vehicle rollaway.

Consequence: An unexpected loss of drive power can increase the risk of a crash. In addition, a damaged driveshaft can result in a vehicle rollaway if the parking brake is not applied, increasing the risk of a crash or injury.

Remedy: Dealers will inspect the connection between the driveshaft and rear axle differential, and apply adhesive or replace the driveshaft and rear axle differential, as necessary, free of charge. Owner notification letters are expected to be mailed October 2, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning October 2, 2026.