Ford F-750 SD recalls by model year

Reported: 2007-06-05 (June 5, 2007) · Model years: 2007

ON CERTAIN TRUCKS BUILT WITH DANA REAR AXLES, THE REAR AXLE MAY HAVE A HOUSING THAT WAS BUILT USING STEEL THAT WAS THINNER THAN SPECIFIED.

Consequence: THROUGH NORMAL USE, THE AXLE HOUSING COULD FATIGUE AND DEVELOP A CRACK WHICH COULD RESULT IN A WHEEL END LOCK-UP OR SEPARATION, POSSIBLY RESULTING IN A CRASH.

Remedy: DEALERS WILL REPLACE THE AXLE FREE OF CHARGE. THE RECALL BEGAN ON JUNE 12, 2007. OWNERS MAY CONTACT FORD AT 1-800-248-0186.

Reported: 2007-11-20 (November 20, 2007) · Model years: 2008

ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR C7 OR C9 DIESEL ENGINES, A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND MAY CAUSE THE TURBOCHARGER TO FAIL AND CAUSE LOSS OF THROTTLE CONTROL WITH WARNING.

Consequence: THE WARNING MAY BE EXPERIENCED BY ERRATIC PERFORMANCE AND EXCESSIVE SMOKE. BOTH OF THESE CONDITIONS MAY RESULT IN A SITUATION WHERE A VEHICLE CRASH COULD OCCUR.

Remedy: FORD IS WORKING WITH CATERPILLAR TO HAVE THE FUEL PUMP REPLACED FREE OF CHARGE (PLEASE SEE 07E053). OWNERS MAY CONTACT CATERPILLAR AT 309-675-6496 OR FORD AT 1-800-392-3673.

Reported: 2008-08-25 (August 25, 2008) · Model years: 2008, 2009

FORD IS RECALLING 2,811 MY 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: FORD IS WORKING WITH CATERPILLAR (PLEASE SEE 08E042). CATERPILLAR WILL REPLACE THE FUEL PUMP PLUG FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT 1-800-447-4986, OR FORD AT 1-800-343-5338 (FLEET OWNERS) OR 1-866-906-9811 (MOTOR HOME OWNERS).

Reported: 2010-09-09 (September 9, 2010) · Model years: 2008, 2009

FORD IS RECALLING CERTAIN MODEL YEAR 2008-2009 F-650 AND F-750 TRUCKS EQUIPPED WITH CATERPILLAR C7 ENGINE. THE #5 AND #6 FUEL LINES MAY CRACK AT THE FASTENING POINT TO THE COMMON FUEL RAIL AND CAUSE A FUEL LEAK.

Consequence: A FUEL LEAK, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A VEHICLE FIRE.

Remedy: FORD IS WORKING WITH CATERPILLAR TO NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY AUTHORIZED CATERPILLAR DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 8, 2010. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR FORD AT 1-866-436-7332.

Reported: 2015-08-20 (August 20, 2015) · Model years: 2011, 2012, 2013, 2015

Ford Motor Company (Ford) is recalling certain model year 2011-2013 and 2015 Ford F-650, and F-750 trucks manufactured February 14, 2011, to April 28, 2015, and equipped with a 70% fixed bench passenger seat. The affected vehicles have passenger seat belt anchorage floor attachments that are not installed in the correct location. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

Consequence: Seat belt anchors that are installed in an incorrect location may increase the risk of occupant injury in the event of a crash.

Remedy: Ford will notify owners, and dealers will correct the seat belt anchorage locations, free of charge. The recall began on November 12, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C09.

Reported: 2014-09-02 (September 2, 2014) · Model years: 2015

Ford Motor Company (Ford) is recalling certain model year 2015 Ford F-650 SD trucks manufactured May 12, 2014, to July 22, 2014 and Ford F-750 SD trucks manufactured May 12, 2014, to August 4, 2014. The Cummins ISB or ISL engines in these vehicles may have been equipped with Fleetguard UFF-XT fuel filters, part number FF63009, whose filter shell may separate from the fuel filter nut plate causing the engine to stall without warning.

Consequence: If the engine stalls unexpectedly there is an increased risk of a crash.

Remedy: Cummins will notify the owners of the affected Ford vehicles, and Cummins service centers will replace the fuel filter with a non-defective one, free of charge. The recall began in September 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14V01. Owners may also contact Cummins customer service at 1-800-223-4583.

Reported: 2016-03-31 (March 31, 2016) · Model years: 2015, 2016

Ford Motor Company (Ford) is recalling certain model year 2015-2016 F-650 and F-750 trucks manufactured January 28, 2015, to November 30, 2015. The clip that connects the hand operated parking brake actuator cable to the intermediate parking brake cable may fail.

Consequence: If the parking brake cable connector clip fails, the vehicle may unexpectedly roll, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the parking brake cable connector clip, free of charge. The recall began on May 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S15.

Reported: 2017-09-25 (September 25, 2017) · Model years: 2015

Ford Motor Company (Ford) is recalling certain 2015 F-650 and F-750 trucks, equipped with certain Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.

Consequence: If the tie rod loosens, it may disconnect from the steering knuckle, causing a loss of steering control at lower speeds and increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary, free of charge. The recall is expected to begin November 20, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S30.

Reported: 2015-12-22 (December 22, 2015) · Model years: 2016

Ford Motor Company (Ford) is recalling certain model year 2016 Ford F-650 and F-750 trucks manufactured April 15, 2015, to December 15, 2015, and equipped with rear air suspension. In the affected vehicles, the rear brake hoses may contact and chafe on the rear axle housing while driving.

Consequence: A chafed rear brake line may result in an air leak, reducing the rear braking ability and increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will install revised rear brake air chambers and replace any damaged rear air brake lines, free of charge. The recall began on February 9, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S38.

Reported: 2018-04-04 (April 4, 2018) · Model years: 2018

Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.

Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.

Reported: 2018-05-16 (May 16, 2018) · Model years: 2018

Ford Motor Company (Ford) is recalling certain 2018 Ford F-650 and F-750 vehicles equipped with hydraulic brakes. The parking brake cable may not have been adjusted properly, which may result in unexpected vehicle movement. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 105, "Hydraulic and Electric Brake Systems."

Consequence: For vehicles equipped with a transmission that does not have a 'Park' position or a transmission that has a 'Park' position but the transmission lever is not placed in 'Park', an improperly adjusted park brake cable could result in unintended movement of the vehicle, increasing the risk of a crash or injury.

Remedy: Ford will notify owners, and dealers will correct the parking brake cable adjustment, free of charge. The recall began on May 25, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18C05.

Reported: 2018-06-11 (June 11, 2018) · Model years: 2018

Ford Motor Company (Ford) is recalling certain 2018 Ford F-650 and F-750 trucks. The brake circuit hose assemblies located between the master cylinder and the hydraulic control unit, may have been manufactured without anti-corrosion plating on the coupling fittings, or "ferrules," of the hoses. This can lead to premature corrosion, and result in a brake fluid leak.

Consequence: A brake fluid leak can reduce brake effectiveness, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the brake hose assemblies, free of charge. The recall began on July 17, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S19.

Reported: 2020-07-17 (July 17, 2020) · Model years: 2021

Ford Motor Company (Ford) is recalling certain 2021 F-650 and F-750 trucks equipped with 7.3L gasoline engines. The underbody heat shield and other heat-protection components were not installed during assembly. Without these components, the interior cabin floor and seat attachments may reach elevated temperatures in certain driving conditions.

Consequence: Skin contact with certain areas of the cabin interior floor or seat attachments in these high temperature conditions may cause injury.

Remedy: Ford will notify owners, and dealers will install the missing underbody heat shield, thermal insulator patch, seat base covers, and seat bolt covers, free of charge. The recall began September 28, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S36.

Reported: 2024-02-23 (February 23, 2024) · Model years: 2023, 2024

Ford Motor Company (Ford) is recalling certain 2023-2024 F-650 and F-750 vehicles. The parking brake may malfunction and allow the lever to be released without pressing the release button.

Consequence: A parking brake that is released unexpectedly may result in a vehicle roll away, increasing the risk of a crash or injury.

Remedy: Dealers will replace the parking brake handle assembly. Owner notification letters were mailed on June 17, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S09.

Reported: 2023-09-08 (September 8, 2023) · Model years: 2024, 2025

Ford Motor Company (Ford) is recalling certain 2024-2025 Ford E-350, F-650, and F-750 vehicles. The park pawl may not fully engage the park gear due to a casting defect in the transmission.

Consequence: A vehicle which does not have the park pawl fully engaged may result in a vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the transmission, or the valve body and extension housing, as necessary, free of charge. Owner notification letters were mailed January 16, 2024. Owners may contact Ford's customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S54.

Reported: 2024-06-28 (June 28, 2024) · Model years: 2025

Ford Motor Company (Ford) is recalling certain 2025 F-Super Duty F-650 and F-750 vehicles. The front axle tie rod assemblies may contain ball studs that have been incorrectly heat-treated, which can cause them to break, and possibly result in tie rod failure.

Consequence: Tie rod failure can cause a loss of vehicle steering control and increase the risk of a crash.

Remedy: Dealers will inspect and replace the front axle tie rod assembly as necessary, free of charge. Owner notification letters were mailed August 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S42.