Freightliner M2 problems and owner complaints

TL*THE CONTACT OWNS A 2006 FREIGHTLINER M2 LIGHT CHASSIS. THE CONTACT STATED THAT BOTH FRONT BRAKE CALIPERS LOCKED, HEATED UP AND ALMOST CAUGHT FIRE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE FRONT BRAKES WERE DISABLED AS A TEMPORARY FIX. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHO REPLACED THE TWO FRONT CALIPERS. THE REAR DRIVER SIDE CALIPERS WERE MALFUNCTIONING AS WELL. THE VEHICLE WAS BEING REPAIRED; HOWEVER, THE DEALER CONTACTED THE MANUFACTURER WHO WOULD NOT ACKNOWLEDGE THE FAILURE. THE CURRENT MILEAGE WAS 19,450. THE FA…

Owner-reported narrative. 18,400 miles reported. Look up ODI 10403883 at NHTSA ↗

THIS FREIGHTLINER M2 HAS BEEN MADE INTO A MOTORHOME BY DYNAMAX CORP. THE CRUISE CONTROL AND BRAKE SYSTEM ARE FREIGHTLINER. I NOTICED THAT THE CRUISE CONTROL DID NOT ALWAYS DISENGAGE WHEN THE BRAKES WERE APPLIED AND I HAD TO SWITCH IT OFF MANUALLY. UPON FURTHER CHECKING, THE BRAKE LIGHTS WERE ALSO NOT COMING ON WHEN BRAKES WERE APPLIED. I CHECKED THE RECALLS AND THE EXACT SAME PROBLEM WAS UNDER RECALL #10V178000. THE LOCAL FREIGHTLINER DEALER SAID MY VEHICLE DID NOT COME UNDER THE RECALL BECAUSE IT USED DIFFERENT SWITCH. MY SWITCH IS A FORD #3F2…

Owner-reported narrative. 64,498 miles reported. Look up ODI 10714793 at NHTSA ↗

The transmission lines where it connects to the radiator are leaking just like on the recall there is for the 2014 and up years of the freightliner m2 business class

Owner-reported narrative. Look up ODI 11455793 at NHTSA ↗

FLYWHEEL SHEARED OFF (COMPLETELY NO TEETH AROUND THE CIRCUMFERENCE). TRANSMISSION NOT DROPPED DOWN TO CONFIRM BUT CURRENTLY THERE ARE NOT TEETH ON FLYWHEEL TO MESH WITH STARTER TEETH.CANNOT SEE ANY TEETH THROUGH INSPECTION HOLE.

Owner-reported narrative. 257,165 miles reported. Look up ODI 11129707 at NHTSA ↗

The contact owns a 2021 Freightliner M2. The contact stated that while a driver was driving at an undisclosed speed, the vehicle started decelerating unintendedly and then stalled. There were no warning lights illuminated. The driver was able to coast to the side of the roadway. The driver was unable to restart the vehicle. The vehicle was towed to the dealer who stated that there was an excessive amount of oil in the engine. The dealer determined that the engine had failed and needed to be replaced. The dealer linked the failure to NHTSA Campa…

Owner-reported narrative. 151,024 miles reported. Look up ODI 11634557 at NHTSA ↗

The contact owns a 2021 Freightliner XC-M. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 21V00H000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING) and 21V921000 (TIRES). The contact had not experienced a failure. The contact reached out to the manufacturer with questions about the recalls. The vehicle was repaired under NHTSA Campaign Number: 21V00H000 (ELECTRICAL SYSTEM, EXTERIOR LIGHTING). However, the manufacturer informed the contact that the repair for NHTSA Campaign Number: 21V921000 (TIRES) would not be completed b…

Owner-reported narrative. Look up ODI 11719221 at NHTSA ↗

SWAY BAR VERTICAL LINK BUSHINGS ARE PULVERIZED COMPLETELY GONE WITHIN 1500 MILES AFTER REPLACEMENT CAUSING AN UNSAFE TOP HEAVY ROLL OF THE MOTORHOME REDUCING STEERING CONTROL OF THE VEHICLE. I'VE HAD FREIGHTLINER SAN DIEGO REPLACE THESE BUSHING, I'VE REPLACED THEM TWICE, AND HAD A SUSPENSION SHOP REPLACE THEM ONCE. EVERY OTHER SENECA OWNER BUILT ON THE FREIGHTLINER M2 CHASSIS EXPERIENCES THE SAME ISSUE. FREIGHTLINER RECOGNIZES THERE IS AN ISSUE THROUGH A TECHNICAL SERVICE BULLETIN TSB-32-47, BUT HAS NOT ISSUED A RECALL ADDRESSING THIS SERIOUS …

Owner-reported narrative. 5,600 miles reported. Look up ODI 11043725 at NHTSA ↗