Fleetwood AMERICAN EAGLE recalls by model year

Reported: 1995-07-26 (July 26, 1995) · Model years: 1991, 1992, 1993, 1994, 1995

A LOW AIR PRESSURE WARNING LIGHT LOCATED IN THE DRIVER'S INSTRUMENT CLUSTER FAILS TO ACTIVATE IF THE FRONT BRAKE AIR RESERVOIR SYSTEM FALLS BELOW 60 PSI. THIS DOES NOT COMPLY WITH FMVSS NO.121, "AIR BRAKE SYSTEMS."

Consequence: CONSEQUENCE OF NON-COMPLIANCE: LOW AIR PRESSURE IN THE FRONT BRAKE SYSTEM COULD LEAD TO DECREASED VEHICLE BRAKING PERFORMANCE OR CAUSE THE EMERGENCY BRAKE SYSTEM TO ENGAGE WITHOUT THE DRIVER GIVEN VISUAL OR AUDIBLE WARNING.

Remedy: DEALERS WILL INSTALL A WIRING HARNESS WHICH CORRECTLY CONNECTS THE FRONT BRAKE RESERVOIR SYSTEM LOW PRESSURE SWITCH TO THE LOW AIR PRESSURE WARNING LIGHT LOCATED IN THE DRIVER'S INSTRUMENT CLUSTER.

Reported: 1999-10-15 (October 15, 1999) · Model years: 1996, 1997, 1998, 1999, 2000

VEHICLE DESCRIPTION: MOTOR HOMES. THE SUBJECT MOTOR HOMES, WHEN BUILT WITH A DISPROPORTIONATE FRONT AXLE WEIGHT DISTRIBUTION, FULLY EQUIPPED, LOADED WITH CARGO, AND OPERATED WITH IMPROPER TIRE PRESSURES, CAN EXPERIENCE AN OVERLOAD CONDITION ON A FRONT TIRE.

Consequence: OVERLOADING OF A TIRE CAN LEAD TO TIRE FAILURE.

Remedy: DEALERS WILL EQUIP THE SUBJECT MOTOR HOMES WITH NEW LARGER CAPACITY FRONT TIRES, WILL ADJUST THE WEIGHT DISTRIBUTION ON THE FRONT AXLE (IF NECESSARY), APPLY NEW CERTIFICATION LABELS, AND REINFORCE CONSUMER EDUCATION ABOUT THE IMPORTANCE OF TIRE MAINTENANCE, INCLUDING ROTATION, ALIGNMENT, AND TIRE INFLATION PRESSURE.

Reported: 2007-03-19 (March 19, 2007) · Model years: 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004

CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: FLEETWOOD WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST YOU IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2000-07-03 (July 3, 2000) · Model years: 1998, 1999

VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH GRANNING AIR SUSPENSIONS. A FRACTURE CAN DEVELOP AT THE ATTACHMENT POINT OF THE CROSS MEMBER/BELL CRANK AND IDLER ARM HOUSING.

Consequence: THIS DEFECT MAY CAUSE ERRATIC OR LOSS OF STEERING CONTROL IF THE CROSS MEMBER SEPARATES FROM THE ASSEMBLY.

Remedy: TUTHILL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. REPAIR FACILITIES WILL INSPECT AND ADD GUSSETS TO REINFORCE THE CROSS MEMBER CONNECTION FOR THE BELL CRANK AND IDLER ARM. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TUTHILL CUSTOMER SERVICE NUMBER AT 1-800-255-7824 OR FLEETWOOD AT 1-909-351-7638.

Reported: 2006-05-22 (May 22, 2006) · Model years: 1998, 1999

ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH SPARTAN CHASSIS STEERING GEAR, THE STEERING GEAR SUPPORT BRACKET HAS THE POTENTIAL TO FAIL WHEN SUBJECT TO THE REPETITIVE FORCES OF STATIC STEERING CONDITIONS.

Consequence: LOSS OF STEERING CONTROL COULD OCCUR INCREASING THE RISK OF A CRASH.

Remedy: SPARTAN CHASSIS IS CONDUCTING THIS RECALL (PLEASE SEE 06V156000) AND WILL REPLACE THE STEERING SUPPORT BRACKET FREE OF CHARGE. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216 OR SPARTAN AT 517-543-6400.

Reported: 2008-06-03 (June 3, 2008) · Model years: 1999, 2000, 2001

FLEETWOOD IS RECALLING CERTAIN CLASS A GAS AND DIESEL MOTOR HOMES, CLASS C MOTOR HOMES, CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATORS. A LOW CYCLE FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH GENERATES THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Remedy: FLEETWOOD IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR FLEETWOOD AT 1-800-509-3418.

Reported: 1999-07-02 (July 2, 1999) · Model years: 1999

VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH AIR SUSPENSIONS. THE FRONT WHEEL SPINDLE BEARING MAY HAVE EXCESSIVE PRELOAD DUE TO IMPROPER END PLAY SETTINGS.

Consequence: THIS BEARING PRELOAD IN COMBINATION WITH IMPROPER LUBRICATING OIL LEVELS CAN CAUSE PREMATURE FAILURE OF THE OUTER BEARING, AFFECTING THE STEERING ON THE MOTOR HOMES.

Remedy: TUTHILL IS CONDUCTING THE NOTIFICATION AND REMEDY FOR THIS RECALL. TUTHILL WILL INSPECT THE DEFLECTOR RING AND RESEATING, ADJUST THE WHEEL BEARINGS, ADD LUBRICATION, AND REPLACE THE HUBCAP.

Reported: 2009-07-28 (July 28, 2009) · Model years: 2000, 2001, 2002, 2003

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 MOTORHOMES MANUFACTURED BETWEEN JULY 24, 2004 AND MARCH 11, 2005, EQUIPPED WITH NORCOLD MODEL 1200LR, 1200LRIM, AND 1201LRIM REFRIGERATORS WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy: FLEETWOOD RV WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2009. OWNERS MAY CONTACT FLEETWOOD RV AT 1-800-509-3418 OR NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Reported: 2001-01-09 (January 9, 2001) · Model years: 2001

VEHICLE DESCRIPTION: CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE WIRING TO THE HEADLAMP ASSEMBLIES IS INCORRECT CAUSING A LOW BRIGHTNESS OF THE HEADLAMPS.

Consequence: THIS REDUCED LIGHTING LEVEL WILL AFFECT DRIVER VISIBILITY.

Remedy: DEALERS WILL REWIRE THE CONNECTORS THAT PLUG INTO THE HEADLAMPS. OWNER NOTIFICATION BEGAN JANUARY 26, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-445-3307.

Reported: 2002-05-31 (May 31, 2002) · Model years: 2002

ON CERTAIN MOTORHOMES EQUIPPED WITH ARVINMERITOR WABCO PNEUMATIC ANITLOCK BRAKE SYSTEM (ABS) VALVE PACKAGES, THE ASSEMBLY BOLTS ON THESE VALVE PACKAGES WERE NOT TIGHTENED CORRECTLY.

Consequence: BOLTS TORQUED BELOW SPECIFICATION WILL NOT RELIABLY PREVENT AIR LEAKAGE AT THE AFFECTED ABS VALVE PACKAGE INTERFACE JOINTS ONCE THE COMPONENT BEGINS NORMAL VEHICLE OPERATION. IF AIR LEAKS DEVELOP AT ANY OF THE ABS VALVE PACKAGE INTERFACE JOINTS, BRAKE SYSTEM PRESSURE REDUCTIONS COULD OCCUR DURING BRAKING OR NORMAL OPERATION WITH UNITS EQUIPPED WITH THE TRACTION CONTROL OPTION, POTENTIALLY EXTENDING STOPPING DISTANCES, POSSIBLY RESULTING IN A VEHICLE CRASH.

Remedy: DEALERS WILL TIGHTEN THE FASTENERS TO THE PROPER SPECIFICATION. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ARVINMERITOR WABCO AT 1-859-746-5956 OR FLEETWOOD AT 1-800-629-8454.

Reported: 2005-05-12 (May 12, 2005) · Model years: 2003, 2004, 2005

ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.

Consequence: THE SURFACE TEMPERATURE OF THE EXHAUST TUBE EXITING FROM THE HEATER CAN INCREASE AND COULD POTENTIALLY IGNITE COMBUSTIBLE MATERIALS IN OR AROUND THE VEHICLE.

Remedy: VEHICLE SYSTEMS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2008-07-15 (July 15, 2008) · Model years: 2003, 2004, 2005, 2006, 2007

FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.

Remedy: FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2003-08-20 (August 20, 2003) · Model years: 2004

ON CERTAIN MOTOR HOMES, THE ELECTRIC POWER FOR THE ENTRY DOORSTEP "LAST OUT" FEATURE HAS NOT BEEN PROVIDED AND THE ENTRY DOORSTEP WILL NOT OPERATE IN "LAST OUT" MODE. THE "LAST OUT" IS A SAFETY FEATURE THAT CAUSES THE ENTRY DOORSTEP TO EXTEND ONE LAST TIME IF THE ENTRY DOORSTEP POWER SWITCH IS OFF AND THE VEHICLE IGNITION IS TURNED OFF.

Remedy: DEALERS WILL INSPECT AND PROVIDE POWER SO THE ENTRY DOORSTEP "LAST OUT" FEATURE IS ACTIVE. OWNER NOTIFICATION BEGAN SEPTEMBER 10, 2003. OWNERS SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.

Reported: 2004-01-28 (January 28, 2004) · Model years: 2004

ON CERTAIN MOTORHOMES BUILT ON SPARTAN CHASSIS, THE ANGLE OF THE HOSES FROM THE HYDRAULIC PUMP COULD CONTACT THE POSITIVE STUD ON THE STARTER.

Consequence: THIS COULD RESULT IN CLOSE CONTACT WITH THE STARTER AND CAUSE IGNITION OF HYDRAULIC FLUID WHICH COULD RESULT IN INJURY AND/OR PROPERTY DAMAGE.

Remedy: SPARTAN IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPLACE ON VEHICLES WITH CUMMINS ISL ENGINES AND 39MT DELCO STARTERS AT LEAST ONE OF THE 45 DEGREE FITTINGS WITH A 90 DEGREE FITTING AND ALSO REPLACE THE HOSE ASSEMBLY. ON ISL AND ISC ENGINES WITH 42MT DELCO STARTER, DEALERS WILL CHANGE ONE FITTING AT THE REAR OF THE HYDRAULIC PUMP AND RE-ROUTE A HOSE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SPARTAN AT 1-517-543-6400 OR FLEETWOOD AT 1-800-322-8216.

Reported: 2004-04-22 (April 22, 2004) · Model years: 2004

ON CERTAIN MOTORHOMES, THE TIRE PRESSURES WRITTEN ON THE CERTIFICATION TAG WAS INCORRECT. THE CORRECT TIRE PRESSURES SHOULD BE 120 PSI FOR THE FRONT TIRES AND 95 PSI FOR THE REAR TIRES.

Consequence: THESE VEHICLES DO NOT COMPLY WITH THE REGULATIONS.

Remedy: FLEETWOOD CONTACTED EACH CUSTOMER BY TELEPHONE AND MAILED THE CORRECTED FEDERAL TIRE TAG. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FLEETWOOD AT 1-800-322-8216.

Reported: 2005-04-25 (April 25, 2005) · Model years: 2004, 2005

ON CERTAIN CLASS A MOTOR HOMES, A PNEUMATIC LINE CAN BECOME PINCHED BETWEEN THE HYDRAULIC FILTER AND A COMPARTMENT DOOR STRUT. THE CHAFFING CAUSED BY OPENING AND CLOSING OF THE COMPARTMENT DOOR CAN CAUSE THE FILTER TO RUPTURE AND RESULT IN A HYDRAULIC FLUID LEAK.

Consequence: THIS LOSS OF HYDRAULIC FLUID CAUSES THE POWER STEERING FEATURE TO NOT FUNCTION. THIS CAN RESULT IN LOSS OF VEHICLE CONTROL, PERSONAL INJURY OR A VEHICLE CRASH.

Remedy: DEALERS WILL INSPECT, REPLACE OR REPAIR DAMAGED LINES AND RELOCATE THE AFFECTED HYDRAULIC LINES FREE OF CHARGE. THE RECALL BEGAN ON JUNE 15, 2005. OWNERS MAY CONTACT FLEETWOOD AT 1-800-435-7345.

Reported: 2007-12-14 (December 14, 2007) · Model years: 2004, 2005

ON CERTAIN CLASS A MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH ZF MODEL 8018 STEERING GEARS, THESE GEARS MAY HAVE BEEN ASSEMBLED WITH THE INCORRECT RECIRCULATING BALL SPACER. THIS COULD POTENTIALLY ALLOW THE RECIRCULATING BALLS TO ESCAPE FROM THE RECIRCULATING BALL CIRCUIT RESULTING IN A LOSS OF STEERING.

Consequence: THE OPERATOR MAY NOTICE HIGHER REQUIRED STEERING WHEEL INPUTS, OR THE NEED FOR MORE STEERING WHEEL ADJUSTMENTS WHILE DRIVING IN A STRAIGHT LINE IN COMBINATION WITH METALLIC CRACKING NOISES PRIOR TO A LOSS OF STEERING. LOSS OF STEERING COULD RESULT IN A VEHICLE CRASH.

Remedy: FLEETWOOD IS WORKING WITH FREIGHTLINER AND ZF TO REPLACE THE STEERING GEAR FREE OF CHARGE (PLEASE SEE 07V343 AND 07E049). OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216 OR FREIGHTLINER AT 1-800-547-0712.

Reported: 2007-02-16 (February 16, 2007) · Model years: 2007

ON CERTAIN AMERICAN EAGLE AND AMERICAN TRADITION CLASS A MOTOR HOMES, THE ANTI-LOCK BRAKE SYSTEM (ABS) MODULE MAY NOT HAVE BEEN PERMANENTLY MOUNTED. THE MODULE COULD DETACH FROM THE VEHICLE.

Consequence: THE ANTI-LOCK FEATURE FOR THE BRAKE SYSTEM COULD BE LOST.

Remedy: DEALERS WILL INSPECT AND PERMANENTLY MOUNT THE ABS MODULE TO THE INSIDE OF THE CHASSIS RAIL. THE RECALL BEGAN ON MARCH 30, 2007. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.

Reported: 2007-03-14 (March 14, 2007) · Model years: 2007

ON CERTAIN CLASS A MOTOR HOMES, THE SERVICE COMPARTMENT THAT CONTAINS THE INVERTER AND THE HOUSE BATTERIES IS INSUFFICIENTLY SEALED FROM SPARK PRODUCING DEVICES. IN THE EVENT OUT GASSING OCCURS FROM THE BATTERIES AND THE GASES ARE EXPOSED TO A SPARK OF MEASURABLE SIZE AND DURATION, IGNITION OF THE GASSES MAY OCCUR.

Consequence: THIS HAS THE POTENTIAL TO IGNITE COMBUSTIBLE OBJECTS WITHIN THE COMPARTMENT.

Remedy: DEALERS WILL INSPECT AND INSTALL A COMPARTMENT SPACER AND BULB SEAL TO THE SERVICE COMPARTMENT THAT CONTAINS THE HOUSE BATTERIES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 30, 2007. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.

Reported: 2007-08-15 (August 15, 2007) · Model years: 2007, 2008

ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence: EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy: THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Reported: 2008-07-01 (July 1, 2008) · Model years: 2008, 2009

FLEETWOOD IS RECALLING 226 MY 2008-2009 AMERICAN ALLEGIANCE, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER DIESEL, DISCOVERY, EXCURSION, EXPEDITION, FIESTA LX, PACE ARROW, PROVIDENCE, REVOLUTION LE, SOUTHWIND, CLASS A MOTOR HOMES, AND ICON, JAMBOREE, JAMBOREE GT, JAMBOREE SPORT, PULSE, TIOGA, AND TIOGA RANGER CLASS C MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF THE CODE OF FEDERAL REGULATIONS, PART 567, 'CERTIFICATION.' THE OCCUPANT AND CARGO CARRYING CAPACITY WERE CALCULATED INCORRECTLY ALLOWING ADDITIONAL LOAD CARRYING CAPACITY.

Consequence: OVERLOADING MAY HAVE AN ADVERSE AFFECT ON MOTOR HOME HANDLING, INCREASING THE RISK OF A CRASH.

Remedy: FLEETWOOD WILL MAIL A CORRECTED FEDERAL CERTIFICATION LABEL ALONG WITH INSTALLATION INSTRUCTIONS TO THE AFFECTED MOTOR HOME OWNERS. OWNERS WHO DO NOT FEEL COMFORTABLE INSTALLING THIS LABEL CAN TAKE THEIR MOTOR HOME TO ANY FLEETWOOD DEALER AND THE DEALER WILL INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON JULY 28, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.

Reported: 2008-09-26 (September 26, 2008) · Model years: 2008, 2009

FLEETWOOD IS RECALLING 65 MY 2008-2009 AMERICAN ALLEGIANCE, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, AND REVOLUTION L.E. MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE LABEL WAS PRINTED WITH THE REAR AND INTERMEDIATE TIRE PSI RATING REVERSED.

Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING OR TIRE INFLATION WHICH COULD RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: OWNERS WILL BE PROVIDED WITH CORRECTED CERTIFICATION LABELS AND INSTALLATION INSTRUCTIONS. A DEALER CAN INSTALL THIS LABEL FOR THE OWNER AT NO CHARGE. THE RECALL BEGAN ON OCTOBER 9, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.

Reported: 2011-07-22 (July 22, 2011) · Model years: 2010, 2011

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2009 AMERICAN ALLEGIANCE, AMERICAN HERITAGE, REVOLUTION LE; MODEL YEAR 2010 AMERICAN EAGLE, AMERICAN HERITAGE, REVOLUTION LE, AND MODEL YEAR 2011 AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, DISCOVERY, PROVIDENCE, AND REVOLUTION LE, CLASS A MOTOR HOMES MANUFACTURED FROM SEPTEMBER 4, 2009, THROUGH JANUARY 5, 2011. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION". THE FEDERAL CERTIFICATION TAG FIGURES RELATED TO THE INTERMEDIATE AND REAR TIRE PRESSURE RATINGS, IN KILOPASCALS (KPA), WERE PRINTED IN THEIR REVERSE POSITIONS.

Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: FLEETWOOD RV WILL MAIL THE CORRECT FEDERAL CERTIFICATION TAGS TO DEALERS AND OWNERS ALONG WITH INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2011. OWNERS MAY CONTACT FLEETWOOD OWNER RELATIONS AT 1-800-509-3418.

Reported: 2011-08-03 (August 3, 2011) · Model years: 2010, 2011

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2010 AMERICAN EAGLE, AMERICAN TRADITION, DISCOVERY, REVOLUTION LE, AND MODEL YEAR 2011 AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER CLASSIC, DISCOVERY, EXPEDITION, PROVIDENCE, REVOLUTION LE, AND SOUTHWIND CLASS A MOTOR HOMES EQUIPPED WITH MURRAY OR SIEMENS BRAND CIRCUIT BREAKERS. THESE CIRCUIT BREAKERS HAVE A NON-CONFORMING "SPRING CLIP" PLUG-IN ASSEMBLY THAT BREAKS OR FAILS TO PROVIDE SUFFICIENT FORCE TO MAINTAIN A PROPER ELECTRICAL CONNECTION IN THE PANEL BOARD.

Consequence: THIS CONDITION COULD LEAD TO EXCESSIVE TEMPERATURE, ARCING OR THERMAL DAMAGE AT THE CONNECTION POINT, AND POTENTIAL DAMAGE TO THE PANEL BOARD'S ELECTRICAL INSULATION. THIS COULD LEAD TO FIRE, PROPERTY DAMAGE, OR PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT AND REPLACE THE CIRCUIT BREAKERS IF NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 25, 2011. OWNERS MAY CONTACT FLEETWOOD OWNER RELATIONS AT 1-800-509-3418.