Toyota CELICA recalls by model year

Reported: 1978-01-23 (January 23, 1978) · Model years: 1972, 1973

HEATER HOSES ON THE INVOLVED VEHICLES MAY HAVE BEEN DAMAGED DURING INSTALLATION, RESULTING IN SHORTER SERVICE LIFE.

Remedy: HEATER HOSES WILL BE REPLACED ON ALL INVOLVED VEHICLES FREE OF CHARGE.

Reported: 1980-04-11 (April 11, 1980) · Model years: 1980

DUE TO A FAULTY PRESS DIE USED IN MANUFACTURING ALTERNATOR PULLEYS, PULLEYS INSTALLED ON CERTAIN VEHICLES MAY CRACK AND BREAK DURING VEHICLE OPERATION. THE BATTERY WOULD THEN BE CONSTANTLY DRAINED WITHOUT RECHARGING.

Remedy: DEALER WILL REPLACE THE ENGINE ALTERNATOR PULLEYS ON THE INVOLVED VEHICLES WITHOUT CHARGE TO OWNERS.

Reported: 1986-10-02 (October 2, 1986) · Model years: 1982

SOLDERED TERMINALS OF THE CRUISE CONTROL COMPUTER MAY DEVELOP CRACKS DUE TO IMPROPER APPLICATION OF THE COATING TO THE PRINTED CIRCUIT BOARD. CONSEQUENCE OF DEFECT: CONTINUED USE OF CRUISE CONTROL COULD LEAD TO COMPLETE SEPARATION OF SOLDERED TERMINALS AND CIRCUIT FAILURE; ENGINE SPEED WOULD INSTANTLY RACE AND VEHICLE COULD SUDDENLY ACCELERATE, POSSIBLY RESULTING IN AN ACCIDENT.

Remedy: REPLACE CRUISE CONTROL COMPUTER, IF NECESSARY.

Reported: 1990-04-20 (April 20, 1990) · Model years: 1990

AIR BAG INFLATOR CASE WAS INCORRECTLY MACHINED.

Consequence: IN AN ACCIDENT, THE AIR BAG MAY NOT DEPLOY, WHICH COULD RESULT IN INCREASED INJURY TO THE DRIVER.

Remedy: REPLACE AIR BAG INFLATOR UNIT.

Reported: 2020-01-22 (January 22, 2020) · Model years: 1998, 1999

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 1998-2000 RAV4, 1998-1999 RAV4 EV and Celica and 1997-1998 Supra vehicles. These vehicles were equipped with Non-Azide Driver air bag Inflators (NADI) and do not contain phase stabilized ammonium nitrate (PSAN) propellant. Due to a manufacturing issue, the NADI inflators may absorb moisture, causing the inflators to rupture or the air bag cushion to underinflate.

Consequence: In the event of a crash necessitating air bag deployment, an inflator rupture may result in metal fragments striking the driver or other occupants. An underinflated air bag may not properly protect the occupant, and increases the risk of serious injury or death.

Remedy: Toyota will notify owners, and owners will have the option to self-inspect, or have a dealer inspect the steering wheel on their vehicle to determine if their vehicle may be equipped with an affected inflator. Potentially affected steering wheel serial numbers will be inspected by a dealer. Based on the inspection, dealers will replace the front driver air bag inflator with an alternate one, as necessary. These repairs will be performed free of charge. The recall began August 28, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's numbers for this recall is 20TB01 and 20TA01.

Reported: 2004-09-17 (September 17, 2004) · Model years: 2000

CERTAIN PASSENGER VEHICLES HAVE THE POSSIBILITY THAT THE RECESS RETAINS A RUBBER SEAL RING, WHICH IS LOCATED AT THE END OF THE CYLINDER BODY, AND MAY BE CORRODED DUE TO AN IMPROPER WASHING PROCESS.

Consequence: IN THIS CONDITION, BRAKE FLUID MAY LEAK FROM THE SEAL, OR A SMALL AMOUNT OF AIR MAY ENTER THE MASTER CYLINDER, WHICH COULD LEAD TO AN INCREASE OF VEHICLE STOPPING DISTANCE.

Remedy: DEALERS WILL INSPECT THE BRAKE MASTER CYLINDER AND, IF NECESSARY, REPLACE THE BRAKE MASTER CYLINDER AND BOOSTER. THE RECALL BEGAN ON NOVEMBER 29, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-888-270-9371.

Reported: 2004-11-29 (November 29, 2004) · Model years: 2000, 2001

CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE LUMINOUS INTENSITY OF THE DAYTIME RUNNING LAMP (DRL) WILL BE MODIFIED TO MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL INSTALL A RESISTOR, WHICH WILL DECREASE THE LUMINOUS INTENSITY OF THE DRL. THE RECALL BEGAN ON MARCH 16, 2005. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2003-03-05 (March 5, 2003) · Model years: 2002, 2003

ON CERTAIN PASSENGER VEHICLES, THE FUEL TANK CHECK VALVE, LOCATED IN THE FUEL TANK INLET PIPE, MAY BECOME SEPARATED FROM THE INLET PIPE AND FALL INTO THE FUEL TANK. IF THE CHECK VALVE FALLS INTO THE TANK, FUEL MAY SPILL FROM THE FUEL INLET PIPE WHEN THE FUEL PUMP AUTOMATICALLY SHUTS OFF DURING FUELING.

Consequence: THIS CONDITION MAY RESULT A FIRE IN THE PRESENCE OF AN IGNITION SOURCE.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPAIR THE FUEL TANK CHECK VALVE. OWNER NOTIFICATION BEGAN APRIL 4, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2010-02-03 (February 3, 2010) · Model years: 2005

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.