Thor Motor Coach PALAZZO recalls by model year

Reported: 2012-12-11 (December 11, 2012) · Model years: 2013

Thor Motor Coach (Thor) is recalling certain model year 2011 through 2013 Tuscany, Astoria, Ultrasport, Montecito, and Palazzo recreational vehicles manufactured from May 17, 2010, through October 30, 2012, built on Freightliner brand XB and XC custom chassis. The vehicles are equipped with diode jumpers that may come loose in their connectors resulting in an open circuit. Two circuits are affected: The one that disengages the cruise control with brake pedal use, and the one that illuminates the brake lights with brake pedal use.

Consequence: Failure of the cruise control to disengage when the brakes are applied may increase the risk of a vehicle crash. Without the brake lights illuminating when the brakes are applied, the driver's intent is not communicated, increasing the risk of a crash.

Remedy: Daimler Trucks (DTNA) will notify owners on behalf of Thor, and Freightliner dealers will inspect the diode jumpers to make sure they are fully locked in place and will correct the vehicles as needed. The recall is expected to begin January 28, 2013. Owners should contact DTNA Warranty Campaigns Department at (800) 547-0712, 7:00 a.m. to 4:00 p.m. Pacific Time Monday through Friday, e-mail address DTNA.Warranty.Campaigns@Daimler.com, or the Customer Assistance Center at (800) FTL-HELP after normal business hours.

Reported: 2013-04-25 (April 25, 2013) · Model years: 2013

Thor Motor Coach is recalling certain model year 2013-2014 Challenger, Four Winds 5000, Hurricane, Chateau, Chateau Sport, and Windsport; model year 2013 Palazzo and Four Winds Siesta and model year 2014 Majestic motorhomes manufactured February 13, 2013, through April 09, 2013. If the awning installation sequence was not completely followed, the awning motor may unknowningly become damaged. A damaged motor may lead to an unfurling of the awning.

Consequence: If motor damage occurs, it is possible that the awning can unfurl unexpectedly, either while the motorhome is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

Remedy: Thor Motor Coach will notify owners and Dometic staff will replace the affected motors with a design that is not subject to an out-of-sequence installation error. The recall began during May 2013. Owners may contact Thor at 1-877-855-2867 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed.

Reported: 2017-11-22 (November 22, 2017) · Model years: 2013, 2014

Thor Motor Coach (Thor) is recalling various 2003-2018 recreational vehicles, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. See a list of the affected trailer models at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V758-5764.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Thor will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Thor customer service at 1-877-500-1020, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Reported: 2018-10-09 (October 9, 2018) · Model years: 2013

Thor Motor Coach (TMC) is recalling certain 2013 Thor Ace, Daybreak, Challenger, Windsport, Hurricane, Outlaw, Tuscany, and Palazzo motorhomes. The windshield wiper system may have been incorrectly installed, causing the wipers to fail during use, reducing driver visibility.

Consequence: A reduction of driver visibility can increase the risk of a crash.

Remedy: TMC will notify owners, and dealers will verify that the windshield wiper system is installed correctly, repairing or replacing the wiper system as needed, free of charge. The recall began November 28, 2018. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000161.

Reported: 2014-03-18 (March 18, 2014) · Model years: 2014

Thor Motor Coach (Thor) is recalling certain model year 2013-2014 Challenger and Tuscany recreational vehicles, and 2014 Tuscany XTE and Palazzo recreational vehicles manufactured March 8, 2013, through August 8, 2013, and equipped with certain Frigidaire KG-series microwave models CFMV152CLB and CFMV154CLS manufactured January 27, 2013, through April 10, 2013 in the serial number range KG30607951 through KG31600670. In the affected vehicles, the microwave may start on its own and begin heating when unattended.

Consequence: If the microwave starts on its own and there are contents inside, a fire could result.

Remedy: Thor will notify owners, and dealers will repair the membrane/keypad component, free of charge. The recall began on May 12, 2014. Owners may contact Thor Motor Coach at 1-877-500-1020. Thor's number for this recall is RC000088. Note: Until the microwave has been repaired, owners should not store anything in the microwave while it is unattended.

Reported: 2017-02-14 (February 14, 2017) · Model years: 2014

Thor Motor Coach (TMC) is recalling certain 2014-2015 Tuscany, Tuscany XTE and Palazzo motorhomes. The windshield wiper systems on these vehicles may have been improperly installed or secured, causing the wipers to fail during operation.

Consequence: If the windshield wipers fail, the driver would have decreased visibility, increasing the risk of a crash.

Remedy: TMC will notify owners, and dealers will inspect the wiper system, tightening the wiper nuts to the proper specifications, as necessary, free of charge. The recall began on April 12, 2017. Owners may contact TMC customer service at 1-877-500-1020. TMC's number for this recall is RC000128.

Reported: 2017-09-07 (September 7, 2017) · Model years: 2014

Thor Motor Coach (TMC) is recalling certain 2014-2016 Ace, Challenger, Daybreak, Hurricane, Miramar, Outlaw, Windsport, Palazzo, Tuscany, and Tuscany XTE motorhomes. The windshield wipers may fail due to the system being incorrectly installed or secured.

Consequence: If the windshield wipers cannot be used, driver visibility would be reduced, increasing the risk of a crash.

Remedy: TMC will notify owners, and dealers will inspect the wiper system to verify it is installed correctly, repairing or replacing the system as necessary, free of charge. The recall began on September 27, 2017. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000146. Note: Although some of the vehicles included in this recall have previously been remedied under recalls 17V-096 or 17V-162, the vehicles may need additional repairs under this campaign.

Reported: 2023-02-23 (February 23, 2023) · Model years: 2015, 2016, 2017, 2018, 2019, 2021, 2022, 2023

Thor Motor Coach (TMC) is recalling certain 2015-2023 Palazzo recreational vehicles. The front lower cap brackets that support the front fiberglass panel may become loose and detach from the vehicle while in motion.

Consequence: A detached bracket can become a road hazard, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the front lower brackets, as necessary, free of charge. Owner notification letters were mailed March 15, 2023. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000291.

Reported: 2020-07-20 (July 20, 2020) · Model years: 2017, 2018, 2019

Thor Motor Coach (TMC) is recalling certain 2017-2020 Aria, Venetian and Tuscany, 2017 Tuscany XTE and 2017-2019 Palazzo motorhomes vehicles that received an inspection-only remedy for recall 18V-763. The rear mounted Power Distribution Module (PDM) may have been damaged during manufacturing, possibly resulting in the rear marker lights, brake lights, or turn signals not functioning.

Consequence: Non-functioning exterior marker lights can increase the risk of a crash.

Remedy: TMC will notify owners, and Daimler Trucks dealers will replace the PDM, free of charge. Owner letters were mailed October 6, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000196.

Reported: 2020-09-15 (September 15, 2020) · Model years: 2018, 2019, 2021

Thor Motor Coach (TMC) is recalling certain 2018-2021 Aria, Palazzo, Tuscany, and Venetian motorhomes built on a Daimler Trucks (DTNA) chassis. The tire valve stem extension for the inner wheel may contact the outer wheel rim opening and become damaged.

Consequence: Extensive damage to the valve stem extension may result in a loss of tire pressure of the inner wheel, increasing the risk of a crash.

Remedy: TMC will notify owners, and DTNA dealers will inspect the inner wheel valve stem stabilizers, and adjust as needed and/or replace the inner valve stem, free of charge. The recall began November 2, 2020. Owners may contact TMC customer service at 1-800-524-5210 extension 104 or DTNA customer service at 1-800-547-0712. TMC's number for this recall is RC000204. DTNA's number for this recall is FL-861.

Reported: 2021-07-08 (July 8, 2021) · Model years: 2019

Thor Motor Coach (TMC) is recalling certain 2019 Challenger, Palazzo, Tuscany, 2019-2020 Miramar, 2019-2021 Aria, Outlaw, and Venetian recreational vehicles equipped with Hehr 6400 series windows. The adhesive that bonds the vented portion of the window may fail.

Consequence: Adhesive failure may cause the vent portion of the window to detach, increasing the risk of a crash or injury.

Remedy: Dealers will inspect the windows, and replace the vent if necessary, free of charge. Owner notification letters were mailed September 8, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000232.

Reported: 2019-06-30 (June 30, 2019) · Model years: 2020

Thor Motor Coach (TMC) is recalling certain 2019-2020 Challenger, Miramar, Magnitude, Outlaw, Omni, and Palazzo motorhomes. The vehicle control system software may cause the slide-out room to move unexpectedly.

Consequence: Unexpected movement of the slide-out room can increase the risk of a injury.

Remedy: TMC will notify owners, and dealers will update the affected software, free of charge. The recall is expected to begin August 28, 2019. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000170.