U.S. public vehicle records

Yamaha FZ-09 recalls by model year

Explore the records behind recurring owner reports.

Key facts

26 owner complaints analyzed

3 distinct recall campaigns

2,200 mi median reported failure mileage

Scope: 2014 to 2017 model years. Data updated: 2026-11-01 (November 1, 2026). 22 complaints include usable failure mileage. View data status.

Compare model years

Recalls by model year

All campaigns in the snapshot affecting each model year, including recalls announced years later.

From yearThrough year

Recall campaigns

Shared campaigns appear once in each affected model year.

2014

2015

2016

2017

2014: 1; 2015: 2; 2016: 1; 2017: 1

First model yearSecond model year

Year-by-year records

Yamaha FZ-09 model-year comparison
Model year	Complaints	Recalls	Change in recalls
2014	12	1	Not available
2015	10	2	+1
2016	1	1	-1
2017	3	1	0

Recall history

3 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.

14V550000 · Exterior Lighting:Headlights

Reported: 2014-09-10 (September 10, 2014) · Model years: 2014

Yamaha Motor Corporation, USA (Yamaha) is recalling certain model year 2014 Yamaha FZ09 motorcycles manufactured August 1, 2013, to August 29, 2014. The affected motorcycles may have a headlight harness that is too short and when the handlebars are turned fully to the left or right the harness may break near the coupler or coupler may disconnect from the headlight bulb.

Consequence: If the harness breaks or the coupler detaches from the headlight, the headlight will go out, reducing the rider's visibility and increasing the risk of a crash.

Remedy: Yamaha will notify owners, and dealers will install a sub-harness to lengthen the headlight harness, free of charge. The recall is expected to begin on September 22, 2014. Owners may contact Yamaha customer service at 1-800-962-7926.

NHTSA campaign record ↗

15V176000 · Power Train:Manual Transmission

Reported: 2015-03-25 (March 25, 2015) · Model years: 2015

Yamaha Motor Corporation, USA (Yamaha) is recalling certain model year 2015 FJ-09 (FJ09F/FC), FZ-09 (FZ09F/FC), FZ6R (FZ6RF/FC), Super Tenere (XTZ12F/FC), Super Tenere ES (XTZ12EF/EFC), and R6 (YZF-R6) motorcycles manufactured September 1, 2014, to November 17, 2014. The affected motorcycles may have an incorrectly manufactured shift cam segment stopper, having a sharp edge on the inside of the bend instead of a smooth radius. As a result, the stopper can crack and possibly fracture at this sharp edge.

Consequence: If the stopper fractures, the transmission may not shift properly, increasing the risk of a crash.

Remedy: Yamaha will notify owners, and dealers will replace the shift shaft assembly with a new one, free of charge. The recall began on April 6, 2015. Owners may contact Yamaha customer service at 1-800-962-7926.

NHTSA campaign record ↗

17V221000 · Steering: Steering Wheel/Handle Bar

Reported: 2017-03-31 (March 31, 2017) · Model years: 2015, 2016, 2017

Yamaha Motor Corporation, USA (Yamaha) is recalling certain 2015-2017 FJ-09, FZ-09, and XSR900 motorcycles. The lower handlebar holder may loosen due to a painting issue and the inadequate application of the thread-locking agent.

Consequence: If the handlebars are not properly secured to the motorcycle, a loss of vehicle control may result, increasing the risk of a crash.

Remedy: Yamaha will notify owners, and dealers will replace the lower handlebar holder, free of charge. The recall began April 13, 2017. Owners may contact Yamaha customer service at 1-800-962-7926. Yamaha's number for this recall is 990114.

NHTSA campaign record ↗

Explore the data

Vehicle analysis explorer

Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.

Data completeness

26 unique complaints in this selection. Analysis snapshot: 2026-11-01.

84.6%Usable mileage22 / 26 records

100.0%Valid incident date26 / 26 records

100.0%Valid filing date26 / 26 records

100.0%Ordered incident and filing dates26 / 26 records

Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.

Problems by model year

Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.

From model yearThrough model year

Component complaint heatmap
Component	2014	2015	2016	2017
Power Train	541.7% ODI 10594156 · 400 mi CAMSHAFT CHAIN TENSIONER BECOMES LOOSE, EXCEPTIONALLY LOOSE INCREASING THE CHANCE FOR ENGINE TIMING TO JUMP, SLIP, OR FOR THE CAMSHAFT CHAIN TO BREAK WHILE IN MOTION LEADING TO OR ACCELERATING ENGINE DAMAGE AND WEAR. *TR Look up ODI 10594156 at NHTSA ↗	550.0% ODI 10924904 · 28,000 mi CLUTCH HOUSING AND FRICTION PLATES BREAK WITHOUT NOTICE, CAN CAUSE WHEEL LOCKUP AND/OR ENGINE SEIZURE RESULTING IN CRASH Look up ODI 10924904 at NHTSA ↗	1100.0% ODI 11246499 · 12,000 mi CLUTCH BASKET TOTAL FAILURE DESTROYING THE FIBERS, STEELS, AND SENDING METAL IN THE OIL PAN. OIL PAN ALSO CRACKED. HAPPENED WHILE RIDING WITHOUT WARNING. MAY HAVE CAUSED ENOUGH DAMAGE TO NEED FULL REPLACEMENT OF ENGINE. Look up ODI 11246499 at NHTSA ↗	00.0% No examples available for this selection.
Engine	866.7% ODI 10594156 · 400 mi CAMSHAFT CHAIN TENSIONER BECOMES LOOSE, EXCEPTIONALLY LOOSE INCREASING THE CHANCE FOR ENGINE TIMING TO JUMP, SLIP, OR FOR THE CAMSHAFT CHAIN TO BREAK WHILE IN MOTION LEADING TO OR ACCELERATING ENGINE DAMAGE AND WEAR. *TR Look up ODI 10594156 at NHTSA ↗	220.0% ODI 10979181 · 34,500 mi CLUTCH BASKET CUSH BUMPERS PREMATURELY WEARING OUT, CAUSING FREEPLAY BETWEEN RING GEAR AND BASKET. ANY PLAY WHATSOEVER IS ABNORMAL AND WILL CAUSE EXCESSIVE VIBRATIONS. VIBRATIONS WITHIN THE CLUTCH ASSEMBLY WILL CAUSE PLATES TO BREAK POTENTIALLY CAUSING A CRASH. Look up ODI 10979181 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Exterior Lighting	18.3% ODI 11122030 · 16,000 mi CAMPAIGN 014-550 "WIRE HARNESS TOO SHORT". "DEALER TO INSTALL JUMPER HARNESS". THIS WORK WAS PERFORMED BUT I HAVE AN INTERMITTENT HEADLIGHT ISSUE. DEALER & YAMAHA STATE "THEY CAN DO NOTHING UNLESS THE HEADLIGHT IS OUT WHEN THEY HAVE THE VEHICLE". I AM LEFT TO RIDE THIS BIKE WITH A HEADLIGHT THAT MAY OR MAY NOT OPERATE? UNACCEPTABLE TO ME. DEALER HAS HAD THE VEHICLE FOR 2 WEEKS AND NOW IS TELLING ME "I CAN COME PICK IT UP". Look up ODI 11122030 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	3100.0% ODI 10993505 · 925 mi THE HEADLIGHT DESIGN FOR THE 2017 YAMAHA FZ-09 IS UNSAFE. WHEN DRIVING AT NIGHT ON A DARK ROAD THE HEADLIGHTS DO NOT ILLUMINATE TURNS. YOU CANNOT SEE THE TURN ENTRY NOR THE APEX. THE UPLOADED PICTURES SHOW THE PROBLEM WITH THE YAMAHA LED LIGHT PATTERN. VERY DANGEROUS! IN NEED OF A RECALL. PLEASE HELP! Look up ODI 10993505 at NHTSA ↗
Structure:Body	00.0% No examples available for this selection.	330.0% ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Suspension	18.3% ODI 10557000 · 30 mi DRIVING ACROSS THE INTERSTATE10 SALT RIVER BRIDGE IN PHOENIX AZ, THERE IS A DIP AT ONE OF THE BRIDGE EXPANSION JOINTS. IT IS NOT A VERY SEVERE DIP BUT THE REAR SUSPENSION ON THIS NEW MOTORCYCLE BOUNCED VIOLENTLY 5 TIMES AFTER THIS DIP. THERE IS AN ADJUSTMENT SCREW TO INCREASE THE DAMPING AND I TURNED IT TO THE MAXIMUM VALUE, BOTH FRONT AND REAR, THIS REDUCED THE AMOUNT OF POST BUMP BOUNCING TO AROUND 2 TIMES. THIS IS INADEQUATE SUSPENSION DAMPING AND I BELIEVE IT COULD BE A HAZARD, ESPECIALLY IF IT HAPPENS IN A TURN, WITH AN INEXPERIENCED R… Look up ODI 10557000 at NHTSA ↗	220.0% ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Service Brakes	18.3% ODI 11088373 · 6,869 mi FRONT BRAKE LOCKED UP AND APPLYING ALSO CAUSED BRAKE LEVER TO GO ALL THE WAY TO THE HANDLE BAR WHEN GOING OUT FOR FIRST RIDE THIS YEAR. Look up ODI 11088373 at NHTSA ↗	110.0% ODI 10731491 · 1,200 mi ANY TIME THE VEHICLE EXCEEDS 70 MPH THE FRONT BRAKE LEVER BECOMES DIFFICULT TO APPLY AND THE FRONT BRAKES DO NOT WORK. THE BRAKE LEVER REQUIRES MULTIPLE CYCLES OF SQUEEZE AND RELEASE TO BECOME EFFECTIVE AGAIN. Look up ODI 10731491 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Electrical System	18.3% ODI 10904863 · 2,600 mi I WANNA SAY I LOVE THIS BIKE AND WILL CONTINUE DRIVING AND TRYING TO FIX IT.MY 2014 FZ09 HAS 5000 MILES ON IT AND WHEN I DOWN SHIFT IN TRAFFIC OR ANYWHERE THE BIKE DIES THE TIRE WILL SOMETIMES LOCK UP IF I DON'T CATCH THE PROBLEM IN TIME.. I'M TRYING TO GET OTHERS THAT ARE ON THE FZ FORUMS TO SHARE THERE SAME COMPLAINTS.. THIS IS A SERIOUS SAFETY ISSUE AS IT WILL LITERALLY JUST CUT OFF NO POWER POOF.. AND A REALLY BAD NOISE AND VIBRATION AROUND 3100 TO 4000 RPMS MAKES YOU FEEL LIKE THE TRANSMISSION IS FALLING APART.. OTHER THAN THAT I LOVE THE … Look up ODI 10904863 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.	00.0% No examples available for this selection.
Steering	00.0% No examples available for this selection.	110.0% ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗	00.0% No examples available for this selection.	00.0% No examples available for this selection.

Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.

Failure mileage by component

Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.

Component failure mileage distribution
Component	Mileage range (25th–75th percentile)	Median	Usable records	Examples
Power Train	1,454–15,900 mi	7,000 mi	11	ODI 10594156 · 400 mi CAMSHAFT CHAIN TENSIONER BECOMES LOOSE, EXCEPTIONALLY LOOSE INCREASING THE CHANCE FOR ENGINE TIMING TO JUMP, SLIP, OR FOR THE CAMSHAFT CHAIN TO BREAK WHILE IN MOTION LEADING TO OR ACCELERATING ENGINE DAMAGE AND WEAR. TR Look up ODI 10594156 at NHTSA ↗ ODI 10609463 · 386 mi AT INITIAL COLD START AND UNDER LOAD BETWEEN 3000-4000 RPM THERE IS A NOTICEABLE RATTLE/TICK FROM THE RIGHT SIDE OF ENGINE AT THE CAM CHAIN TENSIONER. UPON FURTHER INSPECTION IT SEEMS THE TENSIONER DOES NOT HOLD TENSION WHICH CAN LEAD TO PREMATURE WEAR, BREAKAGE, OR ENGINE FAILURE. FOLLOWING YAMAHA PROCEDURE FOR CAM CHAIN TENSION ADJUSTMENT PROVES THAT THE TENSIONER IS MALFUNCTIONING BY WATCHING THE HEX KEY TOOL BACK OFF (LOOSEN) AFTER MAKING ADJUSTMENT AND EVENTUALLY CAUSING RATTLE/TICK AGAIN. CONTACTING YAMAHA DEALERSHIP ALSO CONFIRMED ISSUE,… Look up ODI 10609463 at NHTSA ↗ ODI 10705510 · 1,108 mi RIDING ON THE FREEWAY WHILE LANE SPLITTING 45 MPH DOWN SHIFTING FROM 4TH TO 3RD GEAR SLOWING DOWN PROCESS. PRESSING CLUTCH ENGINE STALLED, DOWN SHIFTED TO 3RD GEAR. ENGINE STARTED ONCE I LET GO OF THE CLUTCH IN 3RD GEAR. FRONT END LIFTED ABOUT FOOT. TR Look up ODI 10705510 at NHTSA ↗
Engine	1,435–21,375 mi	4,800 mi	8	ODI 10594156 · 400 mi CAMSHAFT CHAIN TENSIONER BECOMES LOOSE, EXCEPTIONALLY LOOSE INCREASING THE CHANCE FOR ENGINE TIMING TO JUMP, SLIP, OR FOR THE CAMSHAFT CHAIN TO BREAK WHILE IN MOTION LEADING TO OR ACCELERATING ENGINE DAMAGE AND WEAR. *TR Look up ODI 10594156 at NHTSA ↗ ODI 10609463 · 386 mi AT INITIAL COLD START AND UNDER LOAD BETWEEN 3000-4000 RPM THERE IS A NOTICEABLE RATTLE/TICK FROM THE RIGHT SIDE OF ENGINE AT THE CAM CHAIN TENSIONER. UPON FURTHER INSPECTION IT SEEMS THE TENSIONER DOES NOT HOLD TENSION WHICH CAN LEAD TO PREMATURE WEAR, BREAKAGE, OR ENGINE FAILURE. FOLLOWING YAMAHA PROCEDURE FOR CAM CHAIN TENSION ADJUSTMENT PROVES THAT THE TENSIONER IS MALFUNCTIONING BY WATCHING THE HEX KEY TOOL BACK OFF (LOOSEN) AFTER MAKING ADJUSTMENT AND EVENTUALLY CAUSING RATTLE/TICK AGAIN. CONTACTING YAMAHA DEALERSHIP ALSO CONFIRMED ISSUE,… Look up ODI 10609463 at NHTSA ↗ ODI 10748012 · 1,780 mi WHILE RIDING APPROXIMATELY 60MPH IN TRAFFIC, JUST PULLED AHEAD OF SOME VEHICLES, AND THE ENGINE STARTED TO LOSE POWER, SHUDDER, AND THEN IT MADE A LOUD SCREETCHING SOUND, AND LOCKED UP THE REAR TIRE WHEN THE ENGINE DIED. I PULLED IN THE CLUTCH, RELEASING THE REAR TIRE, AND THE ENGINE WAS STILL DEAD. TRIED THE STARTER, NOTHING. DOWNSHIFTED AS THE BIKE COASTED SLOWER INTO 3RD GEAR, AND SLOWLY LET OUT THE CLUTCH, AND IT "BUMP STARTED" THE ENGINE, BUT NOW IT WAS MAKING A MASSIVE TICK TICK TICK TICK TICK NOISE. (MUCH LOUDER THAN THE OTHER MINOR T… Look up ODI 10748012 at NHTSA ↗
Exterior Lighting	Too few reports for a range	738 mi	4 (sparse)	ODI 11122030 · 16,000 mi CAMPAIGN 014-550 "WIRE HARNESS TOO SHORT". "DEALER TO INSTALL JUMPER HARNESS". THIS WORK WAS PERFORMED BUT I HAVE AN INTERMITTENT HEADLIGHT ISSUE. DEALER & YAMAHA STATE "THEY CAN DO NOTHING UNLESS THE HEADLIGHT IS OUT WHEN THEY HAVE THE VEHICLE". I AM LEFT TO RIDE THIS BIKE WITH A HEADLIGHT THAT MAY OR MAY NOT OPERATE? UNACCEPTABLE TO ME. DEALER HAS HAD THE VEHICLE FOR 2 WEEKS AND NOW IS TELLING ME "I CAN COME PICK IT UP". Look up ODI 11122030 at NHTSA ↗ ODI 10993505 · 925 mi THE HEADLIGHT DESIGN FOR THE 2017 YAMAHA FZ-09 IS UNSAFE. WHEN DRIVING AT NIGHT ON A DARK ROAD THE HEADLIGHTS DO NOT ILLUMINATE TURNS. YOU CANNOT SEE THE TURN ENTRY NOR THE APEX. THE UPLOADED PICTURES SHOW THE PROBLEM WITH THE YAMAHA LED LIGHT PATTERN. VERY DANGEROUS! IN NEED OF A RECALL. PLEASE HELP! Look up ODI 10993505 at NHTSA ↗ ODI 11074294 · 68 mi HEADLIGHTS ARE INCAPABLE OF MAINTAINING A SAFE DISTANCE DURING CORNERING. ON ANY CORNER, THE HEADLIGHTS WILL DIP TOO FAR DOWN AND NO LONGER ILLUMINATE THE ROAD. THE ISSUE IS WELL DOCUMENTED AMONGST OWNERS OF 2017 FZ-09 AND ALL AGREE THAT THIS HEADLIGHT PATTERN DESIGN IS EXTREMELY DANGEROUS TO POINT OF REQUIRING AUXILIARY LIGHTING, OR ALWAYS KEEPING THE HIGH BEAMS ON. I'VE EXPERIENCED THIS PROBLEM DURING OFF-RAMPS ON THE HIGHWAY IN WHICH I WASN'T ABLE TO RUN HIGHBEAMS DUE TO ONCOMING TRAFFIC. ON THE OFF-RAMP CORNER, I SLOWED DOWN TO THE RAMP SPE… Look up ODI 11074294 at NHTSA ↗
Structure:Body	Too few reports for a range	9,010 mi	2 (sparse)	ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗ ODI 10863621 · 18,000 mi CRACK THROUGH MID-FRAME. Look up ODI 10863621 at NHTSA ↗
Suspension	Too few reports for a range	25 mi	2 (sparse)	ODI 10557000 · 30 mi DRIVING ACROSS THE INTERSTATE10 SALT RIVER BRIDGE IN PHOENIX AZ, THERE IS A DIP AT ONE OF THE BRIDGE EXPANSION JOINTS. IT IS NOT A VERY SEVERE DIP BUT THE REAR SUSPENSION ON THIS NEW MOTORCYCLE BOUNCED VIOLENTLY 5 TIMES AFTER THIS DIP. THERE IS AN ADJUSTMENT SCREW TO INCREASE THE DAMPING AND I TURNED IT TO THE MAXIMUM VALUE, BOTH FRONT AND REAR, THIS REDUCED THE AMOUNT OF POST BUMP BOUNCING TO AROUND 2 TIMES. THIS IS INADEQUATE SUSPENSION DAMPING AND I BELIEVE IT COULD BE A HAZARD, ESPECIALLY IF IT HAPPENS IN A TURN, WITH AN INEXPERIENCED R… Look up ODI 10557000 at NHTSA ↗ ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗
Service Brakes	Too few reports for a range	4,035 mi	2 (sparse)	ODI 11088373 · 6,869 mi FRONT BRAKE LOCKED UP AND APPLYING ALSO CAUSED BRAKE LEVER TO GO ALL THE WAY TO THE HANDLE BAR WHEN GOING OUT FOR FIRST RIDE THIS YEAR. Look up ODI 11088373 at NHTSA ↗ ODI 10731491 · 1,200 mi ANY TIME THE VEHICLE EXCEEDS 70 MPH THE FRONT BRAKE LEVER BECOMES DIFFICULT TO APPLY AND THE FRONT BRAKES DO NOT WORK. THE BRAKE LEVER REQUIRES MULTIPLE CYCLES OF SQUEEZE AND RELEASE TO BECOME EFFECTIVE AGAIN. Look up ODI 10731491 at NHTSA ↗
Electrical System	Too few reports for a range	2,600 mi	1 (sparse)	ODI 10904863 · 2,600 mi I WANNA SAY I LOVE THIS BIKE AND WILL CONTINUE DRIVING AND TRYING TO FIX IT.MY 2014 FZ09 HAS 5000 MILES ON IT AND WHEN I DOWN SHIFT IN TRAFFIC OR ANYWHERE THE BIKE DIES THE TIRE WILL SOMETIMES LOCK UP IF I DON'T CATCH THE PROBLEM IN TIME.. I'M TRYING TO GET OTHERS THAT ARE ON THE FZ FORUMS TO SHARE THERE SAME COMPLAINTS.. THIS IS A SERIOUS SAFETY ISSUE AS IT WILL LITERALLY JUST CUT OFF NO POWER POOF.. AND A REALLY BAD NOISE AND VIBRATION AROUND 3100 TO 4000 RPMS MAKES YOU FEEL LIKE THE TRANSMISSION IS FALLING APART.. OTHER THAN THAT I LOVE THE … Look up ODI 10904863 at NHTSA ↗
Steering	Too few reports for a range	20 mi	1 (sparse)	ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗

Complaint and recall timeline

Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.

ComponentPeriod

Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.

Monthly counts, recall campaigns and complaint examples

Monthly complaint and recall timeline
Month	Campaigns announced	Examples
2024-12	None	No examples available for this selection.
2025-01	None	No examples available for this selection.
2025-02	None	No examples available for this selection.
2025-03	None	No examples available for this selection.
2025-04	None	No examples available for this selection.
2025-05	None	No examples available for this selection.
2025-06	None	No examples available for this selection.
2025-07	None	No examples available for this selection.
2025-08	None	No examples available for this selection.
2025-09	None	No examples available for this selection.
2025-10	None	No examples available for this selection.
2025-11	None	No examples available for this selection.
2025-12	None	No examples available for this selection.
2026-01	None	No examples available for this selection.
2026-02	None	No examples available for this selection.
2026-03	None	No examples available for this selection.
2026-04	None	No examples available for this selection.
2026-05	None	No examples available for this selection.
2026-06	None	No examples available for this selection.
2026-07	None	No examples available for this selection.
2026-08	None	No examples available for this selection.
2026-09	None	No examples available for this selection.
2026-10	None	No examples available for this selection.
2026-11 (partial)	None	No examples available for this selection.

Emerging complaint spikes

Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.

This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.

No complete months meet the spike thresholds for this selection.

Equal-age model-year comparison

Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.

Observation windowFirst model yearSecond model year

2016: 0 complaints · 2017: 3 complaints

Equal observation windows
Model year	Through age 0	Through age 1	Through age 2
2016	0	0	0
2017	1	3	3

Date coverage across each selected cohort

Date basis for all complaints in selected model years
Year	Incident dates used	Filing date fallbacks	Excluded dates
2016	1	0	0
2017	3	0	0

Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.

Components reported together

Each cell counts unique complaints naming both components. Open a nonzero cell for examples.

Component co-occurrence matrix
Component	Power Train	Engine	Exterior Lighting	Structure:Body	Suspension	Service Brakes	Electrical System	Steering
Power Train	—	6 ODI 10594156 · 400 mi CAMSHAFT CHAIN TENSIONER BECOMES LOOSE, EXCEPTIONALLY LOOSE INCREASING THE CHANCE FOR ENGINE TIMING TO JUMP, SLIP, OR FOR THE CAMSHAFT CHAIN TO BREAK WHILE IN MOTION LEADING TO OR ACCELERATING ENGINE DAMAGE AND WEAR. *TR Look up ODI 10594156 at NHTSA ↗ ODI 10609463 · 386 mi AT INITIAL COLD START AND UNDER LOAD BETWEEN 3000-4000 RPM THERE IS A NOTICEABLE RATTLE/TICK FROM THE RIGHT SIDE OF ENGINE AT THE CAM CHAIN TENSIONER. UPON FURTHER INSPECTION IT SEEMS THE TENSIONER DOES NOT HOLD TENSION WHICH CAN LEAD TO PREMATURE WEAR, BREAKAGE, OR ENGINE FAILURE. FOLLOWING YAMAHA PROCEDURE FOR CAM CHAIN TENSION ADJUSTMENT PROVES THAT THE TENSIONER IS MALFUNCTIONING BY WATCHING THE HEX KEY TOOL BACK OFF (LOOSEN) AFTER MAKING ADJUSTMENT AND EVENTUALLY CAUSING RATTLE/TICK AGAIN. CONTACTING YAMAHA DEALERSHIP ALSO CONFIRMED ISSUE,… Look up ODI 10609463 at NHTSA ↗ ODI 10904863 · 2,600 mi I WANNA SAY I LOVE THIS BIKE AND WILL CONTINUE DRIVING AND TRYING TO FIX IT.MY 2014 FZ09 HAS 5000 MILES ON IT AND WHEN I DOWN SHIFT IN TRAFFIC OR ANYWHERE THE BIKE DIES THE TIRE WILL SOMETIMES LOCK UP IF I DON'T CATCH THE PROBLEM IN TIME.. I'M TRYING TO GET OTHERS THAT ARE ON THE FZ FORUMS TO SHARE THERE SAME COMPLAINTS.. THIS IS A SERIOUS SAFETY ISSUE AS IT WILL LITERALLY JUST CUT OFF NO POWER POOF.. AND A REALLY BAD NOISE AND VIBRATION AROUND 3100 TO 4000 RPMS MAKES YOU FEEL LIKE THE TRANSMISSION IS FALLING APART.. OTHER THAN THAT I LOVE THE … Look up ODI 10904863 at NHTSA ↗	0	0	0	0	1 ODI 10904863 · 2,600 mi I WANNA SAY I LOVE THIS BIKE AND WILL CONTINUE DRIVING AND TRYING TO FIX IT.MY 2014 FZ09 HAS 5000 MILES ON IT AND WHEN I DOWN SHIFT IN TRAFFIC OR ANYWHERE THE BIKE DIES THE TIRE WILL SOMETIMES LOCK UP IF I DON'T CATCH THE PROBLEM IN TIME.. I'M TRYING TO GET OTHERS THAT ARE ON THE FZ FORUMS TO SHARE THERE SAME COMPLAINTS.. THIS IS A SERIOUS SAFETY ISSUE AS IT WILL LITERALLY JUST CUT OFF NO POWER POOF.. AND A REALLY BAD NOISE AND VIBRATION AROUND 3100 TO 4000 RPMS MAKES YOU FEEL LIKE THE TRANSMISSION IS FALLING APART.. OTHER THAN THAT I LOVE THE … Look up ODI 10904863 at NHTSA ↗	0
Engine	6 ODI 10594156 · 400 mi CAMSHAFT CHAIN TENSIONER BECOMES LOOSE, EXCEPTIONALLY LOOSE INCREASING THE CHANCE FOR ENGINE TIMING TO JUMP, SLIP, OR FOR THE CAMSHAFT CHAIN TO BREAK WHILE IN MOTION LEADING TO OR ACCELERATING ENGINE DAMAGE AND WEAR. *TR Look up ODI 10594156 at NHTSA ↗ ODI 10609463 · 386 mi AT INITIAL COLD START AND UNDER LOAD BETWEEN 3000-4000 RPM THERE IS A NOTICEABLE RATTLE/TICK FROM THE RIGHT SIDE OF ENGINE AT THE CAM CHAIN TENSIONER. UPON FURTHER INSPECTION IT SEEMS THE TENSIONER DOES NOT HOLD TENSION WHICH CAN LEAD TO PREMATURE WEAR, BREAKAGE, OR ENGINE FAILURE. FOLLOWING YAMAHA PROCEDURE FOR CAM CHAIN TENSION ADJUSTMENT PROVES THAT THE TENSIONER IS MALFUNCTIONING BY WATCHING THE HEX KEY TOOL BACK OFF (LOOSEN) AFTER MAKING ADJUSTMENT AND EVENTUALLY CAUSING RATTLE/TICK AGAIN. CONTACTING YAMAHA DEALERSHIP ALSO CONFIRMED ISSUE,… Look up ODI 10609463 at NHTSA ↗ ODI 10904863 · 2,600 mi I WANNA SAY I LOVE THIS BIKE AND WILL CONTINUE DRIVING AND TRYING TO FIX IT.MY 2014 FZ09 HAS 5000 MILES ON IT AND WHEN I DOWN SHIFT IN TRAFFIC OR ANYWHERE THE BIKE DIES THE TIRE WILL SOMETIMES LOCK UP IF I DON'T CATCH THE PROBLEM IN TIME.. I'M TRYING TO GET OTHERS THAT ARE ON THE FZ FORUMS TO SHARE THERE SAME COMPLAINTS.. THIS IS A SERIOUS SAFETY ISSUE AS IT WILL LITERALLY JUST CUT OFF NO POWER POOF.. AND A REALLY BAD NOISE AND VIBRATION AROUND 3100 TO 4000 RPMS MAKES YOU FEEL LIKE THE TRANSMISSION IS FALLING APART.. OTHER THAN THAT I LOVE THE … Look up ODI 10904863 at NHTSA ↗	—	0	0	0	0	1 ODI 10904863 · 2,600 mi I WANNA SAY I LOVE THIS BIKE AND WILL CONTINUE DRIVING AND TRYING TO FIX IT.MY 2014 FZ09 HAS 5000 MILES ON IT AND WHEN I DOWN SHIFT IN TRAFFIC OR ANYWHERE THE BIKE DIES THE TIRE WILL SOMETIMES LOCK UP IF I DON'T CATCH THE PROBLEM IN TIME.. I'M TRYING TO GET OTHERS THAT ARE ON THE FZ FORUMS TO SHARE THERE SAME COMPLAINTS.. THIS IS A SERIOUS SAFETY ISSUE AS IT WILL LITERALLY JUST CUT OFF NO POWER POOF.. AND A REALLY BAD NOISE AND VIBRATION AROUND 3100 TO 4000 RPMS MAKES YOU FEEL LIKE THE TRANSMISSION IS FALLING APART.. OTHER THAN THAT I LOVE THE … Look up ODI 10904863 at NHTSA ↗	0
Exterior Lighting	0	0	—	0	0	0	0	0
Structure:Body	0	0	0	—	1 ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗	0	0	1 ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗
Suspension	0	0	0	1 ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗	—	0	0	1 ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗
Service Brakes	0	0	0	0	0	—	0	0
Electrical System	1 ODI 10904863 · 2,600 mi I WANNA SAY I LOVE THIS BIKE AND WILL CONTINUE DRIVING AND TRYING TO FIX IT.MY 2014 FZ09 HAS 5000 MILES ON IT AND WHEN I DOWN SHIFT IN TRAFFIC OR ANYWHERE THE BIKE DIES THE TIRE WILL SOMETIMES LOCK UP IF I DON'T CATCH THE PROBLEM IN TIME.. I'M TRYING TO GET OTHERS THAT ARE ON THE FZ FORUMS TO SHARE THERE SAME COMPLAINTS.. THIS IS A SERIOUS SAFETY ISSUE AS IT WILL LITERALLY JUST CUT OFF NO POWER POOF.. AND A REALLY BAD NOISE AND VIBRATION AROUND 3100 TO 4000 RPMS MAKES YOU FEEL LIKE THE TRANSMISSION IS FALLING APART.. OTHER THAN THAT I LOVE THE … Look up ODI 10904863 at NHTSA ↗	1 ODI 10904863 · 2,600 mi I WANNA SAY I LOVE THIS BIKE AND WILL CONTINUE DRIVING AND TRYING TO FIX IT.MY 2014 FZ09 HAS 5000 MILES ON IT AND WHEN I DOWN SHIFT IN TRAFFIC OR ANYWHERE THE BIKE DIES THE TIRE WILL SOMETIMES LOCK UP IF I DON'T CATCH THE PROBLEM IN TIME.. I'M TRYING TO GET OTHERS THAT ARE ON THE FZ FORUMS TO SHARE THERE SAME COMPLAINTS.. THIS IS A SERIOUS SAFETY ISSUE AS IT WILL LITERALLY JUST CUT OFF NO POWER POOF.. AND A REALLY BAD NOISE AND VIBRATION AROUND 3100 TO 4000 RPMS MAKES YOU FEEL LIKE THE TRANSMISSION IS FALLING APART.. OTHER THAN THAT I LOVE THE … Look up ODI 10904863 at NHTSA ↗	0	0	0	0	—	0
Steering	0	0	0	1 ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗	1 ODI 10863611 · 20 mi BOUGHT A BRAND NEW 2015 YAMAHA FZ-09 IN YEAR 2016. MY BIKE AND MANY OTHERS HAVE A DEFECT IN THE FRAME, AND I CHOSE TO DIG DEEPER TO SEE IF IT WAS A CRACK OR CASTING MARK. YAMAHA HAD THE DEALERSHIP TAKE THE TANK OFF AND AND LOOK ON THE INSIDE, AND SURE ENOUGH, IT WAS CRACKED IN THE SAME AREA SAME PLACE ONLY ON THE OPPOSITE SIDE OF THE MAIN FRAME AS WELL. TO MAKE SURE THE DEALERSHIP TOOK IT TO AN AUTO BODY FACILITY TO SAND BLAST THE AREA, AND THAT CONFIRMED THAT IT WAS INDEED A CRACK. MANY MANY MORE 2015'S HAVE THE SAME ISSUE, AND TWO OF TH… Look up ODI 10863611 at NHTSA ↗	0	0	—

Co-reporting does not establish that one component caused another concern.

Recurring narrative patterns

Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.

Search patterns

1 patterns with matching reports.

Stalling or loss of power

2 mentions · 7.7% of complaints

Median mileage: 9,054 mi (2 usable records).

ODI 10705510 · 1,108 mi

RIDING ON THE FREEWAY WHILE LANE SPLITTING 45 MPH DOWN SHIFTING FROM 4TH TO 3RD GEAR SLOWING DOWN PROCESS. PRESSING CLUTCH ENGINE STALLED, DOWN SHIFTED TO 3RD GEAR. ENGINE STARTED ONCE I LET GO OF THE CLUTCH IN 3RD GEAR. FRONT END LIFTED ABOUT FOOT. *TR

Look up ODI 10705510 at NHTSA ↗

ODI 11020180 · 17,000 mi

DRIVING DOWN THE ROAD AT 50MPH WHEN A ANIMAL CAME OUT OF THE DITCH. I THEN PULLED CLUTCH IN SO I COULD BRAKE. ONCE I DID THIS THE BIKE STALLED. TO GET THE BIKE GOING AGAIN I RELEASED THE CLUTCH, BUT ONCE I DID THIS THE BIKE JUST LOCKED THE BACK TIRE. I THEN PULLED CLUTCH IN AGAIN AND THEN IT STARTED. I ATTEMPTED TO PULL TO THE SIDE OF THE ROAD, WHEN I NOTICED THAT THE CLUTCH WAS NOT DISENGAGING I KNEW THERE WAS SOMETHING WRONG. GOT THE BIKE BACK HOME, AND PULLED THE CLUTCH CASE OFF TO FIND TWO CLUTCH DISKS HAD SHATTERED. THIS ALSO CAUSED THE CL…

Look up ODI 11020180 at NHTSA ↗

Matching rule

\b(stall\w*|loss of power|lost power|engine shut\w* off)\b