2010 Bmw 5 SERIES: complaints, problems and recalls

THIS IS THE SECOND TIME THIS PARTICULAR PROBLEM HAPPENED. THE FIRST TIME THE CAR LOST POWER WHEN REVS WENT UP ABOVE 3.5K RPM AND RECOVERED AS SOON AS REVS FELL BELOW THIS RANGE. THIS ALMOST RESULTED IN AN ACCIDENT SINCE THE DRIVER BEHIND ME WAS TAKEN BY SURPRISE WITH THE ABRUPT REDUCTION IN SPEED. I TOOK THE CAR TO BMW FOR SERVICE AND THEY REPORTED IT HAD BEEN FIXED. THE SECOND INCIDENT OCCURRED WHILE DRIVING AT 60MPH ON THE LEFTMOST LANE OF A THREE LANE HIGHWAY. THE CAR COMPLETELY LOST POWER AND A WARNING WAS DISPLAYED INDICATING: "ENGINE MALF…

Owner-reported narrative. 10,000 miles reported. Look up ODI 10369896 at NHTSA ↗

AIR BAG WARNING LIGHT ILLUMINATES WITH ADULT PASSENGER FIRMLY BELTED INTO PASSENGER SEAT. LIGHT REMAINS ILLUMINATED FOR PERIODS WHICH VARY FROM 5 MINUTES TO 30 MINUTES. THERE IS NO WAY TO TELL IF THIS IS A DEFECTIVE LIGHT ONLY OR IF THE AIR BAG IS INOPERATIVE. AN ADDITIONAL SAFETY CONCERN IS THAT BMW DIAGNOSTIC TECHNIQUES ARE NOT ABLE TO DETECT THIS FAILURE. BMW REFUSES TO CORRECT THE DEFECT.

Owner-reported narrative. 5,000 miles reported. Look up ODI 10370053 at NHTSA ↗

WHEN THE TEMPERATURE HITS 100 DEGREES AS IT DOES IN THE DESERT 5 MONTHS OR SO PER YEAR, THE INTERIOR CABIN FILLS UP WITH VERY HARMFUL GAS FUMES. WE OWNED A 2008 AND THE SAME SITUATION. AS A RESULT OF THIS AND PROBLEMS WITH THE FUEL PUMP ON THE 2008, THE DEALERSHIP BOUGHT THE CAR BACK. MY HUSBAND REALLY WANTED ANOTHER BMW AND WHEN HE WAS LOOKING AT BUYING THE 2010 HE WAS TOLD ALL THE PROBLEMS INCLUDING THE GAS FUMES HAD BEEN RESOLVED. NOT SO. THE CAR HAS BEEN BACK TO SERVICE TWICE FOR THE GAS FUMES AND NO ONE CAN SHED ANY LIGHT ON THE SITUA…

Owner-reported narrative. Look up ODI 10415863 at NHTSA ↗

I WAS TRAVELING ON FREEWAY TO THE AIRPORT WHEN MY WIFE AND I HEARD A LOUD BOOM AND SUDDENLY HEARD LOUD AIRFLOW. I PULLED OFF TO SIDE OF ROAD AND INSPECTED CAR. THE SUNROOF HAD EXPLODED AND SHATTERED. THE CAR TRAVELING BEHIND ME ALSO STOPPED TO INSPECT HIS VEHICLE BECAUSE OF FLYING GLASS. THE CABIN DOOR TO THE SUNROOF HAD LUCKILY HAD BEEN CLOSED SO AS MY WIFE AND I AVOIDED THE FLYING GLASS. WHEN WE RETURNED FROM OUR TRIP I TOOK VEHICLE TO DEALER, THE VEHICLE WAS UNDER WARRANTY. THE DEALER SAID THIS PART WAS NOT COVERED AND WOULD COST $3600 TO RE…

Owner-reported narrative. 53,000 miles reported. Look up ODI 10617626 at NHTSA ↗

ON SUNDAY 12/03 I SUDDENLY HEARD A KNOCKING NOISE WHILE ACCELERATING AND IMMEDIATELY REACHED THE DEALERSHIP TO HAVE THE CAR CHECKED. THE DIAGNOSIS I RECEIVED IS THAT THERE HAS BEEN A FATAL FAILURE OF BEARING THAT CAUSE THE ENGINE TO GET DAMAGED AND IN NEED TO BE REPLACED. I LOOKED UP ON THE WEB AND FOUND OUT THAT IN 2014 BMW HAD A WORLDWIDE RECALL OF 2010 5 SERIES MODELS FOR A DEFECT IN THE ENGINE WHICH WOULD HAVE GENERATED THE SAME FAILURE I HAVE EXPERIENCE, SUDDENLY, ON SUNDAY. MY CAR WAS NEVER RECALLED, BUT THE FAILURE MODE AND THE YEAR OF…

Owner-reported narrative. 130,000 miles reported. Look up ODI 11056120 at NHTSA ↗

CAR STALLS AT HIGH SPEED, FUEL PUMP WARNINGS LIGHT COMES ON. CAR WILL RESET AFTER 30 MINS BUT WILL CONTINUE TO SHUT OFF DURING DRIVING. BOTH FUEL PUMPS HAVE BEEN REPLACED

Owner-reported narrative. 130,000 miles reported. Look up ODI 11220713 at NHTSA ↗

Reported: 2010-07-22 (July 22, 2010)

BMW IS RECALLING CERTAIN 2010 AND 2011 5-SERIES AND 5-SERIES GRAN TURISMO PASSENGER VEHICLES MANUFACTURED FROM JANUARY 12 THROUGH JULY 1, 2010. THE VEHICLE'S FUEL LEVEL SENSOR WITHIN THE FUEL TANK CAN BECOME WEDGED AGAINST THE TANK.

Consequence: IF THIS OCCURS, THE FUEL GAUGE IN THE INSTRUMENT CLUSTER WOULD DISPLAY A LARGER AMOUNT OF FUEL THAN WAS ACTUALLY IN THE TANK. AS A RESULT, IF THE TANK BECAME EMPTY, THE VEHICLE COULD STALL INCREASING THE RISK OF A CRASH.

Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 18, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Reported: 2010-10-01 (October 1, 2010)

BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, 6-SERIES, AND MODEL YEAR 2002-2008 7-SERIES VEHICLES. A CHECK VALVE OF THE BRAKE VACUUM PUMP MAY LEAK A SMALL AMOUNT OF LUBRICATING OIL. OVER TIME THIS COULD RESULT IN CONTAMINATION OF THE BRAKE BOOSTER.

Consequence: POWER ASSIST BRAKING PERFORMANCE COULD BE ADVERSELY AFFECTED. IN EXTREME CASES THERE COULD BE A COMPLETE LOSS OF POWER ASSIST BRAKING. AN UNEXPECTED REDUCTION OR LOSS IN POWER BRAKING ASSIST MAY INCREASE THE RISK OF A CRASH.

Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 24, 2010. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Reported: 2012-03-26 (March 26, 2012)

BMW IS RECALLING CERTAIN MODEL YEAR 2004-2010 5-SERIES, MODEL YEAR 2004-2010 6-SERIES, MODEL YEAR 2006-2010 M5, AND MODEL YEAR 2007-2010 M6 VEHICLES. THE INSULATED BULKHEAD CONNECTOR FOR THE POSITIVE BATTERY CABLE MAY HAVE BEEN INCORRECTLY ATTACHED TO THE TRUNK FLOOR PANEL, WHICH CAN LEAD TO A LOOSENING OF THE BOLT CONNECTION. AS IT LOOSENS, AN INCREASE IN ELECTRICAL RESISTANCE AT THIS CABLE CONNECTION IS POSSIBLE AND COULD CAUSE THE CABLE CONNECTION TO OVERHEAT.

Consequence: OVERHEATING COULD LEAD TO A FIRE, EVEN WHILE THE VEHICLE IS NOT IN USE. AS A PRECAUTION, OWNERS ARE ADVISED TO PARK OUTSIDE UNTIL THE REMEDY HAS BEEN MADE.

Remedy: BMW WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND SECURE THE BATTERY BOLT CABLE CONNECTION AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2012. OWNERS MAY CONTACT BMW CUSTOMER RELATIONS AND SERVICES AT 1-800-525-7417.

Reported: 2022-03-02 (March 2, 2022)

BMW of North America, LLC (BMW) is recalling certain 2008-2013 1 Series Coupe (128i); 2007-2013 3 Series Coupe (328i, 328xi, 328i xDrive); 2007-2010 X3 SAV (X3 3.0si, X3 xDrive30i); 2008-2013 1 Series Convertible (128i); 2006-2011 3 Series Sedan (325i, 325xi, 328i, 328xi, 328i xDrive, 330i, 330xi); 2006-2012 3 Series Wagon (328i, 328i xDrive); 2007-2013 3 Series Convertible (328i); 2006-2010 5 Series Sedan (525i, 525xi, 528i, 528xi, 530i, 530xi); 2006-2007 5 Series Wagon (530xi); 2007-2010 X5 SAV (X5 3.0si, X5 xDrive30i); 2006-2008 Z4 Coupe (Z4 3.0si); and 2006-2011 Z4 Roadster (Z4 3.0i, Z4 3.0si, Z4 sDrive30i) vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.

Consequence: An electrical short can cause the PCV valve heater to overheat, increasing the risk of a fire while driving or, soon after driving when parked.

Remedy: This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Dealers will install an electrical wiring harness with fuse protection for the PCV Valve heater in potentially affected vehicles, free of charge. This recall supersedes and expands previous NHTSA recalls 17V-683 and 19V-273. Vehicles previously repaired under the prior recalls will need to come back for the new recall remedy. The remedy is currently being developed. Interim owner notification letters informing owners of the safety risk were mailed on April 1, 2022. Owner notification letters were mailed on July 22, 2022. Owners may contact BMW customer service at 1-800-525-7417.

Reported: 2023-10-20 (October 20, 2023)

BMW of North America, LLC (BMW) is recalling certain 2010-2012 1 Series Coupe, 1 Series Convertible, 3 Series Sedan, 3 Series Convertible, 2010-2011 3 Series Sportswagon, 3 Series Coupe, 5 Series Sedan, X3 xDrive 28i, X3 xDrive 30i, X5 xDrive30i, and Z4 sDrive30i vehicles. The aluminum bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and possibly break.

Consequence: Loose or broken VANOS unit bolts can result in an engine stall, increasing the risk of a crash.

Remedy: Dealers will replace the four VANOS bolts, free of charge. Interim letters notifying owners of the safety risk are expected to be mailed December 18, 2023. Owner notification letters were mailed June 19, 2024. Owners may contact BMW customer service at 1-800-525-7417.