Western Star 4900 recalls by model year

Reported: 2001-12-17 (December 17, 2001) · Model years: 1998, 1999, 2000

ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR 3406E AND C-15 ENGINES, INTERFERENCE BETWEEN THE POSITIVE BATTERY CABLE AND STUD MOUNTING ELECTRONIC CONTROL MODULE (ECM) TO THE ENGINE EXISTS. CHAFING CAN WEAR THROUGH THE BATTERY CABLE INSULATION TO ALLOW CONTACT BETWEEN THE BATTERY CABLE AND THE STUD.

Consequence: THIS CONTACT COULD PROVIDE A SHORT CIRCUIT, WHICH MAY CAUSE A FIRE.

Remedy: DEALERS WILL INSPECT THE VEHICLES AND THE BATTERY CABLES WILL BE REPLACED AND/OR RE-ROUTED AS NECESSARY. OWNER NOTIFICATION BEGAN APRIL 18, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2003-03-21 (March 21, 2003) · Model years: 1998, 1999, 2000, 2001

ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.

Consequence: SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.

Remedy: DEALERS WILL REPLACE BOTH FRONT HUBS. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON OR BEFORE SEPTEMBER 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2001-05-14 (May 14, 2001) · Model years: 2000

VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CHALMERS 1000 AND 800 SERIES SUSPENSION KITS. THESE SUSPENSION KITS MAY HAVE INSUFFICIENT PENETRATION OF THE WELD ATTACHING THE TORQUE ROD EYE TO THE TORQUE ROD TUBE.

Consequence: FAILURE OF THE WELD COULD RESULT IN SEPARATION OF THE EYE AND TUBE, CAUSING A LOCK OF AXLE RETENTION, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL REPLACE ALL CHALMERS FIXED TORQUE RODS ON THESE VEHICLES. OWNER NOTIFICATION BEGAN MARCH 14, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2002-03-20 (March 20, 2002) · Model years: 2001

ON CERTAIN TRUCKS, A CAPACITOR IN THE POWER LINE CONTROL (PLC) FILTER COULD OVERHEAT AND/OR IGNITE WHEN SUBJECTED TO REVERSE POLARITY ELECTRICAL SPIKES.

Consequence: THIS COULD CAUSE AN ELECTRICAL FIRE IN THE AREA OF THE PLC FILTER WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL DISCONNECT AND SECURE THE PLC FILTER GROUND WIRE. OWNER NOTIFICATION BEGAN SEPTEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2005-10-05 (October 5, 2005) · Model years: 2001, 2002, 2003, 2004, 2005

ON CERTAIN TRUCKS FITTED WITH OPTIONAL IN-CAB BATTERIES, THE DUAL SUCTION/RETURN LINES MAY CONTACT THE CAB POWER HARNESS RESULTING IN CHAFING THROUGH.

Consequence: THIS COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REROUTE AND SECURE THE FUEL LINES. THE RECALL BEGAN ON JANUARY 26, 2006. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2017-12-15 (December 15, 2017) · Model years: 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017

Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: DTNA will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on April 11, 2018. Owners may contact DTNA customer service at 1-800-547-0712, or contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.

Reported: 2006-02-08 (February 8, 2006) · Model years: 2004, 2005, 2006

ON CERTAIN TRUCKS EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE VARIABLE VALVE ACTUATION OIL LINE MAY WEAR AGAINST THE SHARP EDGE OF THE CYLINDER HEAD IF NOT POSITIONED CORRECTLY.

Consequence: THE OIL LINE MAY BE CUT ON THE CYLINDER HEAD CAUSING AN OIL LEAK AND A POSSIBLE FIRE.

Remedy: CATERPILLAR, IN CONJUNCTION WITH FREIGHTLINER, WILL BE CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN FREE OF CHARGE. OWNERS MAY CALL CATERPILLAR AT 309-675-6496, OR FREIGHTLINER AT 1-800-547-0712.

Reported: 2009-09-23 (September 23, 2009) · Model years: 2004, 2005, 2006, 2007, 2008, 2009, 2010

DAIMLER TRUCKS IS RECALLING MODEL YEAR 2004-2010 TRUCKS EQUIPPED WITH CATERPILLAR C15 ENGINE. THE VARIABLE VALVE ACTUATION OIL LINE MAY RUB AGAINST THE P-CLIPS RETAINING THE OIL LINE, CAUSING AN OIL LEAK.

Consequence: AN OIL LEAK MAY RESULT IN A FIRE.

Remedy: DAIMLER TRUCKS IS WORKING WITH CATERPILLAR TO REMEDY THESE VEHICLES. PLEASE SEE CATERPILLAR'S DEFECT REPORT 09E-020. CATERPILLAR WILL INSPECT AND REPAIR THE NECESSARY COMPONENTS FREE OF CHARGE. THE RECALL BEGAN ON MAY 5, 2009. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986 OR DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2011-09-16 (September 16, 2011) · Model years: 2004, 2005, 2006, 2007, 2008

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.

Consequence: THIS COULD CREATE A ROAD HAZARD INCREASING THE RISK OF A CRASH. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. VEHICLES WILL BE INSPECTED AND THE PLASTIC LOW PRESSURE FUEL LINE WILL BE REPLACED WITH A STEEL LOW PRESSURE FUEL LINE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON OCTOBER 28, 2011. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2007-12-18 (December 18, 2007) · Model years: 2005, 2006, 2007

ON CERTAIN HEAVY DUTY TRUCKS BUILT WITH SISU FR2P-21, SISU FR2P-26, SISU FR3P-33, OR SISU FR3P-48 REAR AXLES, A COUNTER-BORE MACHINED IN BOTH ENDS OF THE WORM WHEEL OPENING OF THE SLACK ADJUSTER HOUSING REDUCES MATERIAL THICKNESS BETWEEN THE WORM WHEEL OPENING AND THE WORM SHAFT OPENING. UNDER NORMAL SERVICE A CRACK MAY DEVELOP IN THIS AREA RENDERING THE SLACK ADJUSTER INOPERABLE AND REDUCING BRAKE EFFECTIVENESS.

Consequence: REDUCED VEHICLE BRAKING COULD LEAD TO A CRASH.

Remedy: DEALERS WILL INSPECT THE SLACK ADJUSTERS, AND REPLACE THE ADJUSTER IF FOUND DEFECTIVE. THE RECALL BEGAN ON JULY 31, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2008-03-11 (March 11, 2008) · Model years: 2005, 2006, 2007

DAIMLER TRUCKS IS RECALLING 62,000 MY 2005-2007 FREIGHTLINER BUSINESS CLASS, CENTURY CLASS, COLUMBIA, CORONADO, FLD, CLASSIC, STERLING A-LINE, L-LINE, AND WESTERN STAR 4900 TRUCKS. A FRACTURED FUEL LINE COULD LEAK DIESEL FUEL.

Consequence: IF A LEAK CONTINUES UNDETECTED UNDER CERTAIN CONDITIONS, FUEL MAY IGNITE AT A HOT ENGINE SURFACE AND/OR FUEL MAY BE SPILLED ON THE ROAD SURFACE.

Remedy: HIGH PRESSURE FUEL LINES AND TRANSFER TUBES WILL BE INSPECTED AND REPLACED FREE OF CHARGED. THE RECALL BEGAN ON JULY 9, 2008. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2007-11-13 (November 13, 2007) · Model years: 2006, 2007, 2008

ON CERTAIN TRUCK-TRACTORS EQUIPPED WITH HOLLAND SIMPLEX SE OR SE II FIFTH WHEELS, THE LATCH LEVER PIVOT BOLT ASSEMBLY MAY HAVE BEEN OVER-TIGHTENED WHICH COULD DISTORT THE PIVOT BOLT SPACER SLEEVE. CORROSION OR CONTAMINATES IN THE PIVOT MAY CAUSE IT TO BIND AND PREVENT THE FIFTH WHEEL JAW FROM LATCHING SECURELY AROUND THE TRAILER KING PIN.

Consequence: THERE IS A POSSIBILITY THAT THE FIFTH WHEEL MAY FAIL TO LATCH WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THE OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER. THE RECALL BEGAN ON JANUARY 3, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2009-10-06 (October 6, 2009) · Model years: 2006, 2007, 2008, 2009, 2010

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 HEAVY TRUCKS MANUFACTURED BETWEEN JANUARY 17, 2006 AND MARCH 31, 2009, EQUIPPED WITH EPA07 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES. THE PLASTIC LINES MAY EXPERIENCE LEAKS DUE TO FATIGUE CRACKS CAUSED BY STRESS AND VIBRATION COMBINED WITH HIGH INTERNAL PRESSURE.

Consequence: IF A DIESEL FUEL LEAK CONTINUES UNDETECTED UNDER CERTAIN CONDITIONS FUEL MAY IGNITE ON A HOT ENGINE SURFACE AND/OR FUEL MAY SPILL ON THE ROAD INCREASING THE RISK OF A CRASH.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES AND DIRECT WARRANTY CUSTOMERS. THE SAFETY RECALL BEGAN ON MAY 7, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2011-03-03 (March 3, 2011) · Model years: 2006, 2007, 2008, 2009, 2010, 2011

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 FREIGHTLINER, CASCADIA, CENTURY, COLUMBIA FLD, AND M2, STERLING 9500, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM MARCH 20, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE4000 EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.

Consequence: A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.

Remedy: DTNA WILL NOTIFY OWNERS OF THE RECALL DURING MARCH 2011. ANOTHER NOTIFICATION WILL BE ISSUED ONCE THE REMEDY IS RELEASED. DTNA EXPECTS THE REMEDY TO BE AVAILABLE BY DECEMBER 1, 2011. REPAIRS WILL BE PERFORMED BY DTNA DEALERS FREE OF CHARGE. OWNERS MAY CONTACT DTNA TOLL-FREE AT 1-800-547-0712. THIS RECALL IS ASSCOCIATED WITH A PREVIOUS RECALL, CAMPAIGN NUMBER 10V-341.

Reported: 2012-02-28 (February 28, 2012) · Model years: 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.

Consequence: A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DTNA WILL NOTIFY OWNERS, AND WHERE NECESSARY, THE HIGH PRESSURE FUEL LINE SUPPORT SYSTEM WILL BE REPLACED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Reported: 2007-07-18 (July 18, 2007) · Model years: 2007, 2008

FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.

Consequence: INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.

Remedy: THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2007-07-24 (July 24, 2007) · Model years: 2007, 2008

ON CERTAIN TRUCKS EQUIPPED WITH TUFTRAC REAR SUSPENSIONS, THE CENTER CASTING BRACKETS MAY BE OUT OF SPECIFICATION. AN OUT OF SQUARE CASTING MAY HAVE UNACCEPTABLE STRESS IN THE BRACKET WHEN IT IS INSTALLED AND MAY CAUSE IT TO CRACK IN SERVICE.

Consequence: THE DRIVE AXLE MAY NOT BE HELD IN POSITION IF A CRACKED BRACKET FRACTURES COMPLETELY. THIS WILL AFFECT VEHICLE CONTROL AND MAY CAUSE A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSPECT AND CASTINGS THAT ARE OUT OF SPECIFICATION WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 12, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2007-08-02 (August 2, 2007) · Model years: 2007, 2008

ON CERTAIN TRUCKS, A MANUFACTURING ERROR IN THE FUEL-WATER SEPARATOR PREHEATER THERMOSWITCH MAY PREVENT THE FUEL PREHEATER FROM TURNING OFF IF THE IGNITION IS LEFT ON. IF THE IGNITION SWITCH IS LEFT ON WHEN FUEL IS ADDED TO THE FUEL- WATER SEPARATOR AT THE FACTORY OR DURING A FILTER ELEMENT CHANGE, A SMALL FLAME MAY OCCUR INSIDE THE FILTER COVER.

Consequence: THE POTENTIAL EXISTS FOR THE FLAME TO SPREAD RESULTING IN POSSIBLE PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT THE FUEL FILTER DATE CODE AND THERMOSWITCH LOT CODE TO DETERMINE IF THEY CONTAIN THE SUSPECT COMPONENT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 4, 2007. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2009-10-08 (October 8, 2009) · Model years: 2007, 2008, 2009, 2010

DAIMLER TRUCKS IS RECALLING MODEL YEAR 2007-2010 FREIGHTLINER, STERLING AND WESTERN STAR VEHICLES EQUIPPED WITH DETROIT DIESEL DD15 EPA07 ENGINES WHICH WERE MANUFACTURED WITH GRID HEATERS. INCREASED INTERNAL GRID HEATER RESISTANCE CAUSED BY IMPROPERLY TIGHTENED SCREWS MAY MELT THE SOLDER ON THE GRID HEATER CIRCUIT BOARD LEADING TO A SHORT CIRCUIT.

Consequence: A SHORT-CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.

Remedy: THE ENGINE CONTROL LOGIC WILL BE REPROGRAMMED FREE OF CHARGE BY DETROIT DIESEL AUTHORIZED REPAIR FACILITIES AND DIRECT WARRANTY CUSTOMERS TO PROVIDE COLD WEATHER STARTING WITHOUT THE NEED OF A GRID HEATER. THE SAFETY RECALL BEGAN ON NOVEMBER 4, 2009. OWNERS MAY CONTACT DETROIT DIESEL AT 1-313-592-5800 AND DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2010-07-27 (July 27, 2010) · Model years: 2007, 2008, 2009, 2010, 2011

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FREIGHTLINER, FCCC, STERLING, AND WESTERN STAR HEAVY TRUCKS MANUFACTURED FROM SEPTEMBER 5, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.

Consequence: A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 29, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

Reported: 2007-12-21 (December 21, 2007) · Model years: 2008

ON CERTAIN TRUCKS EQUIPPED WITH TRW STEERING GEARS, MODELS TAS85 AND RCS85, THESE STEERING GEARS CONTAIN POTENTIALLY DEFECTIVE SECTOR SHAFTS WITH AN INCORRECT GEAR TOOTH WHICH MAY INTERFERE WITH THE RACK-PISTON TEETH, RESULTING IN A STICK OR BIND CONDITION.

Consequence: THIS CONDITION HAS THE POTENTIAL TO CAUSE THE STEERING GEAR TO STALL AND RESTRICT THE STEERING TURNING ANGLE OF THE VEHICLE WHICH COULD RESULT IN A VEHICLE CRASH.

Remedy: FREIGHTLINER IS WORKING WITH TRW TO REPLACE THE DEFECTIVE STEERING GEAR (PLEASE SEE 07E101). THE RECALL BEGAN ON APRIL 18, 2008. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2008-04-09 (April 9, 2008) · Model years: 2008

DAIMLER TRUCKS IS RECALLING 900 MY 2008 FREIGHTLINER ARGOSY, ARGOSY RHD, CASCADIA, COLUMBIA, CENTURY ST, CORONADO, STERLING ACTERRA, L-LINE AND WESTERN STAR 4900 TRUCKS EQUIPPED WITH BENDIX MV-3 DASH CONTROL VALVES. THE MOLDED VALVE BODY HAS AN INCORRECT CORE PIN IN THE INJECTION MOLD CAUSING THE VALVE BODY TO BE OVERSIZED IN THE DOUBLE CHECK VALVE AREA. THIS CONDITION CAN ALLOW THE RUBBER DOUBLE CHECK VALVE TO BECOME LODGED IN THE BODY OPENING UNDER CERTAIN CIRCUMSTANCES.

Consequence: IF THE DOUBLE CHECK VALVE BECOMES LODGED, IN THE EVENT OF A PRIMARY RESERVOIR FAILURE, AIR PRESSURE CAN LEAK PAST THE LODGED DOUBLE CHECK VALVE THEREBY DEPLETING THE SECONDARY RESERVOIR, CAUSING REDUCED ABILITY FOR MODULATING THE SERVICE EMERGENCY BRAKES INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE MV-3 DASH VALVE FOR THE PRODUCTION DATE CODE. VALVES IN THE AFFECTED PRODUCTION LOTS WILL BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 9, 2008. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2010-03-23 (March 23, 2010) · Model years: 2008, 2009, 2010

DAIMLER TRUCKS HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN MODEL YEAR 2008 THROUGH 2010 FREIGHTLINER COLUMBIA, FLD, STERLING 9500 AND WESTERN STAR 4900 EMERGENCY VEHICLES. THE ENGINE MAY SHUT DOWN UNEXPECTEDLY WHEN A DIESEL PARTICULATE FILTER OVER TEMPERATURE CONDITION IS DETECTED.

Consequence: UNEXPECTED EMERGENCY VEHICLE ENGINE SHUTDOWN UNDER CERTAIN CONDITIONS COULD HAMPER RESCUE OPERATIONS AND PLACE THE PUBLIC AT RISK.

Remedy: THE ENGINE CONTROL LOGIC WILL BE REPROGRAMMED TO ILLUMINATE A MALFUNCTION INDICATOR LIGHT WITHOUT REQUESTING ENGINE SHUTDOWN. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL. PLEASE SEE DAIMLER TRUCKS DEFECT REPORT 10E-005. THE SAFETY RECALL BEGAN ON MAY 17, 2010. OWNERS MAY CONTACT DETROIT DIESEL AT 1-313-592-5800 OR DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2011-03-29 (March 29, 2011) · Model years: 2008, 2009, 2010

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008-2010 WESTERN STAR 4900 TRUCKS EQUIPPED WITH CATERPILLAR C15 ENGINES AND MANUFACTURED FROM FEBRUARY 9, 2007, THROUGH FEBRUARY 20, 2009. DEGRADATION OF A COMBUSTION TUBE WELD CAN CAUSE RADIAL HEAT IMPINGEMENT ON THE BODY WHICH MAY BURN THROUGH CERTAIN BODIES USED ON C15 ENGINES.

Consequence: THIS COULD RESULT IN A FIRE.

Remedy: CATERPILLAR IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. PLEASE SEE CATERPILLAR'S DEFECT REPORT 11E-006. CATERPILLAR WILL REPLACE THE SINGLE PIECE COMBUSTION TUBE WITH A THICK WALL COMBUSTION TUBE WHICH WON'T ALLOW THE HEAT TO BREAK THROUGH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN IN AUGUST 2011. OWNERS MAY CONTACT CATERPILLAR TOLL-FREE AT 1-800-447-4986.

Reported: 2017-11-27 (November 27, 2017) · Model years: 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018

Daimler Trucks North America, LLC (DTNA) is recalling certain 2008-2018 Freightliner Cascadia, Western Star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.

Consequence: If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on January 22, 2018. The recall began on May 9, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-756.

Reported: 2009-06-18 (June 18, 2009) · Model years: 2009, 2010

DAIMLER TRUCKS IS RECALLING 53 MY 2009-2010 WESTERN STAR 4900 TRUCKS BUILT WITH DD15 ENGINES. A NEW FORWARD CAB CROSSMEMBER DESIGN REDUCED CLEARANCE FOR CAB MOUNTED BATTERY DISCONNECT SWITCH POWER CABLES ON STANDARD CAB HEIGHT VEHICLES. DURING CAB ARTICULATION THE NEW CROSSMEMBER MAY PINCH POWER CABLES AGAINST THE CAB.

Consequence: CABLES THAT BECOME PINCHED BETWEEN THE CAB AND FORWARD CAB CROSSMEMBER COULD SHORT TO GROUND AND POTENTIALLY OVERHEAT RESULTING IN A POSSIBLE VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.

Remedy: DEALERS WILL REMOVE THE CABLES AND REINSTALL THEM IN A NEW SAFE LOCATION. DAMAGED CABLES WILL BE REPLACED. BOTH WILL BE DONE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE AUGUST 7, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL FREE AT 1-800-547-0712.

Reported: 2009-10-06 (October 6, 2009) · Model years: 2009

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 HEAVY TRUCKS MANUFACTURED BETWEEN MAY 5, 2008 AND JANUARY 7, 2009, EQUIPPED DD15 ENGINES AND WITH BOSCH HIGH PRESSURE FUEL PUMPS. THE FASTENERS ON THESE FUEL PUMPS COULD BE UNDER-TORQUED ALLOWING THE "O" RING BETWEEN THE PUMP HOUSING AND THE BARREL TO PROTRUDE AND LEAK.

Consequence: IF A DIESEL FUEL LEAK CONTINUES UNDETECTED UNDER CERTAIN CONDITIONS FUEL MAY IGNITE ON A HOT ENGINE SURFACE AND/OR FUEL MAY SPILL ON THE ROAD INCREASING THE RISK OF A CRASH.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND THE REMEDY WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES AND DIRECT WARRANTY CUSTOMERS. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2010-07-27 (July 27, 2010) · Model years: 2009, 2010, 2011

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 FREIGHTLINER CASCADIA, CENTURY, COLUMBIA, CORONADO, M2, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM FEBRUARY 19, 2009 THROUGH JULY 9, 2010, EQUIPPED WITH SPECIFIC DD13 AND DD15 ENGINES ASSEMBLED WITH A BOSCH HIGH PRESSURE FUEL PUMP ELEMENT WHICH MAY DEVELOP A CRACK DUE TO HYDROGEN INDUCED STRESS CORROSION. OVER TIME THE BARREL OF THE BOSCH HIGH PRESSURE FUEL PUMP ELEMENT USED ON SPECIFIC DD13/DD15 ENGINES MAY DEVELOP A CRACK DUE TO HYDROGEN INDUCED STRESS CORROSION RESULTING IN A DIESEL FUEL LEAK.

Consequence: IF A DIESEL FUEL LEAK CONTINUES UNDETECTED, FUEL MAY SPILL ONTO THE ROADWAY POTENTIALLY RESULTING IN A CRASH.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 28, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

Reported: 2011-05-18 (May 18, 2011) · Model years: 2009, 2010, 2011

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2009 THROUGH 2011 FREIGHTLINER CASCADIA, CENTURY, COLUMBIA, CORONADO, M2, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM FEBRUARY 19, 2009, THROUGH JULY 9, 2010, EQUIPPED WITH SPECIFIC DD13 AND DD15 ENGINES ASSEMBLED WITH A BOSCH HIGH PRESSURE FUEL PUMP ELEMENT WHICH MAY DEVELOP A CRACK DUE TO HYDROGEN INDUCED STRESS CORROSION. THE CRACK MAY RESULT IN A DIESEL FUEL LEAK.

Consequence: IF A DIESEL FUEL LEAK CONTINUES UNDETECTED, FUEL MAY SPILL ONTO THE ROADWAY INCREASING THE RISK OF A CRASH.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE VEHICLES, FREE OF CHARGE. THIS RECALL IS AN EXPANSION OF A PREVIOUS RECALL (SEE RECALL CAMPAIGN 10V-339). THE SAFETY RECALL BEGAN ON MAY 18, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

Reported: 2012-05-23 (May 23, 2012) · Model years: 2009

DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING 12 MY 2009 WESTERN STAR 4900 TRUCKS BUILT WITH DD15 ENGINES. A NEW FORWARD CAB CROSSMEMBER DESIGN REDUCED CLEARANCE FOR CAB MOUNTED BATTERY DISCONNECT SWITCH POWER CABLES ON STANDARD CAB HEIGHT VEHICLES. DURING CAB ARTICULATION, THE NEW CROSSMEMBER MAY PINCH POWER CABLES AGAINST THE CAB.

Consequence: CABLES THAT BECOME PINCHED BETWEEN THE CAB AND FORWARD CAB CROSSMEMBER COULD SHORT TO GROUND AND POTENTIALLY OVERHEAT RESULTING IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.

Remedy: DTNA WILL NOTIFY OWNERS, AND DEALERS WILL REMOVE THE CABLES AND REINSTALL THEM IN A NEW SAFE LOCATION. DAMAGED CABLES WILL BE REPLACED. BOTH WILL BE DONE FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2012. THIS RECALL IS AN EXPANSION OF RECALL 09V-226. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL FREE AT 1-800-547-0712.

Reported: 2013-09-05 (September 5, 2013) · Model years: 2009, 2010, 2011, 2012, 2013, 2014

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2009-2014 Western Star 4900 vehicles manufactured May 27, 2008, through March 22, 2013. A potential misalignment of a clearance hole in the B-pillar reinforcement may affect the performance of the seatbelt D-ring anchorage point.

Consequence: In the event of a crash, the seatbelt may not properly restrain the occupant, increasing the risk of injury.

Remedy: DTNA will notify owners, and dealers will reinforce the D-ring anchor points, free of charge. The recall began during january November 2014. Owners may contact DTNA at 1-800-547-0712. DTNA's recall number is FL-645.

Reported: 2010-11-04 (November 4, 2010) · Model years: 2011

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 FREIGHTLINER CORONADO, COLUMBIA, FLD MILITARY, BUSINESS CLASS M2, CASCADIA, CENTURY, AND WESTERN STAR 4900 TRUCKS MANUFACTURED FROM AUGUST 9, 2010, THROUGH OCTOBER 27, 2010 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE VEHICLES WERE EQUIPPED WITH LABELS MISSING RECOMMENDED COLD TIRE INFLATION PRESSURES.

Consequence: FAILURE TO FOLLOW PROPER TIRE INFLATION RECOMMENDATIONS CAN RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: LABELS WITH MISSING INFORMATION WILL BE REPLACED WITH CORRECTED LABELS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 15, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2011-02-23 (February 23, 2011) · Model years: 2011

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 FREIGHTLINER CASCADIA AND CONORADO AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM APRIL 22, 2010, THROUGH JANUARY 28, 2011, EQUIPPED WITH AN EPA10 ISX ENGINE. THE ROUTING AND SECURING OF THE ALTERNATOR CABLES MAY ALLOW THE CABLE TO CONTACT OR NEARLY CONTACT AN ENGINE HEAT SHIELD POTENTIALLY DAMAGING THE CABLE INSULATION.

Consequence: A POSITIVE ALTERNATOR CABLE, WITH DAMAGED INSULATION, THAT MAY CONTACT A GROUNDED COMPONENT CAN CAUSE A SHORT CIRCUIT THAT CAN RESULT IN A FIRE.

Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE ALTERNATOR CABLES FOR DAMAGE TO THE INSULATION. CABLES WITH DAMAGE TO THE INSULATION WILL BE REPLACED. THE CABLE ROUTING AND SECURING WILL BE MODIFIED TO ENSURE SUFFICIENT CLEARENCE TO THE HEAT SHIELD. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 27, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2011-04-20 (April 20, 2011) · Model years: 2011

DTNA IS RECALLING CERTAIN MODEL YEAR 2011 FREIGHTLINER CASCADIA, COLUMBIA GLIDER KIT, CORONADO, M2, AND WESTERN STAR4900 HEAVY TRUCKS MANUFACTURED FROM OCTOBER 16, 2010, THROUGH MARCH 9, 2011, EQUIPPED WITH GUNITE AUTOMATIC SLACK ADJUSTERS MANUFACTURED FROM OCTOBER 15, 2010, THROUGH JANUARY 31, 2011. DUE TO AN INCOMPLETE "KNITTING" OF THE IRON AT THE TIME OF CASTING, INADEQUATE STRUCTURAL INTEGRITY OF THE SLACK ADJUSTER HOUSING CAN OCCUR, WHICH COULD CAUSE THE HOUSING TO BREAK AT THE HANDLE UNDER NORMAL OPERATING LOADS.

Consequence: IF THE SLACK ADJUSTER HOUSING WERE TO BREAK, THE WHEEL BRAKE TO WHICH THE SLACK ADJUSTER IS ATTACHED WOULD NO LONGER FUNCTION, CAUSING THE VEHICLE TO HAVE REDUCED BRAKING CAPACITY AND, IF MOUNTED ON THE STEER AXLE, THE VEHICLE COULD PULL TO ONE SIDE, POSSIBLY RESULTING IN A CRASH.

Remedy: DTNA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE ANY AFFECTED SLACK ADJUSTERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 5, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Reported: 2011-05-16 (May 16, 2011) · Model years: 2011, 2012

DTNA IS RECALLING CERTAIN MODEL YEAR 2011-2012 WESTERN STAR 4900 VEHICLES MANUFACTURED FROM APRIL 1, 2010, THROUGH MAY 13, 2011, WITH STANDARD CAB HEIGHT AND A DD13 ENGINE. THE SUPPLY AND DELIVERY AIRLINES FOR THE FOOT VALVE MAY CONTACT THE AIR INTAKE ON THE ENGINE. RELATIVE MOTION BETWEEN THE CAB AND THE ENGINE MAY ALLOW THE DELIVERY AIRLINES TO CHAFE ON THE AIR INTAKE.

Consequence: A HOLE IN THE DELIVERY AIR LINE MAY DEVELOP, EVENTUALLY LEADING TO REDUCED BRAKING CAPACITY TO THE FRONT OR REAR BRAKES, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE AIR LINES AND REROUTE IF NECESSARY TO PROVIDE ADDITIONAL CLEARANCE TO THE ENGINE AIR INTAKE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 21, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Reported: 2011-11-18 (November 18, 2011) · Model years: 2011

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011 WESTERN STAR 4900 TRUCKS, MANUFACTURED FROM DECEMBER 14, 2010, THROUGH JANUARY 26, 2011, EQUIPPED WITH MERITOR AXLE ASSEMBLIES. THE WELD THAT ATTACHES A TOWER BRACKET TO THE HOUSING IN SUSPECT ASSEMBLIES MAY CRACK AS A RESULT OF IMPROPER WELDING PROCEDURES.

Consequence: DETACHMENT OF THE BRACKET MAY LEAD TO A LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A CRASH.

Remedy: DAIMLER TRUCKS DEALERS WILL INSPECT THE AXLES FOR CRACKS AND THE WELDS WILL BE REPAIRED AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 30, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

Reported: 2011-12-27 (December 27, 2011) · Model years: 2011, 2012

DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2011 AND 2012 FREIGHTLINER BUSINESS CLASS M2 AND WESTERN STAR 4900 EMERGENCY VEHICLES MANUFACTURED FROM JULY 2, 2010, THROUGH DECEMBER 13, 2011, EQUIPPED WITH A DD13 EPA10 DETROIT DIESEL ENGINE. THE ENGINE SHUTDOWN SOFTWARE NORMALLY PROVIDED TO PROTECT THE ENGINE AND VEHICLE MAY NOT HAVE BEEN DISABLED ON ENGINES INTENDED FOR EMERGENCY VEHICLE APPLICATIONS.

Consequence: IF THE VEHICLE OPERATOR RECEIVES AND IGNORES MULTIPLE WARNINGS INDICATING THE NEED FOR OPERATOR INTERVENTION, THE ENGINE MAY SHUT DOWN UNEXPECTEDLY. UNEXPECTED EMERGENCY VEHICLE ENGINE SHUTDOWN UNDER CERTAIN CONDITIONS COULD HAMPER RESCUE OPERATIONS AND PLACE THE PUBLIC AT RISK.

Remedy: DTNA WILL NOTIFY OWNERS, AND DEALERS WILL DISABLE THE ENGINE SHUTDOWN SOFTWARE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 13, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Reported: 2018-05-29 (May 29, 2018) · Model years: 2012, 2013, 2014, 2015, 2016, 2017, 2018, 2019

Daimler Trucks North America LLC (DTNA) is recalling certain 2012-2019 Western Star 4900 trucks built with Lowmax hoods and disc brakes. There may be insufficient clearance between the front brake hose and the hood resulting in the brake hose being chafed.

Consequence: Front brake hose chafing may causing air loss, possibly reducing braking effectiveness and increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the front axle brake hose, free of charge. DTNA issued owners an interim notification on July 27, 2018. The recall began November 27, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-773.

Reported: 2018-07-31 (July 31, 2018) · Model years: 2012, 2013, 2014, 2015

Daimler Trucks North America, LLC (DTNA) is recalling certain 2012-2015 Freightliner Cascadia, Coronado, Business Class M2, 114SD, and Western Star 4900 trucks. In certain front axle, brake lining, and brake spider combinations, braking may cause high vibrations, resulting in early failure of the tie-rod tube.

Consequence: A tie-rod failure would cause a disconnect between the front wheels, resulting in a loss of steering ability, thereby increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the brake linings, brake spider, and tie-rod, free of charge. The recall began March 22, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL782.

Reported: 2012-06-12 (June 12, 2012) · Model years: 2013

DAIMLER TRUCKS NORTH AMERICA (DTNA) IS RECALLING CERTAIN MODEL YEAR 2013 FREIGHTLINER, WESTERN STAR, FREIGHTLINER CUSTOM CHASSIS TRUCKS, AND THOMAS BUILT BUSES MANUFACTURED FROM APRIL 18, 2012, THROUGH MAY 11, 2012, AND EQUIPPED WITH DETROIT AXLE-BRAND FRONT AXLE KNUCKLES. THE FRONT KNUCKLES ON THESE VEHICLES MAY HAVE A MACHINING ERROR IN THE WHEEL BEARING AREA WHICH MAY LEAD TO PREMATURE SPINDLE FAILURE.

Consequence: IF THE SPINDLE FAILS, THE WHEEL MAY SEPARATE FROM THE KNUCKLE, RESULTING IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: DTNA WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE AFFECTED COMPONENTS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 10, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS NORTH AMERICA TOLL FREE AT 1-800-547-0712.

Reported: 2021-11-17 (November 17, 2021) · Model years: 2013, 2014, 2015, 2016, 2017, 2018, 2019, 2020, 2021, 2022

Daimler Trucks North America, LLC (DTNA) is recalling certain 2012-2021 Freightliner SD 108, Freightliner SD 114, 2016-2020 Freightliner Coronado, 2013 Western Star 6900, 2013-2022 Western Star 4700, Western Star 4900, and 2022 49X vehicles. The tires and rims are not approved and rated for these vehicles from the Tire and Rim Association or tire manufacturer. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims-Other Than Passenger Cars."

Consequence: Unapproved tires that are not rated for the vehicle can cause tire performance issues, increasing the risk of a crash.

Remedy: Dealer will inspect and replace, as necessary, tires and rims, free of charge. Interim owner notification letters were mailed January 14, 2022. Owner notification letters were mailed on April 22, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall FL-908.

Reported: 2013-11-29 (November 29, 2013) · Model years: 2014

Daimler Trucks North America (DTNA) is recalling certain model year 2014 Freightliner 108SD, 114SD, 122SD, Coronado, Argosy, Cascadia, M2 Business Class, and Western Star 4700, 4900, and 6900 vehicles manufactured August 5, 2013, through November 15, 2013; and equipped with IMMI-brand L9 seat belt buckles. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Consequence: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy: DTNA will notify owners, and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall is expected to begin by January 26, 2014. Owners may contact Daimler at 1-800-385-4357. DTNA's number for this campaign is FL-654.

Reported: 2014-03-28 (March 28, 2014) · Model years: 2014

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014 Freightliner 108SD, 114SD, 122SD, Coronado, Argosy, Cascadia, Columbia, and M2 Business Class, and Western Star 4700, and 4900 vehicles manufactured August 5, 2013, through November 15, 2013, and equipped with IMMI-brand L9 seat belt buckles. When the button is pressed to release the seat belt, the latch plate can become partially engaged with the buckle, making the seat belt difficult to unlatch. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 209, "Seat Belt Assemblies."

Consequence: If the latch plate remains partially engaged after the button is pressed, egress from the vehicle could be hindered which would increase the risk of injury in the event of an emergency.

Remedy: DTNA will notify owners, and dealers will inspect and replace the seat belt buckle, as necessary, free of charge. The recall began on May 22, 2014. Owners may contact Daimler at 1-800-385-4357. DTNA's number for this campaign is FL-661. Note: This is an expansion of recall 13V-604.

Reported: 2014-09-03 (September 3, 2014) · Model years: 2014, 2015

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2015 Western Star 4900 trucks manufactured June 24, 2013, to April 30, 2014. The affected vehicles were manufactured without Anti-lock Brake Systems. As such, these vehicles fail to meet the requirements of Federal Motor Vehicle Safety Standard No. 121, "Air Brake Systems."

Consequence: When not equipped with ABS, the affected vehicles have a greater chance of wheel lock up when braking, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will install an Anti-lock Brake System, free of charge. The recall began on October 28, 2014. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-665.

Reported: 2015-03-27 (March 27, 2015) · Model years: 2014, 2015

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2015 Western Star 4700, 4900, 5700, and 6900 trucks manufactured from July 23, 2013, through December 4, 2014, and equipped with certain Kidde disposable handheld fire extinguishers. These fire extinguishers may not fully discharge as designed when the lever is repeatedly pressed and released.

Consequence: In the event of a fire, if the fire extinguisher does not work correctly, there is an increased risk of injury to the truck occupants.

Remedy: DTNA will notify owners, and Kidde will provide a replacement extinguisher when contacted directly or affected owners may go to an authorized DTNA repair facility to order a replacement fire extinguisher, free of charge. The recall began on May 26, 2015. Affected owners may contact Kidde directly toll free at (855) 283-7991 from 8 a.m. to 5 p.m. ET Monday through Friday or owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL680.

Reported: 2016-10-05 (October 5, 2016) · Model years: 2014, 2015, 2016, 2017

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2014-2017 Western Star 4900 and 5700 trucks manufactured March 22, 2013, to September 23, 2016 and equipped with a Stratosphere sleeper cab. The seat belt mounting plate may have a drill hole that is too large.

Consequence: If the plate has a hole that is too big, the plate may fail when it stressed such as in the event of a crash, preventing the seat belt from adequately restraining the seat occupant, increasing the risk of injury.

Remedy: DTNA will notify owners, and dealers will reinforce the seat belt mounting plate, free of charge. An interim notice was mailed to owners on December 7 2016. The final remedy is now available. A second notice was mailed to owners on February 24, 2017. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-725.

Reported: 2014-11-28 (November 28, 2014) · Model years: 2015

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2015 Freightliner Business Class M2, 108SD, 114SD, 122SD, Coronado, Columbia Glider, Argosy Glider, Western Star 4700, and Western Star 4900 trucks manufactured September 17, 2014, to November 10, 2014 equipped with Haldex Life Seal brake chambers. The affected vehicles may experience brake drag due to an improperly seated diaphragm in the brake chamber.

Consequence: While traveling at highway speeds, brake drag may cause loss of vehicle control, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect and repair the diaphragm if necessary, free of charge. Owners were sent an interim notice on January 27, 2015. The recall began on September 25, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-676.

Reported: 2015-03-30 (March 30, 2015) · Model years: 2015

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2015 Freightliner Cascadia, Business Class M2, 108SD, 114SD, 122SD, Coronado, Western Star 4700, and Western Star 4900 trucks manufactured October 6, 2014, to February 16, 2015, and equipped with Haldex Life Seal brake chambers. The affected vehicles may experience brake drag due to an improperly seated diaphragm in the brake chamber.

Consequence: While traveling at highway speeds, brake drag may cause loss of vehicle control, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the brake chambers, free of charge. Owners were mailed interim notices at the end of May 2015. The recall began on September 25, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL676.

Reported: 2015-06-17 (June 17, 2015) · Model years: 2015

Daimler Trucks North America, LLC (DTNA) is recalling certain model year 2015 Western Star 4700, 4800 and 4900 trucks manufactured November 15, 2014, to January 30, 2015. In the affected vehicles, the speedometer may not operate properly, possibly not displaying the vehicle's speed.

Consequence: If the speedometer does not show the vehicle speed, the driver may unknowingly exceed the posted speed limit, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will install a new speedometer, free of charge. The recall began on July 28, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-683.

Reported: 2015-12-22 (December 22, 2015) · Model years: 2015, 2016

Daimler Trucks North America, Inc. (DTNA) is recalling certain model year 2015-2016 Freightliner 108SD, 114SD, Business Class M2, and Western Star 4900 vehicles manufactured September 26, 2014, to November 6, 2015, and equipped with certain drive axles manufactured by Marmon-Herrington. The affected axles have hex nuts on the flange yoke that may not have been properly tightened.

Consequence: If the hex nuts are not tightened to specification, the driveshaft may disconnect from the drive axle, resulting in a loss of propulsion and increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect the hex nuts, tightening them as necessary, free of charge. The recall began on February 5, 2016. Owners may contact DTNA customer service at 1-800-745-8000, or Marmon-Herrington customer service at 1-800-547-0712. DTNA's number for this recall is FL-699.

Reported: 2017-02-27 (February 27, 2017) · Model years: 2015, 2016, 2017, 2018

Daimler Trucks North America LLC (DTNA) is recalling certain 2015-2018 Western Star 4900 trucks. The aluminum air tanks on these vehicles may have improper welds possibly resulting in a rapid loss of air pressure.

Consequence: A rapid loss of air pressure without warning may cause a sudden application of the park brakes, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the aluminum air tanks with steel, triple compartment, air tanks, free of charge. The recall began on April 27, 2017. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-732.

Reported: 2019-05-14 (May 14, 2019) · Model years: 2015

Daimler Trucks North America LLC (DTNA) is recalling certain 2004-2019 Freightliner 108SD, 114SD, 122SD, Cascadia, Columbia, Classic, FL80, FLD 120SD, Business Class M2, Western Star 4700, 4900, 6900, Sterling Acterra, L7500, LT7500, L8500, LT8500, L9500, and LT9500 vehicles. The vehicles may have an insufficient service brake air reservoir capacity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Consequence: An insufficient air reservoir volume may reduce brake effectiveness, increasing the risk of crash.

Remedy: DTNA will notify owners, and dealers will add air reservoir capacity to the affected vehicles. Owner letters were mailed on November 29, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-815.

Reported: 2015-10-02 (October 2, 2015) · Model years: 2016

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2016 Freightliner Cascadia, Business Class M2, 108SD, 114SD, and 122SD, Western Star 4700 and 4900, Thomas Built Buses Saf-T-Liner C2, and Freightliner MT55 vehicles manufactured August 7, 2015, to August 26, 2015. The affected vehicles are equipped with certain Cummins ISB6.7, ISL9, ISX12 or ISX15 engines whose engine control module (ECM) may short circuit and blow a fuse resulting in the engine stalling without warning.

Consequence: An engine that stalls without warning increases the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the ECM free of charge. The recall began on October 22, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-690.

Reported: 2017-10-06 (October 6, 2017) · Model years: 2016

Daimler Trucks North America LLC (DTNA) is recalling certain 2016 Western Star 4900 and Freightliner Cascadia vehicles, equipped with certain Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.

Consequence: If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. DTNA issued an interim to owners on December 4, 2017. The recall began on March 7, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-751.

Reported: 2019-11-04 (November 4, 2019) · Model years: 2016, 2017, 2018, 2019, 2020

Daimler Trucks North America LLC (DTNA) is recalling certain 2016-2020 Western Star 4900 and 5700 vehicles equipped with sleeper cab vent windows. Due to improper adhesive, the vent window may detach from the vehicle.

Consequence: If the vent window detaches while the vehicle is in motion, it can become a road hazard, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the vent windows, free of charge. DTNA issued owners an interim notification on December 27, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-836.

Reported: 2016-06-09 (June 9, 2016) · Model years: 2017

Daimler Trucks North America LLC (DTNA) is recalling certain model year 2017 Freightliner Cascadia, 122SD, Western Star 4900SA and 4900FA, and FCCC XCM and XCP trucks manufactured from March 14, 2016, through May 18, 2016, equipped with a Cummins ISX12 or ISX15 engine using certain engine control modules (ECM). These ECM's may experience an internal electrical short that can cause a fuse to blow, resulting in an unexpected engine stall without the ability to restart the engine.

Consequence: An engine stall without the ability to restart the engine can increase the risk of a crash.

Remedy: Cummins will notify owners, and Cummins dealers will install a new ECM, and correct ECM calibrations, free of charge. The recall began on July 8, 2016. Owners may contact DTNA customer service at 1-800-547-0712, or Cummins customer service at 1-800-343-7357. DTNA's number for this recall is FL-715.

Reported: 2017-07-19 (July 19, 2017) · Model years: 2017, 2018

Daimler Trucks North America (DTNA) is recalling certain 2017-2018 Freightliner 122SD trucks, Western Star 4900 and 6900 trucks, and Freightliner Custom Chassis XCM and XCP chassis equipped with Cummins ISX15 engines. The affected engines have a fuel pump whose drive gear may slip on its drive shaft, resulting in a loss of fuel pump function.

Consequence: Failure of the fuel pump will result in a sudden engine stall with no warning, and with no ability to restart, increasing the risk of a crash.

Remedy: Cummins will send notices to the owners of the affected vehicles and Cummins dealers will replace the fuel pumps, free of charge. The recall began on September 11, 2017. Owners may contact Cummins customer service at 1-800-286-6467 or DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL744.

Reported: 2017-08-24 (August 24, 2017) · Model years: 2017, 2018

Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2018 Western Star 4900 trucks. The front axle weight capacity may exceed the spring capacity.

Consequence: Overloaded springs may result in the front axle separating from the vehicle, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the front axle springs, free of charge. The recall began on October 16, 2017. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-745.

Reported: 2018-03-26 (March 26, 2018) · Model years: 2017, 2018, 2019

Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2019 Western Star 4700, 4900, 5700, and 6900 trucks. The affected trucks have a power stud that passes through the bulkhead. In certain circumstances the power stud may contact the bulkhead and result in an electrical arc.

Consequence: An electrical arc can increase the risk of a fire.

Remedy: DTNA will notify owners, and dealers will inspect the power stud for the proper clearance to the bulkhead, and replace it if necessary, free of charge. DTNA issued an interim notification to owners on May 23, 2018. The recall began October 29, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-766.

Reported: 2018-05-29 (May 29, 2018) · Model years: 2017, 2018, 2019

Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2019 Freightliner M2 Business Class, 108SD, 114SD and Cascadia trucks, Western Star 4700, 4900, and 5700 trucks, FCCC S2C 106 Cab, S2G Cab, XBR, XBS, XCL, XCM, XCP, XCR, and XCS chassis equipped with air disc brakes. The brake caliper mounting bolts on these vehicles may be insufficiently tightened, allowing the bolts to loosen.

Consequence: If the brake caliper mounting bolts loosen, braking performance may be reduced, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect the brake caliper mounting bolts and tighten them as necessary, free of charge. DTNA issued owners an interim notification on July 25, 2018. The recall began September 4, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-772.

Reported: 2018-08-30 (August 30, 2018) · Model years: 2017, 2018, 2019

Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2019 Freightliner Cascadia, Coronado and 122SD, and Western Star 4900 trucks, equipped with Cummins ISX15 or X15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.

Consequence: If the fuel line bursts, fuel may leak onto the road resulting in a roadway hazard for other motorists. The engine may also stall without warning, resulting in the vehicle's inability to restart, increasing the risk of a crash.

Remedy: Dealers will replace the affected nylon fuel line with a steel fuel line, free of charge. The recall began November 21, 2018. Owners may contact DTNA customer service at 1-800-547-0712 or Cummins customer service at 1-800-286-6467. DTNA's number for this recall is FL789.

Reported: 2018-12-19 (December 19, 2018) · Model years: 2017, 2018, 2019

Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2019 Freightliner 114SD, 122SD, 108SD, Cascadia and Business class M2 trucks, Freightliner Custom Chassis XBS, XCL, XCM, MT45, MT55, S2G, S2RV, XCR and XCS custom chassis and Western Star 4700, 4900 and 5700 trucks equipped with Detroit Axle axles. The affected vehicles may have loose steering and tie rod arm bolts.

Consequence: Loose tie rod arm bolts may lead to separation of the tie rod arm, resulting in a loss of vehicle control, increasing the risk of a crash.

Remedy: DTNA has notified owners, and dealers will inspect the steering arm and tie rod arm bolts for to make sure that they are properly tightened, installing new fasteners as necessary, free of charge. The recall began February 9, 2019. Owners may contact Daimler Trucks at 1-800-547-0712. DTNA's number for this recall is FL-802.

Reported: 2019-10-10 (October 10, 2019) · Model years: 2017, 2018, 2019, 2020

Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2020 Western Star 4900 and 5700 vehicles. The adhesive bond may fail allowing the baggage or sleeper side door to separate from the hinges.

Consequence: A baggage or sleeper side door that separates from the vehicle while in motion can cause road debris, increasing the risk of an injury or crash.

Remedy: DTNA will notify owners and dealers will install reinforcement clips with mechanical fasteners on each baggage and sleeper door hinge, free of charge. DTNA issued owners an interim notification on December 6, 2019. The recall began September 21, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL834.

Reported: 2021-11-12 (November 12, 2021) · Model years: 2017, 2018, 2019

Daimler Trucks North America LLC (DTNA) is recalling certain 2017-2019 Western Star 4700, 4900, 5700, and 6900 trucks. The affected trucks have a power stud that passes through the bulkhead. In certain circumstances, the power stud may contact the bulkhead and result in an electrical arc.

Consequence: An electrical arc can increase the risk of a fire.

Remedy: Dealers will replace the pass-through power studs, free of charge. Owner notification letters were mailed January 7, 2022. This recall supersedes previous recall number 18V-191. Vehicles previously inspected and considered complete under 18V-191 will need to return for the new remedy. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-907.

Reported: 2018-10-05 (October 5, 2018) · Model years: 2018, 2019

Daimler Trucks North America, LLC (DTNA) is recalling certain 2018-2019 Freightliner 108SD, 114SD, Cascadia, Business Class M2, Freightliner Custom Chassis Corporation S2C 106 Cab, S2G Cab Chassis, XCL, XCM, XBS, XCP, XCR, Western Star 4700, 4900 and 5700 trucks. The brake caliper mounting bolts may have been insufficiently tightened.

Consequence: Loose brake caliper mounting bolts can reduce brake effectiveness, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will check and tighten the brake caliper mounting bolts, free of charge. The recall began December 3, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-794.

Reported: 2018-12-19 (December 19, 2018) · Model years: 2018, 2019

Daimler Trucks North America LLC (DTNA) is recalling certain 2018-2019 Freightliner 108SD, 114SD, 122SD, Cascadia, Business Class M2, Western Star 4700, 4900, and 5700 vehicles, equipped with certain Eaton ECA heavy-duty truck clutches. An internal component in the clutch assembly may fail, possibly resulting in unintended vehicle movement.

Consequence: Unintended vehicle movement can increase the risk of a crash.

Remedy: DTNA will notify owners, and dealers will update the software, and repair any physical components, free of charge. DTNA issued owners an interim notification on February 16, 2019. The recall began July 31, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-803.

Reported: 2020-10-16 (October 16, 2020) · Model years: 2018, 2019

Daimler Trucks North America LLC (DTNA) is recalling certain 2018-2019 Freightliner Cascadia, Business Class M2, 108SD, 114SD and 122SD and Western Star 4700, 4900 and 5700 vehicles. An internal component within the clutch assembly may fail, which in certain circumstances could allow the vehicle to move unexpectedly.

Consequence: Unintended vehicle movement van increase the risk of a crash.

Remedy: DTNA will notify owners, and dealers will update the software and replace the clutches, free of charge. DTNA issued owners an interim notification on December 7, 2020. Owner notification letters were mailed on May 28, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-865.

Reported: 2018-09-19 (September 19, 2018) · Model years: 2019

Daimler Trucks North America, LLC (DTNA) is recalling certain 2019 Freightliner 108SD, 114SD, 122SD and Business Class M2 trucks and Western Star 4700 and 4900 trucks, equipped with certain Bridgestone M854 tires with date codes 2418-2518, Bridgestone M860A tires with date code 2518, and Bridgestone M864 tires with date codes 2318-2418, all of size 425/65R22.5. The sidewall steel body cords may be exposed, which can cause unexpected, rapid air loss during use.

Consequence: Rapid air loss can increase the risk of a crash.

Remedy: DTNA will notify owners, and dealers will inspect and replace the affected tires, as necessary, free of charge. The recall began October 8, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL790.

Reported: 2019-03-05 (March 5, 2019) · Model years: 2019

Daimler Trucks North America LLC (DTNA) is recalling certain 2019 Western Star 4700 and 4900 trucks. The vehicles are accumulating distance in kilometers, but the odometer display is labeled as being miles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."

Consequence: The odometer failing to register the correct distance travelled could cause driver confusion, as well as possible incorrect assumptions about driver speed. An incorrect speed assumption may increase the risk of crash.

Remedy: DTNA will notify owners, and dealers will replace the speedometer, free of charge. The recall began April 29, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-812.

Reported: 2022-12-12 (December 12, 2022) · Model years: 2019, 2020, 2021, 2022

Daimler Trucks North America, LLC (DTNA) is recalling certain 2020-2023 Freightliner 114SD, 2023 Freightliner 122SD, 2020 Western Star 4700, 2019-2022 Western Star 4900, 2019-2023 Freightliner Business Class M2, and 2021 Freightliner Cascadia vehicles. The vehicles are equipped with tires that are not compatible with their 8.25-inch rims. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims-Other Than Passenger Cars."

Consequence: Driving with tires that are not compatible with their rims can reduce tire performance, increasing the risk of a crash.

Remedy: Dealers will replace the tires, free of charge. Owner notification letters were mailed June 2, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-962.

Reported: 2020-04-10 (April 10, 2020) · Model years: 2020, 2021

Daimler Trucks North America LLC (DTNA) is recalling certain 2020 Freightliner 108SD and 2020-2021 Freightliner Coronado, 114SD, and Western Star 4700 and 4900 vehicles. The Gross Axle Weight Rating (GAWR) on the certification label may be incorrect, possibly resulting in the vehicle being overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Wheels and Rims - Other Than Passenger Cars."

Consequence: An overloaded vehicle can increase the risk of a crash.

Remedy: DTNA will notify owners, and dealers will update the GAWR labels, free of charge. The recall began May 28, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL847.

Reported: 2020-09-03 (September 3, 2020) · Model years: 2020, 2021

Daimler Truckers North America LLC (DTNA) is recalling certain 2020-2021 Freightliner 114SD, 122SD and Western Star 4700, and 4900 vehicles equipped with certain SL2065 steerable lift axles. The lower rear pivot cap screws may not be long enough to sufficiently engage the locking feature of the corresponding nuts.

Consequence: If the screws are not long enough to engage the corresponding nuts, the hardware may separate from the suspension system, becoming a road hazard, increasing the risk of a crash and/or injury.

Remedy: DTNA will notify owners, and dealers will inspect the lower rear pivot cap screws for the proper length, correcting the hardware as necessary, free of charge. The recall began October 30, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-862.

Reported: 2020-10-14 (October 14, 2020) · Model years: 2020, 2021

Daimler Trucks North America LLC (DTNA) is recalling certain 2020-2021 Western Star 4700 and 4900 and Freightliner Coronado, 108SD and 114SD vehicles. The vehicle certification label contains incorrect information, stating a Gross Axle Weight Rating (GAWR) that exceeds the tire capacity rating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims-Other than passenger cars."

Consequence: Incorrect weight rating information on the certification labels could result in potential overloading of the axles, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will install accurate GAWR labels, free of charge. The recall began November 25, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-864.

Reported: 2020-10-27 (October 27, 2020) · Model years: 2021

Daimler Trucks North America LLC (DTNA) is recalling certain 2020-2021 Freightliner Cascadia, 2021 Freightliner 108SD, 114SD and Business Class M2 and Western Star 4700, 4900 and 5700 vehicles. The steer axle spindle nut snap-ring locking feature may be incorrectly installed or missing from the left spindle nut at the spindle.

Consequence: A missing or improperly installed locking snap ring can result in wheel-end failure and potentially a wheel-off/separation condition, increasing the risk of crash.

Remedy: DTNA will notify owners, and dealers will inspect the hub cap plug, and reinstall or replace of the snap-ring as needed, free of charge. The recall began December 18, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-866.

Reported: 2021-04-12 (April 12, 2021) · Model years: 2021, 2022

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2022 Freightliner Cascadia, Business Class M2, 114SD, 108SD, 122SD, Custom Chass S2 Chassis, Custom Chass XB Chassis, Custom Chass XC Chassis, and Custom Chass MT Chassis Western Star 4700, 4900, 5700 vehicles. The steering arm and tie rod bolts may have a defective seam that can fracture.

Consequence: A fractured bolt may cause a loss of steering, increasing the risk of a crash.

Remedy: DTNA will notify owners, and dealers will replace the tie rod arm and steering arm bolts, free of charge. The recall began on June 10, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-884.

Reported: 2021-05-19 (May 19, 2021) · Model years: 2021, 2022

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2022 Freightliner 114SD, 122SD, Business Class M2, Cascadia, 108SD, Western Star 4900, 4700, 5700, Custom Chass RV Chassis, Custom Chass S2 Chassis, Custom Chass XC Chassis, Custom Chass XB Chassis, and Custom Chass MT Chassis. The tie rod clamps may be loose, which could result in loose tie rod ends that could break or detach.

Consequence: Detached or broken tie rod ends can result in steering loss, increasing the risk of a crash.

Remedy: Dealers will replace the tie rod clamp bolts and nuts, free of charge. Owner notification letters were mailed December 23, 2021. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-888.

Reported: 2021-12-08 (December 8, 2021) · Model years: 2021, 2022

Daimler Trucks North America, LLC (DTNA) is recalling certain 2021-2022 Western Star 4900 vehicles. The steering shaft pinch bolt may not have been properly tightened, allowing the steering shaft to separate from the steering gear.

Consequence: Steering shaft separation may cause a loss of steering control, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the pinch bolt as necessary, free of charge. Owner notification letters were mailed on February 28, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-914.

Reported: 2022-04-20 (April 20, 2022) · Model years: 2022

Daimler Trucks North America, LLC (DTNA) is recalling certain 2022 Western Star 4900 and 4700 vehicles. The seat belts may not be secured properly.

Consequence: Improperly secured seat belts may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: All vehicles have been remedied, therefore no owner notification letters are necessary. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-927.

Reported: 2022-05-16 (May 16, 2022) · Model years: 2022

Daimler Trucks North America, LLC (DTNA) is recalling certain 2020 Freightliner Cascadia, 2020-2022 Western Star 4700 and 5700, 2022 Western Star 4900, and 2020-2023 Freightliner New Cascadia vehicles. The Gross Axle Weight Rating (GAWR) listed on the Federal Certification Label is incorrect, which can allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."

Consequence: An overloaded vehicle can increase the risk of a crash.

Remedy: Dealers will be replace the GAWR labels, free of charge. Owner notification letters were mailed July 14, 2022. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-933.

Reported: 2022-03-30 (March 30, 2022) · Model years: 2023

Daimler Trucks North America, LLC (DTNA) is recalling certain 2023 Western Star 4900 trucks. The inversion valve air lines may have been incorrectly installed, potentially reducing brake performance.

Consequence: Reduced brake performance increases the risk of a crash.

Remedy: All vehicles have been remedied, therefore no owner notification letters are necessary. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-924.

Reported: 2022-09-28 (September 28, 2022) · Model years: 2023

Daimler Trucks North America, LLC (DTNA) is recalling certain 2022-2023 Western Star 4700 and 2023 Western Star 4900, 49X, 6900, and Freightliner 114SD vehicles. The tie rod clamps may have been improperly heat-treated, causing them to crack and allowing the tie rods to separate.

Consequence: Tie rod separation can result in a sudden loss of steering, increasing the risk of a crash.

Remedy: Dealers will replace the tie rod clamps, free of charge. Owner notification letters were mailed Marc 15, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL955.

Reported: 2023-04-04 (April 4, 2023) · Model years: 2023

Daimler Trucks North America, LLC (DTNA) is recalling certain 2022 FCCC Shuttle Chassis, 2022-2023 FCCC RV Chassis, FCCC Van Chassis, Van Chassis Gas, 2023 Freightliner Cascadia, Freightliner Business Class M2, Thomas Built Bus School Bus Chassis, Western Star 4700, Western Star 47X, Western Star 4900, and Western Star 49X commercial buses. The tie rod may be missing a fastener, allowing the steer arm to detach.

Consequence: A detached steering arm can result in a sudden loss of steering control, increasing the risk of a crash.

Remedy: DTNA will inspect and repair or replace the tie rod assembly as necessary, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL970.

Reported: 2024-01-10 (January 10, 2024) · Model years: 2023

Daimler Trucks North America, LLC (DTNA) is recalling certain 2023 Western Star 4900 and Western Star 6900 vehicles. A defect in the inversion valve may delay park brake engagement, which could allow the vehicle to move unintentionally. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

Consequence: Unintentional vehicle movement can increase the risk of a crash or injury.

Remedy: DTNA will inspect and replace the inversion valves, as necessary free of charge. Owner notification letters were mailed February 27, 2024. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL992.