Ultimate FREEDOM recalls by model year

Reported: 2002-12-03 (December 3, 2002) · Model years: 1996, 1997, 1998, 1999, 2000

CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 442, 443, 452, EV452, 453, 462, EV462, 463, EV463, 482, EV482, 483, EV483, 874, AND 875. THESE REFRIGERATORS CAN EXPERIENCE A BREAK DOWN IN A RUBBER SEAL WITHIN THE GAS VALVE. AS THE RUBBER SEAL AGES, A LEAK MAY OCCUR, ALLOWING PROPANE GAS TO ACCUMULATE IN THE BURNER AREA.

Consequence: THE CONSEQUENCE CAN RESULT IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy: NORCOLD WILL NOTIFY ITS CUSTOMERS AND PROVIDE A REPLACEMENT GAS VALVE FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT NORCOLD SERVICE CENTER AT 1-800-667-3005 OR WINNEBAGO AT 641-585-3535.

Reported: 2001-04-30 (April 30, 2001) · Model years: 1997, 2001

VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.

Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.

Remedy: DEALERS WILL INSPECT THE LAP BELTS AND, IF NECESSARY, REPLACE IT WITH A NEW BELT ASSEMBLY. OWNER NOTIFICATION BEGAN MAY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE AT 1-219-266-8330 OR WINNEBAGO AT 1-641-585-6939.

Reported: 2000-12-04 (December 4, 2000) · Model years: 1998

VEHICLE DESCRIPTION: MOTOR HOMES. THE FRONT AXLE AND/OR FRONT TIRES CAN ENCOUNTER UNEQUAL SIDE-TO-SIDE LOADING DUE TO INAPPROPRIATE LOADING OR THE VEHICLE'S LEVELING DEVICE BECOMING IMPROPERLY ADJUSTED.

Consequence: SHOULD THIS OCCUR, ONE OR MORE OF THE FRONT AXLE COMPONENTS COULD FAIL INCREASING THE RISK OF A CRASH OR PERSONAL INJURY.

Remedy: DEALERS WILL CORRECT THIS OVERLOADING CONDITION BY REPLACING DEFECTIVE COMPONENTS INCLUDING TIRES, WHERE NECESSARY.

Reported: 2000-10-13 (October 13, 2000) · Model years: 2001

VEHICLE DESCRIPTION: CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.

Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.

Remedy: DEALERS WILL INSPECT AND REPLACE THE DEFECTIVE BUCKLE ASSEMBLIES.

Reported: 2002-07-12 (July 12, 2002) · Model years: 2002

ON CERTAIN MOTOR HOMES, THE HYDRAULIC LINES FOR THE BEDROOM SLIDEOUT MAY BE ROUTED ADJACENT TO THE ENGINE EXHAUST. THE TEMPERATURE OF THE EXHAUST COULD DEGRADE THE HOSE TO THE POINT A LEAK COULD DEVELOP.

Consequence: IF A LEAK WERE TO OCCUR, HYDRAULIC FLUID COULD SPRAY ON TO HOT EXHAUST OR ENGINE COMPONENTS AND COULD IGNITE RESULTING IN A FIRE.

Remedy: DEALERS WILL REPLACE AND CORRECTLY ROUTE THE HYDRAULIC LINES. OWNER NOTIFICATION BEGAN AUGUST 9, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.

Reported: 2003-03-17 (March 17, 2003) · Model years: 2003

ON CERTAIN MOTORHOMES EQUIPPED WITH INTERNATIONAL THERMAL RESEARCH (ITR)HURRICANE HOT WATER HEATERS, THE ELECTRONIC CONTROL BOARD MAY ADVERSELY AFFECT SAFETY FEATURES IN SOME OF THE SYSTEMS PROTECTING AGAINST OVERHEATING AND POTENTIAL FIRE SITUATION.

Consequence: IF THE SAFETY FEATURES DO NOT SHUT DOWN PROPERLY, THE HEATING SYSTEM CAN CONTINUE HEATING, POSSIBLY RESULTING IN A FIRE.

Remedy: THE DEFECTIVE ELECTRONIC CONTROL BOARD WILL BE REPLACED. IN THE MEANTIME, CUSTOMERS SHOULD TURN THE SYSTEM OFF USING THE MASTER ON/OFF SWITCH LOCATED ON THE SIDE OF THE ELECTRONIC CONTROL BOX WHICH IS ADJACENT TO THE HEATER. OWNERS WHO TAKE THEIR MOTORHOMES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ITR AT 1-800-755-1272 OR AT WINNEBAGO AT 1-641-585-3535.

Reported: 2004-01-06 (January 6, 2004) · Model years: 2004

ON CERTAIN MOTORHOMES BUILT ON SPARTAN CHASSIS, THE ANGLE OF THE HOSES FROM THE HYDRAULIC PUMP COULD CONTACT THE POSITIVE STUD ON THE STARTER.

Consequence: THIS COULD RESULT IN CLOSE CONTACT WITH THE STARTER AND CAUSE IGNITION OF HYDRAULIC FLUID WHICH COULD RESULT IN INJURY AND/OR PROPERTY DAMAGE.

Remedy: SPARTAN IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPLACE ON VEHICLES WITH CUMMINS ISL ENGINES AND 39MT DELCO STARTERS AT LEAST ONE OF THE 45 DEGREE FITTINGS WITH A 90 DEGREE FITTING AND ALSO REPLACE THE HOSE ASSEMBLY. ON ISL AND ISC ENGINES WITH 42MT DELCO STARTER, DEALERS WILL CHANGE ONE FITTING AT THE REAR OF THE HYDRAULIC PUMP AND RE-ROUTE A HOSE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SPARTAN AT 1-517-543-6400 OR WINNEBAGO AT 1-641-585-3535.