2012 Audi A3: complaints, problems and recalls

CPSC: I1360446A. 2012 AUDI A3 WAGON. CONSUMER STATED THE GAS PEDAL AND BRAKES ARE TOO CLOSE TOGETHER. ALSO STATES CANNOT GET FOOT OFF GAS WITHOUT GETTING CAUGHT ON THE BRAKE IF IN AN EMERGENCY SITUATION. *LN

Owner-reported narrative. Look up ODI 10531474 at NHTSA ↗

TRAVELING AT SPEED ON THE INTERSTATE WHEN THE GLOW PLUG LIGHT WARNING INDICATOR STARTED FLASHING ON THE DASH. CAR INSTANTLY BECAME INOPERABLE. LUCKILY WAS APPROACHING AN EXIT AND ATTEMPTED TO EXIT THE INTERSTATE. THE CAR DIED ON THE RAMP AND WOULD NOT RESTART. CALLED A TOW TRUCK TO HAUL THE CAR TO AUDI OF LEXINGTON. SERVICE EXAMINED THE VEHICLE THE NEXT MORNING. TO MY WITNESS, THE FUEL FILTER CANISTER AND THE TOP SIDE OF THE HIGH PRESSURE FUEL PUMP APPEARED TO BE FULL OF METAL. THE SERVICE REQUIRED IS A COMPLETE FUEL SYSTEM REPLACEMENT F…

Owner-reported narrative. 52,400 miles reported. Look up ODI 10608827 at NHTSA ↗

THE F16 FUSE WHICH IS RECALLED ON THE VW SIDE MELTED, CAUSING THE SMELL OF BURNT PLASTIC AND EXTERIOR LIGHTS GOING OUT WHILE DRIVING ON THE INTERSTATE AT NIGHT. THE DEALER ON TOP IF THIS REFUSES TO ACKNOWLEDGE THIS ISSUE, AND WILL NOT PROPERLY FIX THE CAR. I REPLACED THE FUSE WITH ANOTHER, THE RECALL ON THE VW SIDE IS 13V569000, AOA CLAIMS THEY DO NOT HAVE THIS PROBLEM, VW REDESIGNED THE FUSE PANELS IN ITS 2012 GOLF/TIGUAN/JETTA, BUT THE AUDI A3 STILL USES THE EXACT SAME FUSE AND FUSE PANEL AS THE MODELS ON THE RECALL LIST AND TSB LIST. *TR

Owner-reported narrative. 40,750 miles reported. Look up ODI 10682609 at NHTSA ↗

LOSS OF POWER AT SPEED IN TRAFFIC DUE TO A HIGH PRESSURE FUEL PUMP FAILURE, JUST AVOIDING A SERIOUS ACCIDENT. I WAS TOLD IT WAS CAUSED BY EITHER INCORRECT/CONTAMINATED FUEL OR INCORRECT OIL BY THE DEALER SERVICE DEPARTMENT. I HAVE USED ONLY DIESEL FUEL FROM NATIONAL STATIONS, HAVE NEVER USED BIO DIESEL AND HAVE USED THE CORRECT AUDI APPROVED OIL. THIS IS APPARENTLY A WIDE SPREAD ENGINEERING ISSUE THAT HAS NOW DICTATED THE COMPLETE FUEL SYSTEM REPLACEMENT ON THIS VEHICLE (AND NUMEROUS OTHERS) AT A SIZABLE COST WITH NO GUARANTEE THAT IT WILL NO…

Owner-reported narrative. 71,000 miles reported. Look up ODI 10694181 at NHTSA ↗

WHILE DRIVING AT 40 MPH ON EVENING ON APRIL 16, 2015, THE ENGINE NOISE WAS NOTICEABLY MORE PRONOUNCED. ONE MILE FURTHER, A FLASHING GLOW PLUG LIGHT ILLUMINATED FOLLOWED BY A DRAMATIC LOSS OF POWER (LIMITED TO 25 MPH). DROVE REMAINING SHORT DISTANCE HOME AT A LOW SPEED DUE TO ENGINE FAILURE. AFTER TOWING VEHICLE TO AUDI DEALERSHIP THE NEXT MORNING, TECHNICIAN REPORTED THAT THE HIGH PRESSURE FUEL PUMP HAD DISINTEGRATED AND SENT METAL SHAVINGS THROUGHOUT THE ENTIRE FUEL SYSTEM REQUIRING COMPLETE REPLACEMENT OF ALL FUEL SYSTEM COMPONENTS. *TR

Owner-reported narrative. 68,884 miles reported. Look up ODI 10711857 at NHTSA ↗

WHILE DRIVING AT 50MPH, AN MIL INDICATOR ILLUMINATED ON THE DASHBOARD. A CONSISTENT CHANGE IN POWER OR DRIVABILITY WAS NOT EXPERIENCED IMMEDIATELY, BUT INTERMITTENT MOMENTS OF SLIGHT POWER LOSS WERE NOTICED (1 SECOND DROP IN POWER) DURING BOTH CRUISE OR ACCELERATION DURING THE REMAINING DRIVE HOME AFTER THE LIGHT ILLUMINATED. WHEN I ARRIVED HOME, I INSPECTED THE ENGINE FOR ANY OBVIOUS SIGNS SUCH AS DISCONNECTED OR LOOSE ELECTRICAL CONNECTIONS, OIL LEVEL, ETC. I DID FIND A POOL OF OIL ON TOP OF THE CYLINDER HEAD POOLING AROUND THE INJECTOR PORTS…

Owner-reported narrative. 71,000 miles reported. Look up ODI 10732364 at NHTSA ↗

WHILE DRIVING MY LIGHTS WOULD RANDOMLY GO OUT BOTH DURING DAY AND NIGHT. DASH WARNING WOULD BE BULB OUT NEEDING REPLACING BUT NOTHING WAS EVER WRONG WITH THE BULBS OR TURN SIGNALS. ISSUE WAS INTERMITTENT AND WARNING WOULD GO AWAY ON IT'S OWN OR AFTER CAR RESTARTED. LATER WHEN DASH WARNING CAME ON AND STAYED ON I TOOK IT INTO SERVICE WHICH LATER WAS DIAGNOSED TO BE A MELTED FUSE BOX PANEL ON F16 & F17. BOTH FUSE SLOTS WERE MELTED ALONG WITH F16 FUSE (15AMP) AND BURN MARKS ALONG THE HOUSING. THE DEALERSHIP REPAIRED IT BUT WOULD NOT COVER THE REPA…

Owner-reported narrative. 50,209 miles reported. Look up ODI 10790335 at NHTSA ↗

AFTER STARTING THE CAR AND DRIVING ABOUT 50 FEET, THE VEHICLE DRIVER DISPLAY SCREEN SIGNALED THAT MULTIPLE EXTERIOR LIGHTS HAD FAILED SIMULTANEOUSLY. SENSING THAT MULTIPLE LIGHT BULBS WOULD NOT FAIL AT ONCE UNLESS THERE WAS A LARGER ELECTRICAL PROBLEM, I PROMPTLY MADE AN APPOINTMENT AT THE LOCAL AUDI SERVICE CENTER THE NEXT DAY. AFTER DIAGNOSIS BY AUDI TECHNICIANS, I LEARNED THAT THE FUSE BOX UNDER THE HOOD HAD MELTED DUE TO OVERLOAD OF CIRCUITS OR WIRING IN THE BOX. HAD I NOT TAKEN THE CAR IN FOR REPAIR, THE OVERLOAD COULD HAVE CAUSED A FIRE I…

Owner-reported narrative. 84,700 miles reported. Look up ODI 10853652 at NHTSA ↗

Reported: 2011-10-03 (October 3, 2011)

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Reported: 2016-02-10 (February 10, 2016)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2006 Volkswagen Passat sedans and wagons, 2005-2013 Audi A3, and 2006-2009 Audi A4 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. The recall began March 2017. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.

Reported: 2018-01-30 (January 30, 2018)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2006-2013 Audi A3, 2007-2009 A4 Cabriolet and S4 Cabriolet, 2008 RS4 Cabriolet, 2009-2012 Q5, and 2010-2012 Audi A5 Cabriolet and S5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Audi will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began February 23, 2018. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 69R6. Note: This recall partially supersedes recall 16V-078.

Reported: 2019-12-04 (December 4, 2019)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2015 Passat, 2011-2014 Golf A6, and 2011-2013 Audi A3 diesel vehicles, thought to have been previously repaired under one of the Takata air bag recalls. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Volkswagen will notify owners, and dealers will replace the driver's side air bag inflators, free of charge. The recall began December 20, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69R6, 69Q8, 69Q9, and 69Y5.