2005 Volvo S80: complaints, problems and recalls

1) EVENTS LEADING UP TO FAILURE: PURCHASED NEW VOLVO S80 CAR ON 9/3/2005 WITH 813 MILES, DROVE IT HOME. NO INFORMATION WAS GIVEN ON THE 813 MILES ALREADY ON THE CAR. THE NEXT DAY THERE WERE OIL PUDDLES UNDERNEATH CAR AND OIL WAS ALL OVER THE PASSENGER SIDE FRAME UNDERNEATH THE CAR. THE CAR WAS TAKEN IN FOR SERVICE TUES 9/6 MORNING FOR OIL LEAKING. THE LEAKING OIL PUMP AND SEALS WERE REPLACED. CAR WAS READY AND PICKED UP ON FRI EVENING 9/9. FROM TALKING WITH THE SERVICE PEOPLE THE OIL PUMP HAD BEEN CRACKED. THEY SAID THE CAR HAD BEEN CL…

Owner-reported narrative. 1,652 miles reported. Look up ODI 10137856 at NHTSA ↗

ON 07/21/07 I PURCHASED A 2005 VOLVO S80 T6 FROM MOMENTUM VOLVO IN HOUSTON, TX. IT WAS DELIVERED ON 08/02/2005 BRAND NEW WITH 7 MILES ON IT. THE FOLLOWING ARE AN ACCOUNT OF THE ISSUES AND SAFETY HAZARDS THIS CAR HAS HAD WITHIN THE LAST 18 MONTHS AND 24,000 MILES. THE FIRST ISSUE WAS DAMAGE FROM TRANSIT - FRONT AND REAR BUMPER HAD TO BE REPAIRED AND PAINTED. THE SECOND ISSUE - CHECK ENGINE LIGHT CAME ON 01/14/06. IT WAS AN EXHAUST LEAK. I ALSO COMPLAINED OF NO AM RECEPTION (FIXED) . THE THIRD ISSUE - CHECK ENGINE LIGHT CAME ON AGAIN ON 01…

Owner-reported narrative. 25 miles reported. Look up ODI 10187290 at NHTSA ↗

WHILE DRIVING ON AN INTERSTATE AT APPROXIMATELY 70MPH A VERY SLIGHT ROAD VIBRATION WAS FELT APPROXIMATELY 1 MINUTE BEFORE THE REAR DRIVER SIDE TIRE COMPLETELY FAILED. THERE WAS A LOUD AUDIBLE THUMP AS THE VEHICLE UNINTENTIONALLY JERKED TO THE LEFT. I WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND STOP SAFELY. UPON INSPECTION, BOTH SIDEWALLS OF THE TIRE HAD SEPARATED FROM TOP TREAD SECTION AND THE TIRE WAS IN THREE COMPLETE PIECES. THE WHEEL INCURRED MINOR DAMAGE. THE VEHICLE WAS NOT OVERLOADED. THE TIRE WAS BELIEVED TO BE AT THE CORRECT PRESSU…

Owner-reported narrative. 65,000 miles reported. Look up ODI 10376459 at NHTSA ↗

B+ BATTERY CABLE AT STARTER SOLENOID SHORTED TO STARTER CASE AND GROUNDED. CAUSING A FIRE IN ENGINE COMPARTMENT. CAR SHUT DOWN WITHOUT WARNING. ENGINE WENT OFF, LIGHTS WENT OUT ALL IN AN INSTANT. EMERGENCY FLASHERS WERE INOPERATIVE. PULLED OFF TO THE SIDE OF THE ROAD AND STOPPED USING THE EMERGENCY BRAKE. SMOKE WAS COMING FROM UNDER THE HOOD. OPENED THE HOOD AND FOUND THE FRONT OF THE ENGINE ON FIRE. EXTINGUISHED THE FLAMES. DISCONNECTED THE NEGATIVE TERMINAL ON THE BATTERY LOCATED IN THE TRUNK, CAR TOWED TO DEALER, IN PROCESS OF REPA…

Owner-reported narrative. 104,200 miles reported. Look up ODI 10415427 at NHTSA ↗

FUEL LEAK AT TOP OF PUMP UNDER RECALL, INSPECTION AND REPAIR AT NO COST REFUSED BY VOLVO. MY VOLVO S80, 2005 WAS PURCHASED AS A USED VEHICLE IN SAN DIEGO CA FROM THE VOLVO DEALER ABOUT 2 YEARS AGO. THE FUEL LEAK LOCATION WAS DIAGNOSED BY INDEPENDENT SHOP AND THEY CONFIRMED THE PUMP WAS UNDER RECALL. THE INDEPENDENT SHOP RECOMMEND TAKING THE CAR TO THE LOCAL DEALER FOR REPLACEMENT AT NO CHARGE UNDER THE NHTSA RECALL NOTICE. WHEN THE CAR WAS TAKEN TO THE LOCAL DEALER NO INSPECTION WAS PERFORMED AND I WAS TOLD THE RECALL NOTICE DID NOT APPLY…

Owner-reported narrative. 102,000 miles reported. Look up ODI 10501036 at NHTSA ↗

WE OWN A BEAUTIFUL 2005 VOLVO S80 T6 TOP OF THE LINE (FULLY LOADED, TWIN TURBOS,18" RIMS, METALLIC GREEN PAINT & PARKING SENSORS) ONLY 80,300 MILES. IT'S A $46,000 CAR UNFORTUNATELY IT IS NOT SAFE FOR THE ROAD AND IS A HAZARD TO ALL. IT CANNOT GO OVER SPEED BUMPS WITHOUT SHAKING EVERYONE INSIDE VIOLENTLY. WHEN DRIVING THE CAR THE TRANSMISSION WILL SLIP AND STUTTER AT LOW SPEEDS MEANING WE CANNOT MERGE INTO TRAFFIC! THERE IS ALSO COOLANT LEAKING EVERYWHERE AND SPILLING TO STORM DRAINS AND SEWERS LIST OF DIAGNOSED PROBLEMS: -TRANSMISSION REBU…

Owner-reported narrative. 80,435 miles reported. Look up ODI 10510471 at NHTSA ↗

TL* THE CONTACT OWNS A 2005 VOLVO S80. THE CONTACT STATED WHEN VEHICLE WAS PARK THE ENGINE ACCELERATED OWN ITS OWN. THE FAILURE OCCURRED NUMEROUS OF TIMES. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY WERE UNABLE TO DIAGNOSE A FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.

Owner-reported narrative. Look up ODI 10619365 at NHTSA ↗

TL* THE CONTACT OWNS A 2005 VOLVO S80. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STARTED TO RATTLE AND SMOKE WAS EMITTING FROM THE FRONT OF THE VEHICLE WITHOUT WARNING. THE CONTACT TRIED TO MERGE OVER TO THE SLOWER LANE AND DISCOVERED THAT THE BRAKE PEDAL HAD BECOME INOPERABLE. THE VEHICLE COASTED TO A STOP AND SHORTLY AFTER THE VEHICLE EXPLODED. A POLICE REPORT WAS FILED BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAI…

Owner-reported narrative. 118,000 miles reported. Look up ODI 10670225 at NHTSA ↗

Reported: 2005-11-17 (November 17, 2005)

ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, DUE TO AN ERROR IN THE FACTORY ASSEMBLY INSTRUCTION, THE B+TERMINAL MAY BE IN CONFLICT WITH THE STARTER MOTOR SOLENOID. IF THIS OCCURS, THE CONFLICT BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID MAY DEVELOP INTO A SHORT CIRCUIT OF THE BATTERY CABLE TO GROUND.

Consequence: SMOKE MAY APPEAR FROM UNDER THE HOOD AND IT MAY BE IMPOSSIBLE TO START THE CAR. IF THE SHORT CIRCUIT HAPPENS DURING DRIVING, ELECTRICAL POWER COULD BE LOST RESULTING IN THE WARNING LAMPS BEING DEACTIVATED. AN ELECTRICAL SHORT COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND INCREASE DISTANCE BETWEEN THE B+TERMINAL AND THE STARTER MOTOR SOLENOID BY ADJUSTING THE TERMINAL. THE RECALL BEGAN ON JANUARY 31, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Reported: 2006-10-03 (October 3, 2006)

CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.

Consequence: A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Reported: 2009-12-18 (December 18, 2009)

VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.

Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Reported: 2010-11-08 (November 8, 2010)

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

Reported: 2021-09-30 (September 30, 2021)

Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.

Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.