Pierce ENFORCER recalls by model year

Reported: 2010-09-21 (September 21, 2010) · Model years: 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008

PIERCE IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2008 ARROW XT, LANCE, VELOCITY, ENFORCER, IMPEL, AND DASH CUSTOM FIRE APPARATUS VEHICLES MANUFACTURED FROM MAY 30, 1998 THROUGH NOVEMBER 25, 2008. THE STEERING GEAR BRACKET MAY FRACTURE AND BREAK. IF THIS OCCURS THE STEERING GEAR MAY DETACH FROM THE VEHICLE.

Consequence: DETACHMENT OF THE STEERING GEAR WILL RESULT IN A LOSS OF STEERING CONTROL THAT COULD CAUSE A CRASH.

Remedy: PIERCE WILL NOTIFY OWNERS AND DEALERS WILL INSTALL A NEW STEERING GEAR MOUNTING BRACKET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 12, 2010. OWNERS ARE BEING INSTRUCTED TO INSPECT THE STEERING GEAR BRACKET PRIOR TO EACH TRIP. THE REMEDY TO REPAIR THIS DEFECT IS EXPECTED TO BEGIN NO EARLIER THE JANUARY 31, 2011. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.

Reported: 2005-08-10 (August 10, 2005) · Model years: 1999, 2000, 2001, 2002, 2003, 2004

CERTAIN FIRE TRUCKS WITH COMMAND CABS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207,"SEATING SYSTEMS." THE RESCUE BODY OFFERINGS DO NOT MEET THE PULL TEST REQUIREMENTS. THE PEDESTAL SEAT WAS MOUNTED BY DRILLING AND TAPPING THE CAB OR BODY FLOOR.

Consequence: IN THE EVENT OF A CRASH, THE PEDESTAL SEAT FASTENERS COULD FAIL TO RESTRAIN THE SEAT, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.

Remedy: DEALERS WILL INSPECT THE SEAT PEDESTALS. IF THE SEAT WAS MOUNTED WITH TAPPED FASTENERS, THE FASTENERS WILL BE REMOVED AND A HOLE WILL BE DRILLED TO REPLACE THE MOUNTING FASTENERS WITH 7/16" BOLTS AND NUTS. THE RECALL BEGAN ON AUGUST 19, 2005. OWNERS MAY CONTACT PIERCE AT 920-832-3249.

Reported: 2017-05-30 (May 30, 2017) · Model years: 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013

Pierce Manufacturing (Pierce) is recalling certain 1999-2013 Arrow XT, Dash, Enforcer, Quantum and Velocity fire trucks equipped with the electric All-steer rear steering option. The affected vehicles have rear steer axle shafts that were not properly heat treated.

Consequence: Axle shafts that are not properly heat treated may break and potentially disable the vehicle, increasing the risk of a crash.

Remedy: Pierce will notify owners, and dealers will replace the rear steer axle shafts, free of charge. An interim notice was mailed on July 24, 2017. The recall began June 3, 2020. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2002-10-08 (October 8, 2002) · Model years: 2000

ON SOME HEAVY DUTY CLASS 8 VEHICLES EQUIPPED WITH ARVINMERITOR AXLE ASSEMBLIES WHICH MAY HAVE BEEN MANUFACTURED WITH TRW MODEL 20EDL BALL SOCKETS, THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW SPECIFICATION CASE DEPTH AND/OR HARDNESS WHICH CAN LEAD TO PREMATURE WEAR OUT OF THE SOCKET IN SOME APPLICATIONS.

Consequence: IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE STEERING CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE BALL SOCKET ASSEMBLIES. OWNER NOTIFICATION BEGAN OCTOBER 25, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT PIERCE AT 920-832-3000.

Reported: 2011-04-26 (April 26, 2011) · Model years: 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008

PIERCE IS RECALLING CERTAIN MODEL YEAR 1999-2008 ARROW XT, DASH, LANCE, AND ENFORCER FIRE APPARATUS MANUFACTURED FROM JUNE 22, 1999, THROUGH MAY 12, 2008, AND EQUIPPED WITH AN ELECTRONIC ACCELERATOR PEDAL. AFTER REPEATED USE WITH EXCESSIVE FORCE, THE ACCELERATOR PEDAL ARM MAY BEND AND CAUSE THE PEDAL TO MOVE CLOSER TO THE FLOOR. IF THE PEDAL ARM BENDS FAR ENOUGH, THE PEDAL MAY CONTACT THE CAB FLOOR WITHOUT WARNING AND STICK IN THE FULL THROTTLE POSITION.

Consequence: IF THE ACCELERATOR PEDAL BECOMES STUCK, THE OPERATOR MAY LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REMOVE THE EXISTING ACCELERATOR ARM AND INSTALL A REDESIGNED PEDAL ARM FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 9, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.

Reported: 2011-07-26 (July 26, 2011) · Model years: 2000, 2001, 2002, 2003, 2004, 2005

PIERCE HAS DECIDED THAT CERTAIN MODEL YEAR 1995-2008 ARROW XT, DASH, CUSTOM CONTENDER, LANCE, ENFORCER, PIERCE ARROW, QUANTUM, SABER AND COMMERCIAL FIRE TRUCKS MANUFACTURED FROM JANUARY 2, 1995, THROUGH JANUARY 21, 2008, CONTAIN A SAFETY DEFECT. THESE VEHICLES ARE EQUIPPED WITH FUEL TANK STRAPS THAT MAY CORRODE DUE TO WINTER ROAD SALT OR LIQUID DE-ICING CHEMICALS. IF THE FUEL TANK STRAPS CORRODE SUFFICIENTLY, THE FUEL TANK SUPPORTING STRAPS MAY FRACTURE AND THE FUEL TANK MAY FALL FROM THE VEHICLE.

Consequence: THE VEHICLES MAY LOSE POWER AND STALL. IN ADDITION, THE FUEL TANK MAY RUPTURE AND SPILL DIESEL FUEL ON THE ROADWAY. EITHER OF THESE OUTCOMES MAY CAUSE A FIRE TRUCK OR SURROUNDING VEHICLES TO SLIP OR SLIDE ON THE ROADWAY SURFACE, INCREASING THE RISK OF A CRASH.

Remedy: FOR FIRE TRUCKS THAT ARE LESS THAN 10 YEARS OLD, DEALERS WILL INSPECT THE FUEL TANK STRAPS AND REPLACE THEM IF NECESSARY WITH STAINLESS STEEL STRAPS FREE OF CHARGE. FOR VEHICLES THAT ARE OLDER THAN 10 YEARS, PIERCE IS NOT OFFERING A FREE REMEDY, BUT WILL OFFER FOR PURCHASE REPLACEMENT FUEL TANKS STRAPS AND PROVIDE INSTRUCTIONS FOR INSTALLATION. THE SAFETY RECALL BEGAN ON AUGUST 27, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.

Reported: 2013-10-22 (October 22, 2013) · Model years: 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009

Pierce Manufacturing Inc. (Pierce) is recalling certain model year 2000-2009 Enforcer and model year 2000-2010 Dash, Lance, and Arrow XT vehicles. While raising or lowering the cab as part of vehicle maintenance, the mounts on which the cab tilt cylinders pivot may fatigue and fail allowing the cab to fall until the safety catch activates.

Consequence: If a person is in the path of the moving cab when a mount fails, the person may be hit by the falling cab, increasing the risk of injury.

Remedy: Pierce will notify owners, and dealers will affix new safety signs advising the operator to stay clear of the cab while it is being tilted, free of charge. The recall began on January 6, 2014. Owners may contact Pierce at 1-920-832-3000. Pierce's recall number is 74B240.

Reported: 2005-03-04 (March 4, 2005) · Model years: 2001, 2002, 2003, 2004

CERTAIN FIRE TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, 'SEATING SYSTEMS.' THE SEAT TETHER RESTRAINS THE SEAT DURING PULL TESTING AS THE SUSPENSION COMPONENTS ARE NOT DESIGNED TO RESTRAIN THE SEAT ON THEIR OWN. THE SUSPENSION SEAT TETHERS ARE TOO LONG.

Consequence: THE OCCUPANT WILL EXPERIENCE INSUFFICIENT SUSPENSION SEAT RESTRAINT WHICH COULD LEAD TO PERSONAL INJURY OR DEATH IN THE EVENT OF A CRASH.

Remedy: DEALERS WILL REPLACE SUSPENSION SEAT TETHERS WITH SHORTER TETHERS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723.

Reported: 2010-06-28 (June 28, 2010) · Model years: 2003, 2004, 2005, 2006, 2007, 2008, 2009

PIERCE IS RECALLING CERTAIN MODEL YEAR 2003 THROUGH 2009 CUSTOM CONTENDER, DASH, ENFORCER, IMPEL, LANCE SABER, AND VELOCITY FIRE TRUCKS MANUFACTURED FROM FEBRUARY 20, 2003, THROUGH MARCH 27, 2009. THESE TRUCKS MAY BE EQUIPPED WITH DROP-DOWN FIRE HOSE TRAYS MOUNTED UNDER THE FRONT BUMPER. THE HOSE TRAY LATCH MAY ACCIDENTALLY OPEN WHILE THE VEHICLE IS IN MOTION.

Consequence: IF THIS OCCURS THE FIRE HOSE MAY DROP TO THE ROADWAY WITHOUT WARNING. POTENTIAL INJURY TO PEOPLE AND PROPERTY MAY OCCUR. THE SUDDEN HOSE DEPLOYMENT MAY ALSO DISTRACT DRIVERS TRYING TO AVOID THE HOSE AND A CRASH MAY OCCUR.

Remedy: A NEW AND IMPROVED LATCH DESIGN HAS BEEN DEVELOPED AND A NEW HOSE BOX INCORPORATING THE NEW LATCH WILL BE INSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 4, 2010. OWNER MAY CONTACT PIERCE AT 1-920-832-3000.

Reported: 2005-05-12 (May 12, 2005) · Model years: 2004, 2005

CERTAIN FIRE TRUCKS EQUIPPED WITH HOLLAND/NEWAY AIR SUSPENSION SYSTEMS, A TRANSVERSE BEAM CASTINGS MAY FRACTURE UNDER NORMAL LOADS. IF A CASTING BREAKS WHEN THE VEHICLE IS TRAVELING ON A ROADWAY THERE IS THE POTENTIAL FOR PIECES OF THE CASTING TO BECOME PROJECTILES AND THE SUSPENSION?S TRANSVERSE BEAM MAY DROP DOWN LOW ENOUGH TO CONTACT THE ROAD SURFACE.

Consequence: THIS WILL CAUSE SPARKS THAT COULD POTENTIALLY IGNITE AND CAUSE A FIRE.

Remedy: HOLLAND IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE DEFECTIVE TRANSVERSE BEAM ASSEMBLIES FREE OF CHARGE. OWNERS MAY CONTACT HOLLAND AT 616-396-6501 OR PIERCE AT 1-888-974-3723.

Reported: 2019-01-02 (January 2, 2019) · Model years: 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018

Pierce Manufacturing (Pierce) is recalling certain 2004-2018 Arrow XT, Dash, Enforcer, Impel, Quantum and Velocity aerial vehicles. The aerial device may unexpectedly rotate to the right when the ladder is being extended.

Consequence: If the aerial device moves in an unexpected direction, the ladder may contact an object, such as a building or an electrical wire, increasing the risk of injury.

Remedy: Pierce will notify owners, and dealers will reprogram the aerial control module, free of charge. The recall began February 28, 2019. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B295.

Reported: 2006-05-23 (May 23, 2006) · Model years: 2005, 2006

ON CERTAIN FIRE TRUCKS EQUIPPED WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING RODS WHICH TRANSFER ENERGY FROM THE PISTON TO THE CRANKSHAFT ARE DEFECTIVE AND CAN RESULT IN SEIZURE OF THE PISTON PIN. A PISTON PIN SEIZURE CAN RESULT IN A MISSION-DISABLING ENGINE FAILURE.

Consequence: THIS CONDITION COULD ULTIMATELY RESULT IN A LOSS OF VEHICLE POWER (ENGINE STALL) INCREASING THE RISK OF A CRASH.

Remedy: PIERCE IS WORKING WITH CUMMINS TO REPLACE THE CONNECTING RODS FREE OF CHARGE. OWNERS MAY CONTACT PIERCE AT 1-888-974-3723 OR CUMMINS AT 1-800-DIESELS.

Reported: 2011-11-10 (November 10, 2011) · Model years: 2005

PIERCE MANUFACTURING (PIERCE) IS RECALLING CERTAIN MODEL YEAR 2005, 2008-2011 ARROW XT, CUSTOM CONTENDER, DASH, ENFORCER, IMPEL, QUANTUM, SABER, AND VELOCITY 75 FOOT HAL (HEAVY ALUMINUM LADDER) FIRE APPARATUS BODIES VEHICLES MANUFACTURED FROM MAY 17,2005, THROUGH OCTOBER 13, 2011, THAT MAY BE EQUIPPED WITH DUAL SCBA CYLINDER STORAGE COMPARTMENTS. THESE COMPARTMENTS EXTEND INBOARD HORIZONTALLY FROM THE SIDE OF THE REAR BODY. THE SCBA COMPARTMENT DOOR LATCH ORIENTATION MAY HAVE BEEN MANUFACTURED INCORRECTLY, ALLOWING THE DOOR TO ACCIDENTALLY OPEN WHILE THE VEHICLE IS IN MOTION. THE DOOR MAY OPEN WITHOUT WARNING AND WITHOUT KNOWLEDGE TO THE DRIVER.

Consequence: IF THE DOOR OPENS, THE SCBA CYLINDERS MAY FALL OUT OF THE COMPARTMENT AND ONTO THE ROADWAY, INCREASING THE RISK OF A CRASH OR INJURY TO PEDESTRIANS.

Remedy: PIERCE DEALERS WILL NOTIFY OWNERS, AND WILL INSTALL A FLAT REINFORCEMENT PLATE THAT SPANS THE LENGTH OF THE SCBA DOOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 5, 2011. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.

Reported: 2010-07-08 (July 8, 2010) · Model years: 2006, 2007, 2008, 2009, 2010

PIERCE IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 ARROW XT, DASH, ENFORCER, IMPEL, QUANTUM, AND VELOCITY FIRE TRUCKS MANUFACTURED FROM OCTOBER 11, 2006 THROUGH JUNE 16, 2010 AND EQUIPPED WITH MERITOR WABCO EX225 REAR DISC BRAKES AND ONSPOT AUTOMATIC TIRE CHAINS. THE MERITOR WABCO EX225 REAR DISC BRAKE CALIPER MAY INTERFERE WITH THE ONSPOT AUTOMATIC TIRE CHAIN BRACKETS. THIS INTERFERENCE MAY RESTRICT THE CALIPER FROM FULL MOVEMENT.

Consequence: IF THIS INTERFERENCE OCCURS, BRAKING PERFORMANCE MAY BE REDUCED WITHOUT WARNING AND A CRASH MAY OCCUR.

Remedy: DEALERS WILL INSTALL NEW AUTOMATIC TIRE CHAIN BRACKETS. THE NEW BRACKETS PROVIDE ADDITIONAL CLEARANCE FOR THE FULL ACTUATION OF THE DISC BRAKE CALIPERS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN IN JULY 2010. OWNERS MAY CONTACT PIERCE AT 1-920-832-3000.

Reported: 2015-10-01 (October 1, 2015) · Model years: 2006, 2007

Pierce Manufacturing (Pierce) is recalling certain model year 2006-2007 Arrow XT, Dash, Enforcer, Lance, Impel, and Quantum vehicles manufactured January 1, 2006, to March 31, 2007. In the affected vehicles, tears in the ball joint protective boots may result in contamination of the ball joints.

Consequence: The contamination may cause premature ball joint failure and the wheel to disengage from the control arm, increasing the risk of a vehicle crash.

Remedy: Pierce will notify owners, and dealers will inspect the affected vehicles for torn ball joint boots. Pierce will also evaluate the ball joint wear. Ball joints with an unexpected level of wear will be replaced. These repairs will be performed free of charge. The recall began on December 10, 2015. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B267.

Reported: 2008-01-15 (January 15, 2008) · Model years: 2007

ON CERTAIN FIRE TRUCKS EQUIPPED WITH TRW STEERING GEARS, MODELS TAS85 AND RCS85, THESE STEERING GEARS CONTAIN POTENTIALLY DEFECTIVE SECTOR SHAFTS WITH AN INCORRECT GEAR TOOTH WHICH MAY INTERFERE WITH THE RACK-PISTON TEETH, RESULTING IN A STICK OR BIND CONDITION.

Consequence: THIS CONDITION HAS THE POTENTIAL TO CAUSE THE STEERING GEAR TO STALL AND RESTRICT THE STEERING TURNING ANGLE OF THE VEHICLE WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: PIERCE IS WORKING WITH TRW TO REPLACE THE DEFECTIVE STEERING GEAR (PLEASE SEE 07E101). THE RECALL BEGAN ON JANUARY 11, 2008. OWNERS ONTACT TRW AT 765-429-1768 OR PIERCE AT 920-832-3249.

Reported: 2008-11-18 (November 18, 2008) · Model years: 2007, 2008

PIERCE IS RECALLING 15 MY 2007-2008 DASH, ENFORCER, IMPEL, QUANTUM AND VELOCITY FIRE TRUCKS EQUIPPED WITH ARVINMERITOR REAR DISC BRAKES AND HENDRICKSON FIREMAAX SUSPENSION. INTERFERENCE WITH THE BRAKE CALIPER ADJUSTER BOLT SLEEVE AND THE SUSPENSION BEAM MAY OCCUR. THIS INTERFERENCE MAY OCCUR IF THE RIGHT HAND AND LEFT HAND BRAKE COMPONENTS WERE ASSEMBLED ON THE WRONG SIDE OF THE AXLE. THE ADJUSTER BOLT IS DESIGNED TO ROTATE AS THE BRAKE PADS WEAR. IF THE SLEEVE BECOMES DAMAGED, THE SLEEVE MAY PREVENT THE ADJUSTER FROM ROTATING.

Consequence: IF THE ADJUSTER CAN NOT ROTATE, BRAKE PERFORMANCE MAY BE COMPROMISED AND A CRASH MAY OCCUR.

Remedy: DEALERS WILL ADJUST THE BOLT SLEEVE AND THE PROPER COMPONENTS FREE OF CHARGE. ALL OWNERS HAVE BEEN NOTIFIED BY ARVINMERITOR.

Reported: 2018-07-11 (July 11, 2018) · Model years: 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017

Pierce Manufacturing (Pierce) is recalling certain 2007-2017 Pierce Velocity, Impel, Arrow-XT, Quantum, and Enforcer emergency response vehicles equipped with 75ft aerial devices with a 21 inch or 28 inch limited retraction bracket. The bracket on the aerial device may detach from the aerial and fall to the ground.

Consequence: If the bracket falls, it could strike a person below.

Remedy: Pierce will notify owners, and dealers will install additional hardware to mount the limited retraction bracket, free of charge. The recall began on August 22, 2018. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B290.

Reported: 2013-10-22 (October 22, 2013) · Model years: 2009

Pierce Manufacturing Inc. (Pierce) is recalling one model year 2009 Enforcer emergency vehicle and certain model year 2009-2013 Arrow XT, Saber, Velocity, Impel, Quantum, and Commercial vehicles. The trailer connector circuit was wired such that the stop signal overrides the turn signal and the trailer lights do not indicate a turn when brakes are applied.

Consequence: The absence of trailer turn signals may confuse other drivers, increasing the risk of a crash.

Remedy: Pierce will notify owners, and dealers will install a new electrical harness, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Pierce at 1-920-832-3000. Pierce's recall number is 74B244.

Reported: 2014-10-21 (October 21, 2014) · Model years: 2009, 2010, 2011, 2012, 2013

Pierce Manufacturing (Pierce) is recalling certain model year 2009-2013 Pierce Enforcer, Impel, Quantum, Velocity, and Arrow XT emergency vehicles manufactured November 11, 2009, to April 23, 2013, and equipped with TAK-4 front independent suspensions. The affected vehicles have front lower control arms that may crack and fracture.

Consequence: If one of the lower control arm fractures, the attached wheel may separate, increasing the risk of a crash.

Remedy: Pierce will notify owners, and dealers will inspect and replace the lower control arms, as necessary, free of charge. The recall began on November 5, 2014. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B257.

Reported: 2022-10-27 (October 27, 2022) · Model years: 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019, 2020, 2021, 2022

Pierce Manufacturing (Pierce) is recalling certain 2010-2022 Pierce Velocity, Enforcer, Arrow XT, Quantum, and Dash CF fire trucks. Stokes basket mounting brackets may be insufficiently welded.

Consequence: The left and/or right brackets can fail, allowing the stokes basket to fall and increasing the risk of injury.

Remedy: Pierce will replace the stokes basket mounting brackets, free of charge. Owner notification letters were mailed December 14, 2022. Owners may contact Pierce's customer service at 1-888-974-3723. Pierce's number for this recall is 74B323.

Reported: 2017-05-31 (May 31, 2017) · Model years: 2012, 2013, 2014, 2015, 2016, 2017

Pierce Manufacturing (Pierce) is recalling certain 2012-2017 Arrow XT, Dash, Enforcer, Quantum, and Velocity fire trucks equipped with the T3 rear steer option. The affected vehicles have a rear sway bar that may detach from the vehicle.

Consequence: If the sway bar detaches, the vehicle may sway more during steering maneuvers, increasing the risk of a crash.

Remedy: Pierce will notify owners, and dealers will replace and properly torque the sway bar fasteners, free of charge. The recall began on July 11, 2017. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2015-08-13 (August 13, 2015) · Model years: 2014, 2015

Pierce Manufacturing (Pierce) is recalling certain model year 2014-2015 Pierce Arrow XT, Dash CF, Enforcer, Quantum, and Velocity emergency vehicles manufactured from November 3, 2014, through July 31, 2015. The affected vehicles have a driveshaft that may bend or twist possibly causing it disconnect.

Consequence: If the driveshaft disconnects from the vehicle, the vehicle would have a loss of drive, disabling it on the roadway and preventing the vehicle from responding to an emergency. Additionally, portions of the driveshaft could become a road hazard. These scenarios may increase the risk of a crash.

Remedy: Pierce has notified owners, and dealers will install a stronger driveshaft, free of charge. The recall began on September 15, 2015. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B265.

Reported: 2016-03-10 (March 10, 2016) · Model years: 2014, 2015, 2016

Pierce Manufacturing (Pierce) is recalling certain model year 2014-2016 Enforcer and Saber emergency vehicles manufactured from March 3, 2014, through February 3, 2016. The clamps on the heater hose may have been improperly installed allowing engine coolant to leak into the passenger compartment.

Consequence: If coolant leaks into the passenger compartment, it may contact electrical components causing a shorting of circuits and a loss of function of features controlled by those circuits, including loss of power to vehicle which may result in a stall and increase the risk of a crash. The hot coolant may also contact occupants and possibly cause burn injuries.

Remedy: Pierce will notify owners, and dealers will inspect the hose clamp installation. Any improperly installed clamps will be corrected free of charge. The recall began on April 11, 2016. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B269.

Reported: 2015-03-25 (March 25, 2015) · Model years: 2015

Pierce Manufacturing (Pierce) is recalling certain model year 2015 Saber, Enforcer, Impel, and Velocity vehicles manufactured December 4, 2014, to March 23, 2015. The rear axle cast iron leaf spring spacer block may crack and fracture.

Consequence: If the leaf spring spacer block fractures, the pieces may become a road hazard. If the entire spacer block separates from the vehicle, the alignment of the rear axle may suddenly shift. Either condition could increase the risk of a crash.

Remedy: Pierce will notify owners, and dealers will replace the cast iron spring spacer block with a machined steel spring spacer block, free of charge. The recall began on March 23, 2015. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2015-10-26 (October 26, 2015) · Model years: 2015, 2016

Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Arrow XT, Velocity, Enforcer, and Saber vehicles manufactured November 20, 2014, to September 29, 2015. The affected vehicles are equipped with front drive axles whose hex nuts on the flange yoke may not have been properly tightened.

Consequence: If the hex nuts are not tightened to specification, the driveshaft may disconnect from the drive axle, resulting in a loss of propulsion and increasing the risk of a crash.

Remedy: Pierce will notify owners, and dealers will inspect the hex nuts, tightening them as necessary, free of charge. The recall began on November 12, 2015. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B266.

Reported: 2016-06-01 (June 1, 2016) · Model years: 2015, 2016

Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Arrow XT, Enforcer, Impel, Quantum, Saber, and Velocity emergency vehicles manufactured August 4, 2015, to August 24, 2016, equipped with pumps to provide pressurized water to aid in fighting fires. These pumps have 6" intake strainers that may have been improperly soldered during production and, as a result, the strainers may come apart during use, allowing parts of the strainer and debris to enter the pump, possibly damaging the pump.

Consequence: If the strainer and/or debris enters the pump, and the operator is forced to shut down the pump, reducing firefighting effectiveness, there could be an increased risk of injury.

Remedy: Pierce will notify owners to check the strainer for missing solder at the joints. Any strainers missing solder will be replaced, free of charge. The recall began on June 16, 2016. Owners may contact Pierce customer service at 1-888-974-3723 or Hale Products Customer Service Center at 1-800-533-3569. Pierce's number for this recall is 74B272.

Reported: 2016-07-22 (July 22, 2016) · Model years: 2015, 2016

Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Enforcer, Impel, and Velocity vehicles manufactured April 12, 2016, to May 31, 2016, equipped with aerial devices. The affected vehicles may have a plastic plug installed in an unused port in the hydraulic pump for the aerial device. This plastic plug may separate from the pump resulting in a hydraulic fluid leak, potentially disabling the aerial device.

Consequence: The inoperable aerial device can increase the risk of injury if the operator needs to move away from a hazardous situation or it may impede the safety mission.

Remedy: Pierce has notified owners, and dealers will inspect the vehicles and replace the plastic plug with a metal plug, as necessary, free of charge. The recall began on July 26, 2016. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B276.

Reported: 2016-08-05 (August 5, 2016) · Model years: 2015, 2016

Pierce Manufacturing (Pierce) is recalling certain model year 2015-2016 Arrow, Dash, Enforcer, Impel, Quantum, Saber, and Velocity fire trucks manufactured June 29, 2015, to June 30, 2016. The affected vehicles may be equipped with certain C20 and C21 split-shaft transmissions from Waterous. This transmission sends power to the wheels of an emergency response vehicle or power to an add-on unit such as a water pump used for fighting fires. A component within the shift unit may be damaged and as a result, the operator may not be able to switch the power output.

Consequence: If the power output cannot be changed, once the fire truck arrives at the scene, it may not be able to pump water to aid in extinguishing the fire, increasing the risk of injury.

Remedy: Piece will notify owners, and dealers will remove the shift unit assembly and replace the clevis pin and retaining rings, free of charge. The recall began on September 2, 2016. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B277.

Reported: 2017-09-14 (September 14, 2017) · Model years: 2015, 2016

Pierce Manufacturing (Pierce) is recalling certain 2015-2016 Arrow XT, Enforcer, Impel, Quantum, Saber, and Velocity vehicles, equipped with certain Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.

Consequence: If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.

Remedy: Pierce will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on November 30, 2017. Owners may contact Pierce customer service at 1-414-832-3000.

Reported: 2018-01-11 (January 11, 2018) · Model years: 2015, 2016

Pierce Manufacturing (Pierce) is recalling certain 2015-2016 Arrow XT, Enforcer, Quantum, Saber, Velocity, and Commercial emergency vehicles equipped with Hale pressure relief valves in the water pumps used for fire fighting. Rings securing the valves may corrode over time after exposure to water, causing the ring to fail and the pressure relief valve to open, reducing the water pressure available for fire fighting.

Consequence: A reduction in water pressure may hinder fire fighting efforts, increasing the risk of injury.

Remedy: Pierce has notified owners, and dealers will install a remedy kit, free of charge. The recall began on February 9, 2018. Owners may contact Pierce customer service at 1-888-974-3723 or Hale Products at 1-800-533-3569. Pierce's number for this recall is 74B287.

Reported: 2022-01-26 (January 26, 2022) · Model years: 2015, 2016, 2017, 2018, 2019, 2020, 2021

Pierce Manufacturing (Pierce) is recalling certain 2015-2021 Arrow XT, Enforcer, Quantum and Velocity fire trucks. The fuel tubes between the fuel rail and the injectors for cylinders four, five, and six may fatigue and crack, which can result in a high pressure fuel leak.

Consequence: A high pressure fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: On engines with 75 miles or less, dealers will install vibration isolators to the fuel tubes. Engines with more than 75 miles will receive new fuel tubes with vibration isolators, free of charge. Owner notification letters were mailed on March 11, 2022. Owners may contact Pierce's customer service at 1-888-974-3723.

Reported: 2026-04-06 (April 6, 2026) · Model years: 2015, 2016, 2017, 2018, 2019, 2020, 2021, 2022, 2023, 2024, 2025, 2026

Pierce Manufacturing (Pierce) is recalling certain 2015-2026 Arrow XT, Enforcer, Impel, and Velocity 107’ ladder and 110’ platform aerial firetrucks equipped with a single rear axle. The firm-on-ground system light may remain illuminated after the rear stabilizer loses contact with the ground.

Consequence: A false firm-on-ground indicator light may lead to using the aerial device when the vehicle may shift during aerial operation, increasing the risk of injury.

Remedy: Pierce will provide instructions on how to update the vehicle software and perform an aerial device functional check, free of charge. Owner notification letters were mailed April 29, 2026. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2016-03-02 (March 2, 2016) · Model years: 2016

Pierce Manufacturing (Pierce) is recalling certain model year 2016 Arrow-XT, Dash, Enforcer, Impel, Quantum, Saber, and Velocity fire and emergency vehicles manufactured October 13, 2015, to February 9, 2016. The fastener cap over the bearing on the universal joint of the drive shaft may have been improperly tightened.

Consequence: If the cap was not properly tightened, the cap may detach from the vehicle and become a road hazard. Additionally, the universal joint may separate and the vehicle may not be able to be driven, increasing the risk of a crash.

Remedy: Pierce will notify owners, and dealers will check and correct the tightness of all bolts for the universal joint caps, as needed, free of charge. The recall began on March 25, 2016. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B270.

Reported: 2017-07-18 (July 18, 2017) · Model years: 2016, 2017

Pierce Manufacturing (Pierce) is recalling certain 2016-2017 Arrow XT, Enforcer, Impel, Quantum, and Velocity fire trucks equipped with Hale Pump Interlock Module Kits. The Hale interlock pressure switch can fail after prolonged exposure to extreme cold temperatures, preventing the fire truck water pump from operating.

Consequence: If the fire truck cannot pump water during a fire emergency, there would be an increased risk of injury.

Remedy: Pierce will notify owners, and Hale Products dealers will replace the interlock modules, free of charge. The recall began on March 24, 2017. Owners may contact Hale customer service at 1-800-533-3569 or Pierce customer service at 1-414-832-3000. Pierce's number for this recall is 74B281.

Reported: 2021-03-30 (March 30, 2021) · Model years: 2016, 2017, 2018

Pierce Manufacturing (Pierce) is recalling certain 2016-2018 Enforcer, Freightliner and Saber vehicles equipped with ECCO Holdings Code 3 7x9 Stop-Tail-Turn Reverse All-in-One LED stop, tail, turn, and reverse lights. The rear LED lights may be too bright. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: The excessive brightness may negatively affect the vision of other drivers, increasing the risk of a crash.

Remedy: Pierce will notify owners, and dealers will provide a filter kit to be installed in the rear lights, free of charge. The recall is expected to begin April 26, 2021. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2018-10-26 (October 26, 2018) · Model years: 2017, 2018

Pierce Manufacturing (Pierce) is recalling certain 2017-2018 Pierce Arrow XT, Dash, Enforcer, Impel, Quantum, Saber, Velocity, and Commercial vehicles equipped with Whelen accessory brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.

Remedy: Pierce will notify owners, and Whelen will inspect the vehicles and replace the brake lights, as necessary, free of charge. The recall began March 4, 2019. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2021-05-26 (May 26, 2021) · Model years: 2017, 2018, 2019, 2020, 2021

Pierce Manufacturing (Pierce) is recalling certain 2017-2021 Arrow XT, Enforcer, Impel, Quantum, Saber, and Velocity vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect the rail threads and fuel lines, and replace the rail as necessary, free of charge. Interim notification letters were mailed to owners on June 24, 2021. Owner notification letters were mailed July 30, 2021. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2020-09-22 (September 22, 2020) · Model years: 2018, 2019, 2020

Pierce Manufacturing (Pierce) is recalling certain 2018-2020 Arrow XT, Dash, Enforcer, Impel, Quantum, and Velocity vehicles. Due to a problem with the joystick controller, the vehicle's aerial device may move without operator input.

Consequence: Unintended movement of the aerial device can increase the risk of injury.

Remedy: Pierce will notify owners, and dealers will replace the potentially affected joysticks, free of charge. The recall began October 20, 2020. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2023-02-17 (February 17, 2023) · Model years: 2018, 2019, 2020, 2021, 2022, 2023

Pierce Manufacturing (Pierce) is recalling certain 2018-2023 Velocity, Impel, Enforcer, and Arrow XT 110-foot aerial trucks. When the aerial platform is extended to its maximum angle, the platform mounting bracket may interfere with the basket handrail hinge peg and cause the handrail to detach from the basket.

Consequence: A basket handrail that unexpectedly detaches from the basket may increase the risk of injury to first responders using the handrail or to individuals on the ground near the vehicle.

Remedy: Dealers will install new basket handrail hinge pegs, free of charge. Owner notification letters were mailed March 16, 2023. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B326.

Reported: 2019-07-31 (July 31, 2019) · Model years: 2019

Pierce Manufacturing (Pierce) is recalling certain 2019 Arrow XT, Dash, Enforcer, Impel, Quantum, and Velocity vehicles. Due to improper manufacturing, the passenger-side knee air bag (KAB) may not properly inflate during a deployment event.

Consequence: In the event of a crash, if the KAB does not inflate properly, it may not provide the intended protection to the occupant, increasing the risk of injury.

Remedy: Pierce will notify owners, and dealers will replace the KAB assembly, free of charge. The recall began October 9, 2019. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2020-02-28 (February 28, 2020) · Model years: 2019, 2020

Pierce Manufacturing (Pierce) is recalling certain 2019-2020 Arrow XT, Enforcer, Impel, and Velocity Emergency fire emergency vehicles built with a 107 foot or 110 foot aerial device. A rectangular tube in the upper mid-section of the aerial device may develop cracks and corrosion, possibly causing one of the tube walls to fail and the aerial device to become unsteady.

Consequence: The failed tube may cause the aerial device to fall, increasing the risk of injury.

Remedy: Pierce will notify owners, and dealers will inspect for the presence of cracks and/or evidence of corrosion. If no cracks or corrosion is found, the tube will receive a treatment to prevent rust corrosion. If cracks or corrosion is present, the upper mid section of the device will be replaced. All services will be performed free of charge. The recall began March 25, 2020. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2023-12-07 (December 7, 2023) · Model years: 2019, 2020, 2021, 2022, 2023

Pierce Manufacturing (Pierce) is recalling certain 2019-2023 Arrow XT, Enforcer, and Velocity mid-mount tower trucks equipped with an aerial platform basket. The electrical connector to the aerial turntable wiring harness may not be properly secured, which can result in connector corrosion and affect the leveling ability of the platform basket.

Consequence: An inability for the platform basket to maintain level can result in the basket tipping, increasing the risk of injury.

Remedy: Pierce will replace the aerial turntable wiring harness, free of charge. Owner notification letters were mailed December 14, 2023. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B330.

Reported: 2021-01-13 (January 13, 2021) · Model years: 2020

Pierce Manufacturing (Pierce) is recalling 2020 Arrow XT, Impel, and Enforcer vehicles equipped with battery-powered 3600 wireless remote controller units used to control the movement of electric firefighting monitors in firefighting vehicles. The monitor is used to direct the water stream and adjust the spray pattern. The wireless remote controller's sleep mode is disabled, and results in the batteries discharging faster than normal.

Consequence: Inability to use the wireless remote controller may hinder the firefighting efforts, increasing the risk of injury.

Remedy: Pierce will notify owners, and dealers will return the affected controllers to Akron Brass for a software update, free of charge. The recall began on February 22, 2021. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2024-02-21 (February 21, 2024) · Model years: 2020

Pierce Manufacturing (Pierce) is recalling certain 2020 Enforcer, 2021-2022 Velocity, and 2023 Saber vehicles equipped with a specific rear bumper option. The bumper may partially obstruct the rear lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: Partially obstructed rear lights can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.

Remedy: Pierce will reposition the lights, free of charge. Owner notification letters were mailed April 15, 2024. Owners may contact Pierce customer service at 1-888-974-3723. Pierce's number for this recall is 74B333.

Reported: 2022-08-05 (August 5, 2022) · Model years: 2021, 2022

Pierce Manufacturing (Pierce) is recalling certain 2021-2022 Velocity, Impel, Enforcer, Arrow XT, Quantum, and Dash CF trucks. The steering gears may have been assembled incorrectly, which can cause the gears to fracture.

Consequence: A fractured steering gear can cause a loss of steering control, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the steering gears, as necessary, free of charge. Owner notification letters were mailed on October 4, 2022. Owners may contact Pierce's customer service at 1-888-974-3723. Pierce's number for this recall is 74B321.

Reported: 2022-12-02 (December 2, 2022) · Model years: 2022

Pierce Manufacturing (Pierce) is recalling certain 2022 Saber, Enforcer, and Arrow XT fire trucks. The tie rod clamps may have been improperly heat-treated, causing them to crack and allowing the tie rods to separate.

Consequence: Tie rod separation can result in a sudden loss of steering, increasing the risk of a crash.

Remedy: Dealers will replace the tie rod clamps, free of charge. Owner notification letters were mailed on January 26, 2023. Owners may contact Pierce's customer service at 1-888-974-3723. Pierce's number for this recall is 74B324.

Reported: 2024-12-02 (December 2, 2024) · Model years: 2023, 2024

Pierce Manufacturing (Pierce) is recalling certain 2023-2024 Enforcer, Quantum, and Velocity fire trucks. The tires mounted on the front steer axles are incompatible with the wheels. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims - Other Than Passenger Cars."

Consequence: The tires can separate from the wheels, increasing the risk of a crash.

Remedy: Pierce will supply new front steer axle wheel/tire assemblies and updated tire information labels, free of charge. Owner notification letters were mailed December 23, 2024. Owners may contact Pierce customer service at 1-888-974-3723.

Reported: 2026-02-02 (February 2, 2026) · Model years: 2025

Pierce Manufacturing (Pierce) is recalling certain 2025 Velocity, Saber, Impel, Enforcer, and Arrow XT vehicles. The steering linkage arm bolt may come loose, resulting in the steering linkage arm detaching from the steering motor.

Consequence: Steering linkage arm detachment can cause a loss of steering control, increasing the risk of a crash.

Remedy: Dealers will tighten the steering linkage arm bolts, free of charge. Owner notification letters were mailed February 10, 2026. Owners may contact Pierce customer service at 1-888-974-3723.