Coachmen AURORA recalls by model year

Reported: 2011-02-04 (February 4, 2011) · Model years: 1997

COACHMEN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: COACHMEN IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

Reported: 2003-10-14 (October 14, 2003) · Model years: 2000, 2001, 2002

ON CERTAIN MOTOR HOMES, TRAVEL TRAILERS, AND FIFTH WHEEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR COACHMEN AT 1-219-825-5821.

Reported: 2003-02-10 (February 10, 2003) · Model years: 2002, 2003

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.

Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.

Remedy: DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION BEGAN MARCH 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-219-825-5821.

Reported: 2004-10-27 (October 27, 2004) · Model years: 2002, 2003

ON MOTOR HOME CHASSIS BUILT BY WORKHORSE AND EQUIPPED WITH BOSCH BRAKES, THE PADS CAN DRAG ON THE ROTOR SURFACE DUE TO THE PIN SLIDE.

Consequence: A HANG UP OR LOCK UP MAY CAUSE THE CALIPERS TO OVER HEAT AND NOT ALLOW THE DRIVER TO STOP SAFELY. THIS COULD CAUSE OVERHEATING OF THE BRAKE CALIPERS WHICH COULD RESULT IN A VEHICLE FIRE.

Remedy: WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPAIR THE BRAKE CALIPER. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-294-6773 OR COACHMEN AT 219-825-5821.

Reported: 2009-06-02 (June 2, 2009) · Model years: 2002, 2003, 2006, 2007, 2009

COACHMEN IS RECALLING 2,555 MY 2000-2009 GEORGIE BOY AND COACHMEN RECREATIONAL TRAILERS EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR COACHMEN AT 1-574-266-4030, option 5.

Reported: 2005-03-11 (March 11, 2005) · Model years: 2003

ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 101, "CONTROLS AND DISPLAY" AND STANDARD NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." MODELS WITH ACTIA INSTRUMENT CLUSTER, THE INCORRECT SOFTWARE PROGRAMMED INTO THE CLUSTER SUCH THAT CERTAIN WARNINGS ARE NOT DISPLAYED.

Consequence: INCORRECT SOFTWARE MAY NOT HAVE THE ABILITY TO ILLUMINATE WARNING LAMPS INDICATING BRAKE SYSTEM FAILURES. THE STANDARDS REQUIRE DRIVER WARNING WHEN BRAKE FAILURE CODES ARE SET.

Remedy: WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR COACHMEN AT 574-825-5821.

Reported: 2008-06-25 (June 25, 2008) · Model years: 2004, 2005, 2006, 2007

COACHMEN IS RECALLING 37,293 MOTORHOMES AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Remedy: COACHMEN IS WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COACHMEN AT 574-825-5821.

Reported: 2005-03-17 (March 17, 2005) · Model years: 2005

ON CERTAIN CLASS A MOTOR HOMES, THE REAR HITCH ATTACHMENT BRACKETS THAT CONNECT THE HITCH ASSEMBLY TO THE CHASSIS FRAME MAY CRACK AT THE 90 DEGREE BEND.

Consequence: IF THIS WERE TO OCCUR, A COMPLETE SEPARATION OF THE HITCH ASSEMBLY FROM THE CHASSIS COULD OCCUR, RESULTING IN A CRASH DUE TO A LOSS OF CONTROL OF THE TOWED VEHICLE OR TRAILER.

Remedy: DEALERS WILL REPAIR THE HITCH ASSEMBLY ATTACHMENT BRACKETS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 24, 2005. OWNERS MAY CONTACT COACHMEN AT 1-800-453-6064.

Reported: 2007-10-16 (October 16, 2007) · Model years: 2006

ON CERTAIN MOTOR HOMES, THE SPARE TIRE CARRIER ASSEMBLY MOUNTED UNDER THE REAR OF THE UNIT IS THE INCORRECT MODEL TO PROPERLY SUPPORT THE SPARE TIRE.

Consequence: AS A RESULT, THE POTENTIAL EXISTS FOR THE SPARE TIRE TO BECOME DETACHED FROM THE CARRIER ASSEMBLY AND FALL TO THE ROAD SURFACE. SHOULD THE SPARE TIRE DETACH ITSELF FROM THE CARRIER WHILE THE VEHICLE IS IN MOTION, A CRASH MAY RESULT.

Remedy: DEALERS WILL INSTALL THE CORRECT SPARE TIRE SYSTEM AND ALSO A SECONDARY MECHANICAL BACK-UP LATCH. THE RECALL BEGAN ON DECEMBER 5, 2007. OWNERS MAY CONTACT COACHMEN AT 1-800-453-6064.

Reported: 2008-12-04 (December 4, 2008) · Model years: 2006

COACHMEN IS RECALLING 13,662 MY 2002-2008 MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH GLASS SHOWER DOORS AND MANUFACTURED FROM JUNE 15, 2001 THORUGH AUGUST 6, 2007. WHEN PRESSURE IS APPLIED TO THE TOWEL BAR ON THE GLASS SHOWER DOOR, THE EDGE OF THE BAR MAY CONTACT THE GLASS.

Consequence: GLASS BREAKAGE MAY OCCUR WHICH COULD CAUSE PERSONAL INJURY.

Remedy: OWNERS WILL BE PROVIDED WITH NEW MOUNTING HARDWARE FOR THE TOWEL BAR AND INSTALLATION INSTRUCTIONS. IF AN OWNER IS NOT COMFORTABLE REPLACING THE HARDWARE THEMSELVES, A DEALER WILL INSTALL THE HARDWARE AT NO COST TO THEM. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 19, 2008. OWNERS MAY CONTACT COACHMEN AT 1-574-825-5821.

Reported: 2015-11-25 (November 25, 2015) · Model years: 2009

Forest River, Inc. (Forest River) is recalling certain 2014 FR3, 2009 Forest River Encore, Sportscoach Elite, and Aurora, 2008-2009 Cruise Master, 2012-2015 Aviator, 2007-2014 Georgetown, 2007-2009 Legend, 2008-2012 Ridgeview, 2008-2014 Cross Country, 2010-2014 Coachmen Encounter, 2009-2014 Pathfinder, Solera, Mirada, Prism, and Pursuit motorhomes. The affected vehicles are equipped with certain Lippert-brand Coachstep Double and Triple Electric Steps. These steps use a bolt to attach the fan gear assembly to the steps. This bolt may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may be unstable.

Consequence: Unstable entry and exit steps increase the risk of injury.

Remedy: Forest River will notify owners and dealers will install a retainer bracket to reinforce the operating mechanism, free of charge. Forest River issued an interim notification to owners on January 7, 2016. The recall began on March 3, 2016. Owners may contact Forest River customer service number at 1-574-389-4600. Forest River's number for this recall is 51-11102015-0109. Or owners can contact Lippert Components at 1-574-537-8900.

Reported: 2021-09-17 (September 17, 2021) · Model years: 2022

Forest River, Inc. (Forest River) is recalling certain 2022 Forest River Aurora travel trailers. These trailers were manufactured with the incorrect tires, size ST225/75R15 LRD, instead of tire size ST225/75R15 LRE, as identified on the Federal Placard.

Consequence: The incorrectly-sized tires can become overloaded, increasing the risk of a crash.

Remedy: Dealers will replace the tire and wheel assemblies, free of charge. Owner notification letters were mailed September 24, 2021. Owners may contact Forest River customer service 1-574-825-6327. Forest River's number for this recall is 205-1420.

Reported: 2022-03-08 (March 8, 2022) · Model years: 2022

Forest River, Inc. (Forest River) is recalling certain 2022 Coachmen Catalina, Aurora, Apex, Freedom Express, Spirit, Work N Play, Forest River XLR Toy Hauler, Vengeance, Sabre, Cherokee, and Cardinal travel trailers and fifth wheels. The wire cord that connects to the back of the 50AMP shore power inlet may be loose.

Consequence: Loose wires may contact each other and cause an electrical short, increasing the risk of a fire.

Remedy: Dealers will replace the shore cord inlet, free of charge. Owner notification letters were mailed April 5, 2022. Owners may contact the following customer service numbers: Forest River 1-574-825-4995; Catalina & Aurora 1-574-825-8657; APEX 1-574-825-8205; Freedom Express & Work n Play 1-574-825-6302; Cardinal 1-574-296-7700; Cherokee and Vengeance 1-260-499-2100; Sabre 1-574-642-2100; and XLR 1-574-642-0432. Forest River's number for this recall is 51-1485.