Ic Bus RE recalls by model year

Reported: 2008-07-30 (July 30, 2008) · Model years: 2007, 2008

NAVISTAR IS RECALLING 24,975 MY 2003 THROUGH 2008 IC BE, CE, HC, AND RE SCHOOL AND COMMERCIAL BUSES AND 2002 THROUGH 2008 INTERNATIONAL 3200 AND 3300 MODEL BUSES MANUFACTURED BETWEEN SEPTEMBER 21, 2001 THROUGH DECEMBER 14, 2007, EQUIPPED WITH INTERNATIONAL VT365 ENGINES. THESE VEHICLES MAY EXHIBIT ENGINE HARD START, NO START, OR STALL CONDITIONS DUE TO POSSIBLY DAMAGED TERMINALS IN THE FUSE HOLDER CONNECTOR OF THE INJECTOR DRIVE MODULE (IDM) CLEAN BATTERY POWER CIRCUITS. THE TERMINALS MAY HAVE BEEN DAMAGED DURING ELECTRICAL CONTINUITY TESTING IN THE MANUFACTURING PROCESS.

Consequence: THESE CONDITIONS COULD RESULT IN A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND REPLACE THE IDM FUSE HOLDER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 3, 2008. OWNERS CAN CONTACT NAVISTAR TOLL-FREE AT 1-800-448-7825.

Reported: 2010-06-15 (June 15, 2010) · Model years: 2007, 2008

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2008 IC BE, RE, AND CE SCHOOL BUSES MANUFACTURED FROM DECEMBER 4, 2001 THROUGH DECEMBER 14, 2009 EQUIPPED WITH INTERNATIONAL VT365 ENGINES HAVING ENGINE CALIBRATION PAN2PVR0, PAN2PVR1, OR PAN2PWR. THE ENGINE NORMALLY RESPONDS TO A FAILED OPEN ACCELERATOR POSITION SENSOR CIRCUIT FAULT BY RETURNING THE ENGINE TO LOW IDLE SPEED OF 800 RPM AND DISABLING THE DRIVER'S ABILITY TO INCREASE THE ENGINE SPEED. HOWEVER IF THE OPEN CIRCUIT CORRECTS ITSELF WITHIN 30 SECONDS OF INITIATION, ENGINE SPEED COULD SUDDENLY INCREASE TO A HIGH IDLE SPEED OF 1200 RPM.

Consequence: THIS INCREASE TO HIGH IDLE SPEED MAY OCCUR WITHOUT WARNING CAUSING A SUDDEN AND UNEXPECTED SHIFT IN VEHICLE POSITION POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825..

Reported: 2014-11-03 (November 3, 2014) · Model years: 2007, 2008, 2009, 2010, 2012

Navistar, Inc. (Navistar) is recalling certain model year 2013-2015 IC AE, 2007-2015 IC BE, CE, 2007-2011 IC FE, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Navistar will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on January 29, 2015. Owners may contact Navistar customer service at 1-331-332-1590 or Ricon customer service at 1-800-322-2884. Navistar's number for this recall is 14518.

Reported: 2015-12-22 (December 22, 2015) · Model years: 2007, 2008, 2009, 2010, 2011, 2012

Navistar, Inc. is recalling certain model year 2007-2015 IC BE and CE school buses, 2013-2015 IC AE school buses, 2007-2011 IC FE school buses, and 2007-2014 IC RE school buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy: Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on February 19, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Reported: 2009-07-28 (July 28, 2009) · Model years: 2009, 2010

NAVISTAR IS RECALLING 630 MODEL YEAR 2009 AND 2010 IC SCHOOL AND COMMERCIAL BUSES MANUFACTURED BETWEEN FEBRUARY 1, 2008 AND JULY 6, 2009, EQUIPPED WITH TRANS/AIR AIR CONDITIONING SYSTEMS. EACH TRANS/AIR SYSTEM COMES WITH AN ELECTRICAL KIT AND EC PC BOARD WHICH IF IMPROPERLY INSTALLED COULD OVERHEAT.

Consequence: OVERHEATING OF THE PC BOARD COULD RESULT IN A FIRE.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY TRANS/AIR. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT SEPTEMBER 11, 2009. OWNERS MAY CONTACT TRANS/AIR WARRANT AND SERVICE DEPARTMENT AT 1-800-673-2448 OR NAVISTAR TOLL-FREE AT 1-800-448-7825.

Reported: 2009-07-28 (July 28, 2009) · Model years: 2009, 2010

NAVISTAR IS RECALLING 3,449 IC SCHOOL BUSES MANUFACTURED BETWEEN MARCH 1, 2008 AND FEBRUARY 1, 2009, EQUIPPED WITH SPECIALTY MANUFACTURING, INC. (SMI) 000290 LED LIGHT KITS. A CHANGE TO THE WIRE USED IN THE LED LIGHT KITS MAY REDUCE THE EFFECTIVE LIFE OF THE LIGHTS USED ON THE STOP ARMS. THE LIGHTS MAY STOP FUNCTIONING WITHOUT WARNING.

Consequence: SHOULD THE LED LIGHTS STOP FUNCTIONING, VISIBILITY OF A STOPPED BUS WOULD BE DECREASED, POSSIBLY ENDANGERING A CHILD OR PEDESTRIAN TO INJURY BY PASSING VEHICLES.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY SMI. THE SAFETY RECALL BEGAN ON SEPTEMBER 19, 2009. OWNERS MAY CONTACT SMI WARRANTY SERVICE AT 1-800-951-7867 OR NAVISTAR TOLL-FREE AT 1-800-448-7825.

Reported: 2010-06-14 (June 14, 2010) · Model years: 2009, 2010

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 IC CE, FE, RE, AND BE MODEL SCHOOL BUSES MANUFACTURED FROM DECEMBER 10, 2007 THROUGH JANUARY 12, 2010 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

Remedy: NAVISTAR IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON JULY 1, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NAVISTAR AT 1-800-448-7825.

Reported: 2014-11-03 (November 3, 2014) · Model years: 2009, 2010, 2013

Navistar, Inc.(Navistar) is recalling certain model year 2007-2015 IC CE transit buses manufactured January 23,2006, to May 12, 2014, 2008, and 2011 IC FE transit buses manufactured October 5, 2006, to September 28, 2009, and 2009-2010, and 2013 IC RE transit buses manufactured September 19, 2007, to November 29, 2011, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Navistar will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The interim notices were mailed on December 29, 2014. The recall began on January 29, 2015. Owners may contact Navistar customer service at 1-331-332-1590 or Ricon customer service at 1-800-322-2884. Navistar's number for this recall is 14517.

Reported: 2015-12-23 (December 23, 2015) · Model years: 2009, 2010, 2011, 2012, 2013

Navistar, Inc. is recalling certain model year 2007-2015 IC CE transit buses, 2008-2011 IC FE transit buses and 2009-2013 IC RE transit buses equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy: Navistar will notify the purchasers of the lifts, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on February 19, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Note: These buses and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Reported: 2010-02-21 (February 21, 2010) · Model years: 2010

NAVISTAR IS RECALLING CERTAIN IC MODEL YEAR 2010 FE AND RE SCHOOL BUSES MANUFACTURED FROM JUNE 1 THROUGH AUGUST 19, 2009. THE WIRES IN THE HEADLIGHT ELECTRICAL HARNESS MAY HAVE BEEN INSTALLED IN THE INCORRECT CONNECTOR CAVITIES RESULTING IN DEGRADED LOW BEAM HEADLIGHT INTENSITY. THE VEHICLE'S LOW BEAM HEADLIGHTS DO NOT MEET THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence: THE LOW BEAM HEADLIGHT'S INTENSITY IS DECREASED INCREASING THE RISK OF A CRASH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS INSPECT THE HEADLIGHT ELECTRICAL HARNESS CONNECTOR WIRING AND REPAIR IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 12, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2010-02-21 (February 21, 2010) · Model years: 2010

NAVISTAR IS RECALLING CERTAIN IC MODEL YEAR 2010 FE AND RE TRANSIT BUSES MANUFACTURED FROM JUNE 1 THROUGH AUGUST 19, 2009. THE WIRES IN THE HEADLIGHT ELECTRICAL HARNESS MAY HAVE BEEN INSTALLED IN THE INCORRECT CONNECTOR CAVITIES RESULTING IN DEGRADED LOW BEAM HEADLIGHT INTENSITY. THE VEHICLE'S LOW BEAM HEADLIGHTS DO NOT MEET THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence: THE LOW BEAM HEADLIGHT'S INTENSITY IS DECREASED INCREASING THE RISK OF A CRASH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS INSPECT THE HEADLIGHT ELECTRICAL HARNESS CONNECTOR WIRING AND REPAIR IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 5, 2010. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2010-06-14 (June 14, 2010) · Model years: 2010, 2011

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 IC CE, FE, RE, AND BE MODEL NON SCHOOL BUSES MANUFACTURED FROM DECEMBER 10, 2007 THROUGH JANUARY 12, 2010 AND FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

Remedy: NAVISTAR IS WORKING WITH RICON AND RICON WILL BE PERFORMING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON JULY 1, 2010. OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NAVISTAR AT 1-800-448-7825.

Reported: 2011-07-21 (July 21, 2011) · Model years: 2011, 2012

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 IC RE SCHOOL BUSES MANUFACTURED FROM FEBRUARY 4, 2010, THROUGH JUNE 16, 2011. THE POSITIVE BATTERY CABLE MAY RUB ON THE HYDRAULIC COOLER RESERVOIR MOUNTING BRACKET POSSIBLY RESULTING IN AN ELECTRICAL SHORT.

Consequence: AN ELECTRICAL SHORT MAY CAUSE A FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JANUARY 2012. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2011-07-21 (July 21, 2011) · Model years: 2011, 2012

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 IC RE COMMERCIAL BUSES MANUFACTURED FROM AUGUST 24, 2010, THROUGH JUNE 8, 2011. THE POSITIVE BATTERY CABLE MAY RUB ON THE HYDRAULIC COOLER RESERVOIR MOUNTING BRACKET POSSIBLY RESULTING IN AN ELECTRICAL SHORT.

Consequence: AN ELECTRICAL SHORT MAY CAUSE A FIRE POSSIBLY RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. PARTS AVAILABILITY HAS NOT YET BEEN DETERMINED. AN INTERIM LETTER WAS MAILED IN OCTOBER 2011. THE SAFETY RECALL BEGAN ON AJNAURY 23, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2011-07-22 (July 22, 2011) · Model years: 2011, 2012

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 IC CE AND RE SCHOOL BUSES MANUFACTURED FROM OCTOBER 8, 2009, THROUGH APRIL 14, 2011. THESE BUSES WERE BUILT WITHOUT OR INCORRECTLY INSTALLED FLOOR CHANNEL REINFORCEMENTS. ACCORDINGLY, THE BUSES FAIL TO CONFORM WITH THE SEAT BACK REAR FORCE AND DISPLACEMENT REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: NONCOMPLIANCE TO THE STANDARD INCREASES THE PASSENGER'S RISK OF REARWARD EJECTION FROM THE SEAT WHICH MAY CAUSE PERSONAL INJURY OR DEATH IN THE EVENT OF A CRASH.

Remedy: NAVISTAR WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE SEPTEMBER 16, 2011. OWNERS MAY CONTACT NAVISTAR AT 1-800-448-7825.

Reported: 2019-06-21 (June 21, 2019) · Model years: 2011

Navistar, Inc. (Navistar) is recalling certain 2011 IC Bus BE, CE, and RE school buses equipped with certain non-retractable passenger two-point seat belts. After long term buckling and unbuckling of the seat belt, the plastic fingers on the male portion of the buckle may crack and fall off, requiring excessive force to buckle the seat belt.

Consequence: The seat belt may not easily buckle, increasing the risk of an injury in the event of a crash.

Remedy: Navistar will notify owners and dealers will replace the seat belt assemblies, free of charge. Navistar issued owners an interim notification on August 16, 2019. The recall began September 23, 2019. Owners may contact Navistar customer service at 1-800-448-7825.

Reported: 2012-02-16 (February 16, 2012) · Model years: 2012

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2011-2012 IC BUS BE AND CE AND CERTAIN MODEL YEAR 2012 RE SCHOOL BUSES MANUFACTURED FROM APRIL 8, 2010 THROUGH JULY 1, 2011, EQUIPPED WITH C. E. WHITE SEAT CUSHIONS. THE SELF-LATCHING MECHANISM USED TO RETAIN THE SEAT CUSHION TO THE FRAME MAY NOT ACTIVATE. THUS, THESE SEATS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Consequence: IF THE SEAT CUSHION IS NOT SECURELY LATCHED TO THE SEAT STRUCTURE, THE SEAT COULD BECOME DISLODGED, INCREASING THE RISK OF INJURY TO THE VEHICLE OCCUPANTS.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE SEATS FREE OF CHARGE. OWNERS MAY CONTACT NAVISTAR AT 260-461-1890.

Reported: 2012-02-16 (February 16, 2012) · Model years: 2012

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2012-2013 IC BUS CE AND RE SCHOOL BUSES MANUFACTURED FROM DECEMBER 2, 2010, THROUGH JANUARY 26, 2012, AND EQUIPPED WITH BENDIX ATR-6 ANTILOCK TRACTION RELAY VALVES. IN EXTREMELY COLD CONDITIONS, THESE BENDIX RELAY VALVES MAY POTENTIALLY DEVELOP INTERNAL LEAKAGE. INTERNAL LEAKAGE CAN LEAD TO AIR PRESSURE BEING DELIVERED TO AFFECTED PRIMARY OR SECONDARY BRAKES CAUSING CONTINUOUS BRAKE APPLICATION.

Consequence: UNEXPECTED CONTINUOUS BRAKE APPLICATION CAN CAUSE THE DRIVER TO LOSE CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH. ALSO, THE BRAKES MAY BE APPLIED WITHOUT ILLUMINATING THE BRAKE LIGHTS, FAILING TO GIVE PROPER WARNING TO OTHER DRIVERS.

Remedy: NAVISTAR WILL NOTIFY OWNERS, AND DEALERS WILL PROVIDE A TEMPORARY REPAIR UNTIL BENDIX DEVELOPS A PERMANENT REMEDY. THE SAFETY RECALL BEGAN ON APRIL 40, 2012. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. OWNERS MAY CONTACT NAVISTAR AT 260-461-1890.

Reported: 2012-06-21 (June 21, 2012) · Model years: 2012

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2012 AND 2013 IC CE, RE, AND BE SCHOOL BUSES MANUFACTURED FROM APRIL 1, 2011, THROUGH MARCH 31, 2012, EQUIPPED WITH PROLO ROOF ESCAPE HATCHES. INCREASED FRICTION BETWEEN THE REAR PLATE ASSEMBLIES, P/NO. 009327, AND THE NYLON REAR POP-UP SUPPORT, P/NO. 008956, MAY RESULT IN AN OPENING FORCE OF THE PROLO ROOF HATCHES THAT EXCEEDS FEDERAL STANDARD REQUIREMENTS. THUS, THESE HATCHES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

Consequence: IN THE EVENT OF AN EMERGENCY, EGRESS OF THE BUS MAY BE HINDERED POSSIBLY RESULTING IN INJURY TO THE VEHICLE OCCUPANTS.

Remedy: NAVISTAR WILL NOTIFY OWNERS. SPECIALTY MANUFACTURING, INC. (SMI) WILL PROVIDE SERVICE KITS ALONG WITH REPAIR INSTRUCTIONS TO DEALERS AND OWNERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 3, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890 OR SMI AT 1-800-951-7867.

Reported: 2012-06-21 (June 21, 2012) · Model years: 2012, 2013

NAVISTAR IS RECALLING CERTAIN MODEL YEAR 2012 AND 2013 IC BUS CE AND RE COMMERCIAL BUSES MANUFACTURED FROM APRIL1, 2011, THROUGH MARCH 31, 2012, EQUIPPED WITH PROLO ROOF ESCAPE HATCHES. INCREASED FRICTION BETWEEN THE REAR PLATE ASSEMBLIES, P/NO. 009327, AND THE NYLON REAR POP-UP SUPPORT, P/NO. 008956, MAY RESULT IN AN OPENING FORCE OF THE PROLO ROOF HATCHES THAT EXCEEDS FEDERAL STANDARD REQUIREMENTS. THUS, THESE HATCHES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE."

Consequence: IN THE EVENT OF AN EMERGENCY, EGRESS OF THE BUS MAY BE HINDERED POSSIBLY RESULTING IN INJURY TO THE VEHICLE OCCUPANTS.

Remedy: NAVISTAR WILL NOTIFY OWNERS. SPECIALTY MANUFACTURING, INC. (SMI) WILL PROVIDE SERVICE KITS ALONG WITH REPAIR INSTRUCTIONS TO DEALERS AND OWNERS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 3, 2012. OWNERS MAY CONTACT NAVISTAR AT 1-260-461-1890 OR SMI AT 1-800-951-7867.

Reported: 2013-01-17 (January 17, 2013) · Model years: 2012

Navistar is recalling certain model year 2013 IC brand CE buses, and 2012-2013 RE buses; manufactured from December 7, 2010, through June 26, 2012 and equipped with model year 2011 through 2013 I-6 engines and feature codes 12NUK, 12NUL, 12NUM, 12NUN, 12NUP and 12NUS. The injection pressure regulator (IPR) harness wire may break due to vibrational damage. This could cause an unexpected shut down of the engine.

Consequence: An unexpected engine shut down while driving may increase the risk of a vehicle crash.

Remedy: Navistar will notify owners, and dealers will replace the IPR wire connector, free of charge. The safety recall is expected to begin by March 18, 2013. Owners may contact Navistar at 1-800-448-7825.

Reported: 2013-08-07 (August 7, 2013) · Model years: 2012

Navistar, Inc. is recalling certain model year 2013-2014 IC Bus AE, and 2011-2014 BE, CE, and RE buses. These buses were manufactured February 11, 2010, through June 17, 2013. The passenger seat foam padding did not adequately reduce the impact forces to the knee in the lower outside corners of the seat back during compliance testing. Thus, these buses fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 222, "School Bus Passenger Seating and Crash Protection."

Consequence: In the event of a crash, the seat padding may not properly protect against knee impact force, increasing the risk of injury.

Remedy: Navistar will notify owners, and dealers will install polystyrene blocks in the lower outside corners of each seat to increase the knee protection, free of charge. The recall began on October 10, 2013. Owners may contact Navistar at 1-800-448-7825. Navistar's recall campaign number is 13512.

Reported: 2013-01-17 (January 17, 2013) · Model years: 2013

Navistar is recalling certain model year 2012-2013 IC Bus brand model 1300FBC, CE, HC, and RE buses; model year 2011-2013 International brand model Durastar, model year 2013 International brand Workstar trucks; model year 2013 Holiday Rambler brand model Ambassador and Endeavor vehicles; and model year 2013 Monaco brand model Diplomat and Knight vehicles. These vehicles were manufactured August 5, 2010 through September 6, 2012 and are equipped with certain 2011-2013 model year I-6 engines with feature codes 12NUK, 12NUL, 12NUM, 12NUN, 12NUP, 12NUR, 12NUS, 12NUT, 12NUU, 12NUV, 12NUX, 12NUY and 12NUZ. The injection pressure regulator (IPR) harness wire may break due to vibrational damage. This could cause an unexpected shut down of the engine.

Consequence: An unexpected engine shut down while driving may increase the risk of a vehicle crash.

Remedy: Navistar will notify owners, and dealers will replace the IPR wire connector free of charge. The safety recall began on March 15, 2013. Owners may contact Navistar at 1-800-448-7825.

Reported: 2017-10-18 (October 18, 2017) · Model years: 2018

Navistar, Inc. (Navistar) is recalling certain 2015-2018 IC Bus RE school buses. The drop hose fittings for the air brakes may not be oriented correctly, and, as a result, the brake hoses may contact the tire when the wheels are turned to the limit.

Consequence: Contact with the tires may damage the service brake air hose, causing the brakes to become inoperative or lengthening the distance needed to stop the bus, increasing the risk of a crash.

Remedy: Navistar will notify owners, and dealers will reposition the drop hose fittings and replace any damaged drop hose or wheel speed sensor harness, free of charge. The recall began on November 21, 2017. Owners may contact Navistar customer service at 1-331-332-4331. Navistar's number for this recall is 17510.

Reported: 2022-04-27 (April 27, 2022) · Model years: 2022

Navistar, Inc. (Navistar) is recalling certain 2022-2023 International MV, International HV, and 2022 IC RE commercial buses built without a forward radar unit. The warning label notifying the driver that the collision mitigation system is inoperative may be missing.

Consequence: Failure to warn the driver that the collision mitigation system is inoperative increases the risk of a crash.

Remedy: Navistar will provide a warning label and installation instructions, free of charge. Owner notification letters were mailed June 14, 2022. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 22508.

Reported: 2022-05-23 (May 23, 2022) · Model years: 2022

Navistar, Inc. is recalling certain 2022-2023 IC CE, IC RE, and 2023 IC EV school buses. The steering wheel retaining nut may have been tightened incorrectly, which can allow the steering wheel to loosen and detach from the steering column shaft.

Consequence: A loose or detached steering wheel increases the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Dealers will remove the steering wheel nut, apply thread locker, and reinstall the nut, free of charge. Owner notification letters were mailed on May 25, 2022. Owners may contact Navistar, Inc. customer service at (331) 332-1590. Navistar's number for this recall is 22511.

Reported: 2022-05-23 (May 23, 2022) · Model years: 2022, 2023

Navistar, Inc. (Navistar) is recalling certain 2022-2023 IC CE, IC RE and 2023 IC 1300FBC transit buses. The steering wheel retaining nut may have been tightened incorrectly, which can allow the steering wheel to loosen and detach from the steering column shaft.

Consequence: A loose or detached steering wheel increases the risk of a crash.

Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Dealers will remove the steering wheel nut, apply thread locker, and reinstall the nut, free of charge. Owner notification letters are expected to be mailed May 2022. Owners may contact Navistar, Inc. customer service at 1-331- 332-1590. Navistar number for this recall is 22512.

Reported: 2023-02-10 (February 10, 2023) · Model years: 2022, 2023

Navistar, Inc. (Navistar) is recalling certain 2022-2023 IC Bus CE, and 2022-2023 IC RE transit buses. The roof panel may have been manufactured with insufficient joint strength.

Consequence: A school bus roof panel with insufficient joint strength may separate during a crash, increasing the risk of injury.

Remedy: Dealers will add additional fasteners to secure the joints, free of charge. Owner notification letters are expected to be mailed April 3, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23502.

Reported: 2023-05-25 (May 25, 2023) · Model years: 2022, 2023

Navistar, Inc. (Navistar) is recalling certain 2021-2024 International HV, HX, LoneStar, LT, MV, eMV, and RH trucks, and IC Bus CE, 2021-2023 IC Bus RE, and 2022-2023 IC Bus TC Commercial Buses. The anti-lock brake system (ABS) indicator light does not remain illuminated when a malfunction exists, and when the vehicle's ignition switch is on, and the vehicle is in motion. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Consequence: An ABS indicator light that fails to remain illuminated will not alert the driver of an ABS malfunction, which could increase the risk of a crash.

Remedy: Towing variant vehicles under this campaign will not be repaired under recall 24V-8918. Dealers will update the software, free of charge. Owner notification letters are expected to be mailed July 24, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23515.

Reported: 2022-11-23 (November 23, 2022) · Model years: 2023

Navistar, Inc. (Navistar) is recalling certain 2021-2022 International CV, 2022-2023 International HV, 2023 IC 1300 FBC, CE, RE, TC, International MV, HX, LT, RH, and LoneStar vehicles. The hex flange lock nuts, used in the suspension and steering joints, were improperly heat treated and may lose tension over time.

Consequence: A loss of tension in the steering and suspension joints may lead to steering instability and increase the risk of a crash.

Remedy: Dealers will replace the hex flange lock nuts as necessary, free of charge. Owner notification letters are expected to be mailed January 20, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 22524.