Fleetwood STORM recalls by model year

Reported: 2007-03-19 (March 19, 2007) · Model years: 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004

CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Reported: 1996-11-22 (November 22, 1996) · Model years: 1997

THE E-Z SLIDE-OUT ROOM CAN OPERATE UNEXPECTEDLY. WATER CAN CAUSE AN ELECTRICAL SHORT IN THE SLIDE-OUT ROOM CONTROL RELAY.

Consequence: IF THE SLIDE-OUT ROOM OPERATES UNEXPECTEDLY, THE MOTOR HOME WIDTH WILL INCREASE WHICH COULD LEAD TO AN ACCIDENT IF TRAVELING OR PROPERTY DAMAGE COULD OCCUR WHILE THE MOTOR HOME IS PARKED.

Remedy: DEALERS WILL INSTALL A REPLACEMENT CONTROL RELAY IN A WATERPROOF LOCATION ON THESE MOTOR HOMES.

Reported: 1998-04-21 (April 21, 1998) · Model years: 1998

VEHICLE DESCRIPTION: MOTOR HOMES. DUE TO IMPROPER INSTALLATION OF ELECTRICAL WIRES, THE BATTERY CABLES CAN CONTACT THE AUTOMATIC TRANSMISSION COOLER FLUID LINES. THE IGNITION SWITCH AND CUSTOMER ACCESSORY WIRING IS UNDERSIZED.

Consequence: THIS CONDITION CAN RESULT IN DAMAGE TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT, AND POSSIBLY A FIRE. THE UNDERSIZED WIRING CAN RESULT IN THE ENGINE STOPPING WITH A RESULTANT LOSS OF POWER STEERING OR POWER BRAKING, LEADING TO A POSSIBLE CRASH.

Remedy: DEALERS WILL INSPECT AND REPAIR THESE VEHICLES, INCLUDING REPLACEMENT OF ANY DAMAGED WIRING OR OTHER VEHICULAR COMPONENTS.

Reported: 1998-11-05 (November 5, 1998) · Model years: 1998, 1999

VEHICLE DESCRIPTION: CLASS A MOTOR HOMES. THE HYDRAULIC HOSES WHICH OPERATE THE LEVELING JACK SYSTEM WERE ROUTED TOO CLOSE TO THE ENGINE EXHAUST OR NEAR A SHARP EDGE. THE HOT EXHAUST CAN CAUSE THE HOSE TO MELT, AND A SHARP EDGE COULD CUT THE HOSE, RELEASING HYDRAULIC FLUID.

Consequence: HYDRAULIC FLUID LEAKAGE CAN BE IGNITED BY THE ENGINE'S CATALYTIC CONVERTER AND CAUSE A FIRE.

Remedy: DEALERS WILL INSPECT THE LINES AND, IF NECESSARY, REPLACE AND REROUTE THE LINES.

Reported: 2003-03-04 (March 4, 2003) · Model years: 2000, 2001, 2002

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Remedy: DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-445-3307.

Reported: 2003-11-04 (November 4, 2003) · Model years: 2000, 2001, 2002, 2003, 2004

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR FLEETWOOD AT 1-800-629-8454.

Reported: 2009-06-02 (June 2, 2009) · Model years: 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008

FLEETWOOD IS RECALLING 509 MY 2001-2008 CLASS A MOTOR HOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731. WORKHORSE WILL CONDUCT THE OWNER AND DEALER NOTIFICATION.

Reported: 2004-07-20 (July 20, 2004) · Model years: 2003, 2004

CERTAIN MOTOR HOMES EQUIPPED WITH DRAW TITE HITCH RECEIVERS MAY BE MISSING ONE OR MORE WELDS BETWEEN THE HITCH RECEIVER BOX AND THE BOTTOM SUPPORT PLATE.

Consequence: THE WELDS COULD BREAK, ALLOWING THE HITCH RECEIVER BOX AND THE TOWED LOAD TO SEPARATE FROM THE TOWING VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE HITCH RECEIVER. THE RECALL IS EXPECTED TO BEGIN DURING AUGUST 2004. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.

Reported: 2006-04-12 (April 12, 2006) · Model years: 2003, 2004

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101 "CONTROLS AND DISPLAYS" AND NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.

Consequence: AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN AND REPROGRAM THE INSTRUMENT PANEL CLUSTER FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2008-07-15 (July 15, 2008) · Model years: 2003, 2004, 2005, 2006, 2007

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Remedy: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2006-10-04 (October 4, 2006) · Model years: 2004, 2005, 2006

ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GENERAL MOTORS 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.

Consequence: IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.

Remedy: WORKHORSE IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2006-06-19 (June 19, 2006) · Model years: 2005, 2006

ON CERTAIN CLASS A MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.

Consequence: THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFTS. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2006-02-23 (February 23, 2006) · Model years: 2006

ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC ENTRY STEP BUILT WITH A CONTROL UNIT MANUFACTURED BY AMERICAN TECHNOLOGIES, MAY DEVELOP AN ELECTRICAL SHORT DURING COLD WEATHER, ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE.

Consequence: THIS WILL MAKE THE STEP INOPERABLE AND POSSIBLY RESULT IN A RISK OF PERSONAL INJURY, VEHICLE OR OTHER PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE ALL AMERICAN TECHNOLOGIES CONTROLS ASSOCIATED WITH THE KWIKEE BRAND ELECTRIC ENTRY STEP FREE OF CHARGE. THE RECALL BEGAN ON MARCH 17, 2006. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Reported: 2010-06-28 (June 28, 2010) · Model years: 2011

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2010 ENCOUNTER AND MODEL YEAR 2011 STORM 28MS CLASS A MOTOR HOMES MANUFACTURED FROM DECEMBER 16, 2009 THROUGH JULY 1, 2010. AN EMERGENCY EGRESS WINDOW WAS NOT INSTALLED IN THE ROAD SIDE BEDROOM WALL. IN THE EVENT OF A FIRE OR OTHER EMERGENCY, PERSONS IN THE BEDROOM AREA MUST EXIT THROUGH THE DOOR SIDE BEDROOM EMERGENCY EGRESS WINDOW OR THROUGH THE FORWARD ENTRY DOOR.

Consequence: IF THE ENTRY DOOR AND THE DOOR SIDE BEDROOM EMERGENCY EGRESS WINDOWS ARE BLOCKED, THERE IS NO WAY OUT OF THE MOTOR HOME INCREASING THE RISK OF PERSONAL INJURY.

Remedy: DEALERS WILL REMOVE THE EXISTING ROAD SIDE WINDOW AND REPLACE IT WITH AN EMERGENCY EGRESS WINDOW. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 28, 2010. OWNERS MAY CONTACT FLEETWOOD OWNER RELATIONS AT 800-509-3418.

Reported: 2010-10-29 (October 29, 2010) · Model years: 2011

FLEETWOOD IS RECALLING CERTAIN CLASS-A AND CLASS-C MOTOR HOMES EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Remedy: FLEETWOOD IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749.

Reported: 2011-05-24 (May 24, 2011) · Model years: 2011

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2011 BOUNDER CLASSIC, STORM AND TERRA CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 21, 2010, THROUGH FEBRUARY 11, 2011. CERTAIN MODEL YEAR 2011 BOUNDER AND SOUTHWIND CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 24, 2010 THROUGH MAY 18, 2011; AND CERTAIN MODEL YEAR 2012 BOUNDER AND SOUTHWIND CLASS A MOTOR HOMES BUILT ON FORD CHASSIS AND MANUFACTURED FROM MAY 16, 2011 THROUGH JUNE 15, 2011. A WIRE HARNESS THAT IS ROUTED UNDER THE MOTOR HOME, NEAR THE CHASSIS RAIL, CAN CONTACT A HEAT SHIELD LOCATED NEXT TO THE PASSENGER SIDE ENGINE EXHAUST MANIFOLD. THE CLOSE PROXIMITY CAN CAUSE THE HARNESS TO MELT OR BE OTHERWISE DAMAGED.

Consequence: A DAMAGED WIRE HARNESS CAN RESULT IN AN ELECTRICAL SHORT, RESULT IN INTERMITTENT OPERATION OF ELECTRICAL SYSTEMS VEHICLE "SHUT DOWN", AND/OR LEAD TO A FIRE, AND MAY RESULT IN LOSS OF VEHICLE CONTROL, INJURY, OR DEATH.

Remedy: DEALERS WILL INSPECT AND REROUTE THE WIRE HARNESS AWAY FROM THE HEAT SHIELD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2011. OWNERS MAY CONTACT FLEETWOOD OWNER RELATIONS AT 1-800-509-3418.

Reported: 2012-11-06 (November 6, 2012) · Model years: 2011, 2012, 2013

Fleetwood RV is recalling certain model year 2010 and 2011 Encounter vehicles manufactured from November 19, 2009, through May 13, 2010; 2011-2013 Storm vehicles manufactured from May 21, 2010, through September 18, 2012; and 2012 Terra vehicles manufactured from April 26, 2011, through March 13, 2012. The entry step to the motorhome lacks sufficient support and may become damaged by repeated use.

Consequence: The step may collapse during use potentially causing personal injury.

Remedy: Fleetwood RV will notify owners, and dealers will inspect and, as necessary, reinforce the step structural support. The safety recall began during December 2012. Owners may contact Fleetwood RV Owner Relations at 1-800-509-3418.

Reported: 2013-05-10 (May 10, 2013) · Model years: 2014

Fleetwood RV, Inc. is recalling certain model year 2013 Jamboree Sport Diesel, Providence, Tioga DSL and Tioga Ranger DSL; 2014 Excursion, Expedition, Jamboree Sport, Montara Commercial, Searcher Commercial, Southwind, Storm, Terra, and Tioga Ranger; and 2013-2014 Bounder, Bounder Classic, and Discovery recreational vehicles. The vehicles are equipped with Weatherpro and 9100 series power awnings. Due to a design change in the power awning motor assembly, the motor assembly screws may unknowingly shear.

Consequence: If the motor assembly screws shear, it is possible that the awning can unfurl unexpectedly, either while the vehicle is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

Remedy: Fleetwood RV will notify owners and Dometic staff will replace the affected motors with motors of a different design. The recall began during June 2013. Owners may contact Fleetwood RV Owner Relations at 1-800-509-3418 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed.

Reported: 2013-11-20 (November 20, 2013) · Model years: 2014

Fleetwood RV, Inc. (Fleetwood) is recalling certain model year 2014 model American Eagle, American Heritage, American Revolution, American Tradition, Bounder, Bounder Classic, Discovery, Excursion, Expedition, Providence, South Wind, Storm, Terra, Terra SE, Jamboree Searcher, Jamboree Sport, Tioga Montara, and Tioga Ranger recreational vehicles equipped with IMMI-brand L9 seat belt assemblies. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Consequence: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy: Fleetwood will notify owners and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall began on January 17, 2014. Owners may contact Fleetwood at 1-800-322-8216. Fleetwood's recall number 131112FRV.

Reported: 2015-07-21 (July 21, 2015) · Model years: 2016

Allied Recreation Group, Inc. (ARG) is recalling certain model year 2016 Fleetwood Flair, Storm, Terra SE, Jamboree Sport, Tioga Montara, Tioga Ranger, Holiday Rambler Admiral, and Monaco Trek vehicles. The affected vehicles may have been improperly manufactured with a vertical propane gas tank regulator, instead of the horizontal gas tank regulator required. Use of the incorrect regulator can allow moisture to build up in the regulator, possibly resulting in improper operation.

Consequence: If the regulator fails to operate properly, it can cause a propane gas leak, increasing the risk of a fire.

Remedy: ARG will notify owners, and dealers will inspect the motorhomes and replace the regulator, as necessary, free of charge. The recall began on August 14, 2015. Owners may contact ARG customer service at 1-800-509-3417. ARG's number for this recall is 150708ARG.

Reported: 2017-03-03 (March 3, 2017) · Model years: 2016, 2017

REV Recreation Group (REV) is recalling certain 2015 Fleetwood Bounder Classic motorhomes, 2015-2016 Fleetwood Terra motorhomes, 2016-2017 Fleetwood Storm, Holiday Rambler Admiral XE and Fleetwood Flair motorhomes, and 2017 Holiday Rambler Vacationer XE motorhomes. The affected vehicles, equipped with an Onan 5.5 Kilowatt Generator, have an external fuel pump and in-line fuel filter that may be improperly secured to the chassis.

Consequence: If the fuel pump or filter detach or become loose, a fuel leak may result, which in the presence of an ignition source, can increase the risk of a fire or explosion.

Remedy: REV will notify owners, and dealers will inspect the mounting of the generator's external fuel pump and in-line fuel filter, securing them as necessary, free of charge. The recall began on April 28, 2017. Owners may contact REV customer service at 1-800-509-3417. REVs number for the recall is 170301REV.

Reported: 2017-01-03 (January 3, 2017) · Model years: 2017

REV Recreation Group (REV) is recalling certain 2017 Holiday Rambler Vacationer XE, Admiral XE, Fleetwood Storm and Fleetwood Flair motor homes. The rear sway bar may not have been properly tightened and, as a result, the sway bar may detach from the vehicle.

Consequence: If the sway bar falls from the vehicle, it can increase the risk of a crash.

Remedy: REV will notify owners, and dealers will tighten the rear sway bar bolts, replacing them as necessary, free of charge. The recall began on March 3, 2017. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 161229REV.

Reported: 2017-02-03 (February 3, 2017) · Model years: 2017

REV Recreation Group (REV) is recalling certain 2017 Fleetwood Storm and Holiday Rambler Vacationer XE motorhomes and 2016-2017 Holiday Rambler Vacationer motorhomes. In the affected vehicles, the spring shackle bolt may contact the fuel filler components or the fuel vent tubing causing a hole, potentially resulting in a fuel leak.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: REV will notify owners, and dealers will inspect the fuel filler tube and fuel vent components and re-route them or install additional components to shield them from contacting the spring shackle bolt, free of charge. The recall began on April 4, 2017. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 170131REV.

Reported: 2018-03-28 (March 28, 2018) · Model years: 2017, 2018

REV Recreation Group (REV) is recalling certain 2018 Fleetwood Axon and Pulse, Holiday Rambler Reno and Prodigy, Monaco Marquis and American Coach American Dream motorhomes, 2017-2018 Fleetwood Bounder, Discovery, Discovery LXE, Flair, Jamboree, Southwind, Pace Arrow, Pace Arrow LXE and Storm motorhomes, Holiday Rambler Admiral XE, Endeavor, Endeavor XE, Navigator XE, Navigator, Vacationer, Vacationer XE and Vesta and American Coach American Eagle motorhomes and 2017 Holiday Rambler Scepter, Monaco Diplomat, and American Coach American Revolution motorhomes. The mounting screws for the satellite dish may not have been fastened through the sheet steel reinforcement, possibly allowing the satellite dish to detach from the roof while driving.

Consequence: If the satellite dish detaches from the roof while driving, it can increase the risk of a crash or injury.

Remedy: REV will notify owners, and dealers will resecure the satellite dish to the roof with a metal reinforcement, free of charge. The recall began on May 14, 2018. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 180322REV. Note: This recall supersedes recall 17V-802. Any vehicle repaired under that campaigned is not included in this one as the remedy for both recalls is the same.

Reported: 2017-07-27 (July 27, 2017) · Model years: 2018

REV Recreation Group (REV) is recalling certain 2017-2018 Fleetwood Discovery and Discovery LXE, and Holiday Rambler Endeavor, Endeavor XE, and Admiral XE motorhomes, as well as 2018 Monaco Diplomat, Fleetwood Pace Arrow, Bounder, Flair, and Storm motorhomes, and Holiday Rambler Navigator and Vacationer XE motorhomes. The affected vehicles may have been manufactured with headlights that do not have tempered glass lenses.

Consequence: If the headlamp lens is not tempered, it may crack or break, which may cause decreased illumination and/or premature failure of the headlight bulb, increasing the risk of a crash.

Remedy: REV Recreation Group will notify owners, and authorized REV dealers will inspect, and if necessary, replace non-tempered, defective headlamp lenses with new headlamp lenses, free of charge. The recall began on September 8, 2017. Owners may contact REV customer service at 1-800-509-3417. REVs number for the recall is 170720REV.

Reported: 2024-08-13 (August 13, 2024) · Model years: 2018

REV Recreation Group (REV) is recalling certain 2019-2025 Holiday Rambler Admiral, 2018 Holiday Rambler Admiral XE, Fleetwood Storm, 2023-2025 Holiday Rambler Eclipse, Fleetwood Flex, 2018-2025 Fleetwood Flair, 2020-2024 Fleetwood Fortis, 2020-2025 Holiday Rambler Invicta, 2018-2023 Fleetwood Pace Arrow, and 2018-2019 Holiday Rambler Vacationer XE motorhomes, equipped with the HappiJac drop down bed option. The front overhead cabinet fasteners can break, allowing the overhead cabinet to detach.

Consequence: A cabinet that detaches while the vehicle is in motion can distract the driver, increasing the risk of a crash.

Remedy: Dealers will inspect and install new hardware and fasteners as necessary, free of charge. Owner notification letters were mailed October 7, 2024. Owners may contact REV customer service at 1-800-509-3417. REV's number for this recall is 240809REV.