Monaco Coach CAYMAN recalls by model year

Reported: 2002-10-22 (October 22, 2002) · Model years: 2002, 2003

ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.

Consequence: THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2004-01-28 (January 28, 2004) · Model years: 2002, 2003, 2004

ON CERTAIN MOTORHOMES, THE I-BEAM LEAF IMITATOR IN THE FRONT AXLE SUSPENSION COULD CRACK AND BREAK DUE TO AN INADEQUATE WELDING PROCESS.

Consequence: THE I-BEAMS ON THE FRONT AXLE AND THE PANARD BRACKET ON THE REAR AXLE COULD CRACK AND BREAK CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE ORIGINAL I-BEAM. ALSO, DEALERS WILL WELD THE STIFFENERS FROM THE PANARD BAR BRACKET TO THE CENTER DIFFERENTIAL OF THE REAR AXLE HOUSING. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT MONACO AT 1-877-466-6226.

Reported: 2005-02-14 (February 14, 2005) · Model years: 2002, 2003, 2004, 2005

ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.

Consequence: THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.

Remedy: DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.

Reported: 2003-07-28 (July 28, 2003) · Model years: 2003

ON CERTAIN MOTOR HOMES, THE BATTERY CABLE THAT IS ATTACHED TO THE CIRCUIT BREAKER IS ROUTED TOO CLOSE TO THE FRAME OF THE COACH.

Consequence: THIS COULD RESULT IN THE CABLE BECOMING WORN AND CREATING AN ELECTRICAL SHORT IN THE 12-VOLT SYSTEM THAT COULD DAMAGE THE BATTERY AND/OR CIRCUIT BREAKER.

Remedy: DEALERS WILL ROTATE THE EYELET ON THE CIRCUIT BREAKER TO ELIMINATE THE POSSIBILITY OF THE CABLE RUBBING ON THE FRAME. OWNER NOTIFICATION BEGAN AUGUST 22, 2003. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.

Reported: 2005-06-21 (June 21, 2005) · Model years: 2006

CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, 'AIR BRAKE SYSTEMS.' TWO DELIVERY LINES ON THE BRAKE SYSTEM WERE INSTALLED INCORRECTLY.

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL SWITCH THE PORT HOOK-UPS OF THE TWO DELIVERY LINES ON THE AIR BRAKE SYSTEM. THE RECALL BEGAN ON AUGUST 30, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.

Reported: 2007-01-24 (January 24, 2007) · Model years: 2007

ON CERTAIN MOTOR HOMES, AN INCORRECT SCREW WAS USED TO INSTALL THE BLACK AND WHITE CRT BACK-UP MONITOR IN THE DASH. THE INCORRECT SCREWS ARE 1/4" LONGER THAN SPECIFIED AND MAY CONTACT A PC BOARD INSIDE THE MONITOR WHICH COULD POTENTIALLY HIT A HIGH VOLTAGE CIRCUIT ON THE PC BOARD OF APPROXIMATELY 10,000-13,000 VOLTS.

Consequence: IF THE SCREW MAKES CONTACT WITH THE HIGH VOLTAGE TRACER ON THE PC BOARD AND SOMEONE WOULD TOUCH THE SCREW HEAD WHILE THE POWER IS ON, AN ELECTRICAL SHOCK COULD OCCUR CAUSING INJURY.

Remedy: DEALERS WILL INSPECT THE BACK-UP MONITOR TO VERIFY THE OPERATION OF THE MONITOR FREE OF CHARGE. IF THE MONITOR IS OPERATING PROPERLY, THE REPAIR WILL CONSIST OF REPLACING THE INCORRECT SCREW WITH THE SPECIFIED SCREW AND TESTING FOR PROPER OPERATION. IF THE MONITOR IS NOT OPERATING PROPERLY ON INITIAL INSPECTION, THE MONITOR WILL BE REPLACED USING THE CORRECT SCREW. THE RECALL BEGAN ON FEBRUARY 9, 2007. OWNERS MAY CONTACT MONACO AT 877-332-9239.

Reported: 2007-09-06 (September 6, 2007) · Model years: 2007, 2008

ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

Consequence: THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

Remedy: MONACO IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR MONACO AT 1-800-685-6545.

Reported: 2010-11-17 (November 17, 2010) · Model years: 2009, 2010, 2011

NAVISTAR IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: NAVISTAR IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON DECEMBER 1, 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

Reported: 2012-02-16 (February 16, 2012) · Model years: 2009, 2010, 2011

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2008-2010 BEAVER AND CERTAIN MODEL YEAR 2009-2011 MONACO, AND CERTAIN MODEL YEAR 2009-2011 HOLIDAY RAMBLER RECREATIONAL VEHICLES, MANUFACTURED FROM OCTOBER 25, 2007, THROUGH AUGUST 26, 2010, EQUIPPED WITH IOTA ITS-50R 50 AMP AUTOMATIC TRANSFER SWITCHES. THE IOTA ITS-50R 50 AMP AUTOMATIC TRANSFER SWITCH BUS BAR AND/OR ELECTRICAL CONNECTIONS MAY BE INADEQUATE TO HANDLE THE ELECTRICAL LOAD.

Consequence: ELECTRICAL OVERLOAD OF THE TRANSFER SWITCH COULD LEAD TO OVERHEATING, AND A FIRE, INCREASING THE RISK OF PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE IOTA ITS-50R TRANSFER SWITCH FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 15, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2015-12-23 (December 23, 2015) · Model years: 2009, 2010, 2011

Allied Recreation Group, Inc. (ARG) is recalling certain model year 2010-2011 Holiday Rambler Admiral, 2009-2014 Holiday Rambler Ambassador, 2010 Holiday Rambler Arista, 2010-2014 Holiday Rambler Endeavor, 2009-2011 Holiday Rambler Neptune, 2011-2014 Holiday Rambler Vacationer, 2009-2011 Monaco Cayman, 2010-2014 Monaco Diplomat, 2014 Monaco Dynasty, 2009-2014 Monaco Knight, 2012-2013 Monaco LaPalma, 2009-2013 Monaco Monarch, 2009-2011 Monaco Riptide, 2008 Safari Passage, and 2008 Safari Simba motorhomes. The affected vehicles are equipped with certain Lippert-brand Coachstep Double Electric Steps. These steps use a bolt to attach the fan gear assembly to the steps. This bolt may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may be unstable.

Consequence: Unstable entry and exit steps increase the risk of injury.

Remedy: ARG will notify owners and dealers will install a retainer bracket to reinforce the operating mechanism, free of charge. The recall began on February 12, 2016. Owners may contact ARG customer service number at 1-800-509-3417. ARG's number for this recall is 151216REV.

Reported: 2011-11-17 (November 17, 2011) · Model years: 2011

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2009-2011 BEAVER, HOLIDAY RAMBLER AND MONACO COACH BRAND RECREATIONAL VEHICLES MANUFACTURED FROM JANUARY 11, 2008, THROUGH APRIL 15, 2011. SEE THE ABOVE LIST FOR MODELS. THE FRONT WINDSHIELD SHADE MAY SEPARATE FROM THE CABIN BODY WITHOUT WARNING, POSSIBLY IMPAIRING THE DRIVER'S ABILITY TO SEE THE ROADWAY.

Consequence: AN IMPAIRMENT TO A DRIVER'S ABILITY TO SEE THE ROADWAY COULD CAUSE A VEHICLE CRASH POTENTIALLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT THE SHADE MOUNTING CLIPS AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DECEMBER 10, 2011.OWNERS MAY CONTACT NAVISTAR AT 1-877-466-6226.